Battery Service - Honeywell HW7000E Owner's Manual

Battery Service

To ensure the battery remains charged, it is recom-
mended that the generator is started every three months.
If the unit is stored for more than a year without running, a
battery charger may be required to recharge the generator
battery.
Recommended Battery Replacement: 101536A
Xtreme XTAX14AHL-BS
Yuasa 12N14-3A
TABLE 4. Replacement Battery Equivalents to 101536A
To replace battery:
1. Remove spark plug cap.
FIGURE 48: Spark Plug Cap Removal
Loosen and remove nuts on retaining plate; slide
2.
retaining plate off support rods.
FIGURE 49: Electric Start Battery—
Remove Retaining Plate
* See Maintenance Parts at the end of this manual.
HW7000E/HW7000EL Portable Electrical Generator Owner's Manual
Tip battery slightly forward.
3.
4. Disconnect the black negative (-) battery lead remov-
ing the boot, bolt, and nut.
*
FIGURE 50: Electric Start Battery—
Disconnect the red positive (+) battery lead removing
5.
the boot, bolt, and nut.
Remove the battery.
6.
NOTE:
Dispose of used battery according to guidelines estab-
lished by your local or state government.
Place the new battery in the generator frame.
7.
8. Connect the red positive (+) battery lead to the pos-
tive (+) post on the battery; install bolt, nut, and boot.
9. Connect the black negative (-) battery lead to the neg-
ative (-) post on the battery; install bolt, nut, and boot.
Reinstall retaining plate; tighten bolts and nuts.
10.
11. Reinstall spark plug cap.
Battery Service
Lead Connection
www.honeywellgenerators.com 27