Initial Start Up - Scotsman MDT6N90 Installation And User Manual

MDT6N90 User Manual

INITIAL START UP

Pre Start Inspection
1. Remove the two front panels.
2. Check that all shipping blocks have been
removed.
3. Remove any and all packing tape (check inside
the storage bin).
4. Inspect the interior of the machine for loose
screws or wires. Check the solenoid operated door
over the ice discharge port for properly secured
linkage pins.
Check that no refrigerant lines are rubbing each
other. Check that the fan blade on air cooled
models turns freely.
5. Check that the machine is installed correctly
according to the final check list.
Start Up
1. Go through the pre start inspection.
2. Open the water hand valve, observe that water
enters the water reservoir, fills the tube from the
reservoir to the evaporator and then shuts off.
Check for leaks.
3. Switch the mode switch to ON. The auger drive
motor and compressor start, beginning the ice
making process.
4. On air cooled models, warm air will begin to flow
from the condenser. Water cooled models will
begin to discharge warm water down the drain.The
unit should soon be making ice.
5. There are no adjustments to make, so replace
the panels.
6. Check ice dispensing by placing a container in
front of the ice dispensing sensor, the dispensing
system should activate and if there is ice in the
machine it should dispense. Repeat for the water
dispense.
7. Switch off the icemaker-dispenser, remove the
top panel and the top of the ice storage bin.
Sanitize the interior of the ice storage bin with a
locally approved sanitizer. A possible sanitizer is a
mixture of 1 ounce of household bleach to 2
gallons of water. Wash the interior of the bin with
the sanitizing solution. Replace all covers and
panels. Switch the icemaker-dispenser back on.
8. Give the owner/user the service manual, instruct
him/her in the operation and maintenance
requirements of the unit. Make sure they know who
to call for service.
9. Fill out the Customer Evaluation and warranty
Registration form, and mail it in to Scotsman or
register on line at www.scotsman-ice.com.
September 2013
Page 7