Rules For Safe Operation; Important Safety Instructions; Before Operating; Safety Warnings For Gas Units - Troy-Bilt TB415CS Operator's Manual

READ ALL INSTRUCTIONS

BEFORE OPERATING

• Read the instructions carefully. Be familiar with the controls and
proper use of the unit.
• Do not operate this unit when tired, ill, or under the influence of
alcohol, drugs, or medication.
• Children and teens under the age of 15 must not use the unit,
except for teens guided by an adult.
• All guards and safety attachments must be installed properly before
operating the unit.
• Inspect the unit before use. Replace damaged parts. Check for fuel
leaks. Make sure all fasteners are in place and secure. Replace parts
that are cracked, chipped, or damaged in any way. Do not operate
the unit with loose or damaged parts.
• Carefully inspect the area before starting the unit. Remove all debris
and hard or sharp objects such as glass, wire, etc.
• Be aware of the risk of injury to the head, hands and feet.
• Clear the area of children, bystanders, and pets. At a minimum,
keep all children, bystanders, and pets outside a 50 feet (15 m.)
radius; there still may be a risk to bystanders from thrown objects.
Bystanders should be encouraged to wear eye protection. If you are
approached, stop the unit immediately.
• Use only 0.105 inch, 2.667 mm diameter original equipment
manufacturer replacement line. Never use metal-reinforced line,
wire or rope. These can break off and become dangerous
projectiles.
• Squeeze the throttle control and check that it returns automatically
to the idle position. Make all adjustments or repairs before using
unit.

SAFETY WARNINGS FOR GAS UNITS

• Store fuel only in containers specifically designed and approved for
the storage of such materials.
WARNING:
Gasoline is highly flammable, and its
vapors can explode if ignited. Take the following
precautions:
• Avoid creating a source of ignition for spilled fuel. Do not start the
engine until fuel vapors dissipate.
• Always stop the engine and allow it to cool before filling the fuel
tank. Never remove the fuel tank cap or add fuel when the engine is
hot. Never operate the unit without the fuel cap securely in place.
Loosen the fuel tank cap slowly to relieve any pressure in the tank.
• Add fuel in a clean, well-ventilated outdoor area where there are no
sparks or flames. Remove the fuel cap slowly, and only after the
engine stops. Do not smoke while fueling. Wipe up any spilled fuel
from the unit immediately.
• Avoid creating a source of ignition for spilled fuel. Do not start the
engine until fuel vapors dissipate.
• Move the unit at least 30 feet (9.1 m) from the fueling source and
site before starting the engine. Do not smoke. Keep sparks and
open flames away from the area while adding fuel or operating the
unit.
WHILE OPERATING
• Never start or run the unit inside a closed room or building.
Breathing exhaust fumes can be fatal. Operate this unit only in a
well-ventilated outdoor area.
• Wear safety glasses or goggles that meet ANSI Z87.1 standards and
are marked as such. Wear ear/hearing protection when operating
this unit. Wear a face or dust mask if the operation is dusty.
• Wear heavy long pants, boots, gloves and a long sleeve shirt. Do
not wear loose clothing, jewelry, short pants, sandals or go barefoot.
Secure hair above shoulder level.
• The cutting attachment shield must always be in place while
operating the unit as a trimmer. Do not operate unit without both

RULES FOR SAFE OPERATION

• IMPORTANT SAFETY INSTRUCTIONS •
• This unit does not have a clutch. The cutting attachment continues
• Adjust the handle to your size in order to provide the best grip.
• Be sure the cutting attachment is not in contact with anything before
• Use the unit only in daylight or good artificial light.
• Avoid accidental starting. Be in the starting position whenever pulling
• Use the right tool. Only use this tool for its intended purpose.
• Do not overreach. Always keep proper footing and balance.
• Always hold the unit with both hands when operating. Keep a firm
• Keep hands, face, and feet at a distance from all moving parts. Do
• Do not touch the engine, gear housing or muffler. These parts get
• Do not operate the engine faster than the speed needed to cut, trim
• Always stop the engine when cutting is delayed or when walking
• If you strike or become entangled with a foreign object, stop the
• Stop the unit, switch the engine to off, and disconnect the spark plug
• Use only original equipment manufacturer replacement parts and
• Keep unit clean of vegetation and other materials. They may become
• To reduce fire hazard, replace a faulty muffler and spark arrestor.
OTHER SAFETY WARNINGS
• Never store a fueled unit inside a building where fumes may reach an
• Allow the engine to cool before storing or transporting. Be sure to
• Store the unit in a dry area, locked up or up high to prevent
• Never douse or squirt the unit with water or any other liquid. Keep
• Keep these instructions. Refer to them often and use them to instruct
2
trimming lines extended, and the proper line installed. Do not extend
the trimming line beyond the length of the shield.
rotating when the engine is idling. If it does not, have the unit
adjusted by an authorized service technician.
starting the unit.
the starter rope. The operator and unit must be in a stable position
while starting. Refer to Starting/Stopping Instructions.
grip on both handles or grips.
not touch or try to stop the cutting attachment when it rotates.
extremely hot from operation, even after the unit is turned off.
or edge. Do not run the engine at high speed when not cutting.
from one cutting location to another.
engine immediately and check for damage. Do not operate before
repairing damage. Do not operate the unit with loose or damaged
parts.
for maintenance or repair.
accessories for this unit. These are available from your authorized
service dealer. Use of any unauthorized parts or accessories could
lead to serious injury to the user, or damage to the unit, and void
your warranty.
lodged between the cutting attachment and shield.
Keep the engine and muffler free from grass, leaves, excessive
grease or carbon build up.
open flame or spark.
secure the unit while transporting.
unauthorized use or damage, out of the reach of children.
handles dry, clean and free from debris. Clean after each use, see
Cleaning and Storage instructions.
other users. If you loan someone this unit, also loan them these
instructions.
SAVE THESE INSTRUCTIONS