Engine And Engine Parts; Cleaning Debris - Briggs & Stratton 280000 Operating & Maintenance Instructions

MAINTENANCE

ENGINE AND ENGINE PARTS

We recommend that you see an authorized Briggs & Stratton Service Dealer for all maintenance and service of the engine
and engine parts. Use only genuine Briggs & Stratton parts.
WARNING
WARNING
MUFFLER
Replacement parts for the muffler
WARNING
must be the same and installed in the
same position as the original parts,
otherwise fire can occur.
If muffler is equipped with spark arrester screen, remove
screen for inspection. Replace screen if damaged or
plugged.
SPARK PLUG
Use only Briggs & Stratton Spark Tester (part number
19368) to check for spark.
Note: In some areas, local
law requires using resistor
spark plug to suppress igni-
tion signals. If this engine
was originally equipped
with resistor spark plug,
use same type for replace-
ment.

CLEANING DEBRIS

WARNING
Engine parts should be kept clean to
reduce the risk of overheating and
ignition of accumulated debris. This is
especially important if cutting tall grass.
CAUTION: Do not use water to clean engine parts.
Water could contaminate fuel system. Use a brush
or dry cloth.
CLEAN
Finger Guard
If you perform any maintenance on the engine, first disconnect the spark plug wire
from the spark plug, and disconnect the battery at the negative terminal (electric
starter engines only) to prevent unintentional sparking. Unintentional sparking can
result in fire or electric shock. Unintentional start-up can result in entanglement,
traumatic amputation or laceration. Use only correct tools.
• Do not strike the flywheel with a hammer or hard object because the flywheel may
later shatter during operation.
• Do not tamper with governor spring, links or other parts to increase engine speed.
.030" (0.76 mm)
WIRE GAGE
CLEAN
Rotating Screen
14
REPLACE FUEL FILTER (if equipped)
EXTENDED LIFE SERIES
WARNING
PART NO. 695666 OR 5070
(WITH FUEL PUMP)
Drain fuel tank or close
fuel shut-off valve before
replacing fuel filter.
Otherwise, fuel can leak
out, creating a fire/ex-
plosion hazard.
AIR COOLING SYSTEM
Debris may clog the en-
gine's air cooling system.
Remove blower housing
and clean area shown to
prevent overheating and
engine damage.
Daily or before every use, clean grass, chaff or accumu-
lated debris from engine. Keep linkage, spring and
controls clean. Keep area around and behind muffler free
of any combustible debris.
CLEAN
Linkage, Springs,
Controls

FUEL FILTER
STANDARD FUEL FILTER
PART NO. 394358
(WITH FUEL PUMP)
PART NO. 298090 OR 5018
(WITHOUT FUEL PUMP)
FUEL HOSE
CLAMPS
CLEAN OUT CHAFF AND
DEBRIS
CLEAN
Muffler,
Spark Arrester