Toro MM-658H-P Operator's Manual page 6

Preparation
Become familiar with the safe operation of the equipment,
operator controls, and safety signs.
•
Use only accessories and attachments approved by the
manufacturer.
•
Wear personal-protective equipment and appropriate
clothing including:
– Hard hat
– Respirator or dust mask
– Eye protection
– Hearing protection
– Safety shoes
– Long pants
– Shirt with long sleeves buttoned at the wrists
– Tight-fitting gloves without drawstrings or loose cuffs
•
Tie back long hair and do not wear jewelry.
•
Operating the equipment safely requires the full attention
of the operator. Do not wear radio or music headphones
while operating the machine.
•
Use extra care when handling fuels. They are flammable
and the vapors are explosive. Use the following practices
when handling fuel:
– Use only an approved fuel container.
– Never remove the fuel cap or add fuel with the engine
running.
– Allow the engine to cool before refueling.
– Do not smoke.
– Never refuel or drain the machine indoors.
– Replace the fuel cap and tighten it securely.
– Keep the container nozzle in contact with the tank
during filling.
– Never fill a container while it is inside a vehicle, trunk,
pick-up bed, or any surface other than the ground.
– Never store the machine or fuel container inside
where there is an open flame, such as near a water
heater or furnace.
– If fuel is spilled, wipe it off the engine and equipment.
•
Ensure that the machine is on a level surface before
operating the machine.
•
Ensure that you secure the machine to prevent unintended
movement.
•
Before every use:
– Inspect the coupler, ball, and hitch.
– Ensure that all lights are functioning properly (if
equipped with a light kit).
– Ensure that the tires are properly inflated as
recommended.
– Ensure that the lug nuts are tight and torqued
properly.
– Ensure that the machine is properly secured.
Operation
•
Never run an engine in an enclosed or poorly ventilated
area.
•
Only operate the machine in good lighting conditions.
•
Before starting the machine, make sure that there are no
persons or obstacles near or under the machine.
•
Shut off the engine before leaving the machine for any
reason.
Never leave a running machine unattended. Always
shut off the engine and verify that all moving parts have
stopped.
•
Ensure that the machine is secure from movement or
keep it attached to the towing vehicle when it is not in
use, to prevent it from rolling.
•
Avoid prolonged breathing of exhaust fumes.
Engine-exhaust fumes can cause sickness or death.
•
Keep hands away from any moving parts. Keep feet away
from the tires and the front post.
•
Do not operate the machine under the influence of
alcohol or drugs.
•
Ensure that the area is clear of other people or pets before
operating the machine. Stop the machine if anyone enters
the area.
•
Never place your hands or any solid object into the drum
when the machine is in operation.
•
Do not touch parts which may be hot from operation.
Allow them to cool before attempting to maintain, adjust,
or service the machine.
•
Never move the machine while the engine is running.
•
Keep the cowl closed and latched during operation.
•
Ensure that all the guards and shields are securely in place
before operating the machine.
•
Disconnect the spark-plug wire and keep it away from the
spark plug to prevent accidental starting while maintaining
the machine.
•
If the mixing paddles strike a foreign object or if the
machine should start making an unusual noise or
vibration, shut off the engine and empty the drum. Wait
for all moving parts to come to a complete stop and cool.
Vibration is generally a warning of trouble. Disconnect
the spark-plug wire and inspect for clogging or damage.
Clean and repair and/or replace damaged parts.
•
Do not change the engine-governor setting or overspeed
the engine.
•
Lightning can cause severe injury or death. If you see
lightning or hear thunder in the area, do not operate the
machine; seek shelter.
Maintenance and Storage
•
Before performing maintenance, do the following:
– Park the machine on level ground.
6