Batteries; Introduction; Battery Charger; Acid Burns - Quickie Xplore 2 Hybrid Owner's Manual

A.INTRODUCTION
1. Notes-
• Batteries supply the power for your chair. They contain a finite
amount of energy and have limits on how long they can store
and supply energy.
• You can charge batteries only a certain number of times before
they will fail and no longer hold a charge.
• For answers to questions about batteries, consult your supplier.
2. Use Proper Batteries:
Your chair operates on two 12 volt batteries.
• They should be Group 24 (or 22NF) size with a minimum of 50
ampere hour rating. Only deep cycle sealed case construction
batteries should be used in this device.
• Connecting configuration. They should have a post and clamp
style connection.
• When you buy a replacement, insist on a deep cycle sealed
case type. Do not use a car starter battery.
• Group 24 batteries are a minimum requirement for power
seating.
3. Breaking In:
• A battery requires "breaking-in" for the first 6 to 12 charges. It will
not accept a full charge for this period.
• It is best to limit the length of your trips until you break the
batteries in and you know the range of your chair.
4. Discharged Batteries:
• Never allow a battery to completely discharge. If you operate
your wheelchair until it has almost stopped, you will greatly
reduce the life of your batteries.
• Never let a battery sit in a discharged condition. Give unused or
stored batteries a full charge once per month.
• Always fully charge the batteries. Avoid "topping off " with
frequent charges.
WARNING
Never connect a life support or auxiliary device to a
wheelchair battery. The electrical system may fail, and
result in severe injury to or death of user.
B. BATTERY CHARGER
A battery charger produces a direct current (DC). When
applied to a discharged battery, this reverses the chemical
reaction that led to its discharge.
1. Charge Rate. How fast a battery will charge depends on:
• Its electrical capacity; state of charge; electrolyte temperature,
and; internal condition.
• The DC output of the charger. (The charge rate will vary if
the alternating current (AC) supply is higher or lower than 110
volts).
2. Caution — To Avoid Damage to the Charger:
• Never place the charger on top of a battery during charging.
(Gases from the battery can damage the charger and may lead
to an explosion or fire).
• Never place a battery on top of the charger.
• Never expose charger to rain or snow.
• Never unplug charger by pulling on the electrical cord. This
will damage the cord.
• Never open a charger or attempt to repair it yourself. Return
• Keep cord out of the way, where it will not be stepped on,
tripped over, or damaged.
Quickie Xplore 2 Owner's Manual
3. Caution — To Avoid Damage to the Battery:
• Make sure you use the correct setting for sealed (gel)
batteries (located on the off-board charger).
• Never charge a frozen battery. A fully charged battery will
rarely freeze, but the fluid in a discharged battery can freeze
at 16 degrees Fahrenheit (minus 9 degrees Centigrade). If you
suspect a battery is frozen, thaw it before charging.
WARNING
Lead acid batteries generate explosive gas while charging.
Completely read and follow all warnings about the batteries in this
user instruction manual and any labels applied to the product.
Failure to do so could result in fire, explosion, injury and/or death.
C. ACID BURNS (unsealed wet cell batteries)
Acid in batteries is corrosive. It can cause serious burns to the
eyes and skin and can damage floors, furniture, clothing and your
wheelchair.
WARNING
1. Use extreme care not to spill acid when you handle batteries.
Keep batteries upright.
2. Avoid contact of acid with bare skin or clothing.
3. Always wear rubber gloves and safety glasses when you
handle batteries.
4. If acid contacts your skin or clothing, wash immediately with
soap and water.
5. If acid contacts your eyes, immediately flood eyes with cold
running water for at least 15 minutes. Seek medical attention
immediately.
D. CONNECTING BATTERIES IN BATTERY
COMPARTMENT
WARNING
1. Batteries weigh up to 55 lbs. (25 kg). Take care to avoid injury
when lifting.
2. Keep batteries upright. Take care not to spill acid (wet cell

batteries).

3. Always wear rubber gloves and safety glasses when you
handle batteries.
4. Before working around batteries, remove all metal personal
effects, such as necklaces, rings, watches, pins and other metal
jewellery that might contact battery terminal and cause a short.
1. Lift batteries into battery compartment.
WARNING
Batteries weigh up to 55 pounds (25 kg). Lifting batteries may
cause back strain. If you fail to heed these warnings severe injury
may occur to you.
2. Connect and disconnect battery cables with caution. Connect
the red lead to the positive terminal and the black lead to the
negative terminal. Do this for each battery.
3. Tighten all terminal fasteners using two 1/2" box end
Rev. A
X. BATTERIES
28