Sharp LC-32LE511E Service Manual
  1. Manuals
  2. Brands
  3. Sharp Manuals
  4. LED TV
  5. LC-32LE511E
  6. Service manual

Sharp LC-32LE511E Service Manual

Led lcd tv
Hide thumbs Also See for LC-32LE511E:
Table of Contents

Advertisement

Quick Links

See also: Operating Manual
50mm
40mm
DVB-T / DVB-C (HDTV), PAL
31.5mm
25mm
20mm

TABLE OF CONTENTS .......................................................................................................................

ELECTRICAL SPECIFICATIONS ........................................................................................................
IMPORTANT SERVICE SAFETY PRECAUTIONS .............................................................................
OPERATION MANUAL .......................................................................................................................... 10
DIMENSIONS ..................................................................................................................................... 19
INTRODUCTION ................................................................................................................................. 21
CIRCUIT DESCRIPTIONS ....................................................................................................................... 22
SOFTWARE UPDATE ........................................................................................................................... 70
TROUBLESHOOTING................................................................................................................... 70
SERVICE MENU SETTINGS .......................................................................................................... 78
GENERAL BLOCK DIAGRAM ........................................................................................................... 80
OVERAL WIRING BOARD ....................................................................................................... 81
SCHEMATIC DIAGRAMS ............................................................................................................. 84
PRINTED WIRING BOARD ............................................................................................................ 101
REPLACEMENT PARTS LISTING ...................................................................................................... 103
CABINET AND MECHANICAL PARTS LIST ........................................................................................ 149
1st Edition
/ SECAM
B/G, I
In the interests of user safety (required by safety
regulations in some countries) the set should be re-
stored to its original condition and only parts identical
to those specified should be used.
CONTENTS
SERVICE MANUAL
LED LCD
COLOUR TELEVISION
SYSTEM COLOUR TELEVISION
B/G, D/K, L/L'
MODEL
LC-32LE511E
LC-40LE511E
LC-40LE531E
1
LC-32LE511
LC-40LE511
LC-40LE531
Issued: 19 July 2011
MB70 CHASSIS
This document has been published to
be used for after sales service only.
The contents are subject to change without notice.
LC
LC
LC
2
4
7

Advertisement

Table of Contents
loading

Related Manuals for Sharp LC-32LE511E

Summary of Contents for Sharp LC-32LE511E

  • Page 1: Table Of Contents

    B/G, D/K, L/L’ 31.5mm MB70 CHASSIS 25mm MODEL 20mm LC-32LE511E LC-40LE511E LC-40LE531E In the interests of user safety (required by safety regulations in some countries) the set should be re- stored to its original condition and only parts identical to those specified should be used.
  • Page 2 LC-32LE511 LC-40LE511 LC-40LE531 i. SPECIFICATIONS ........................4 ii. IMPORTANT SERVICE SAFETY PRECAUTIONS ................ 7 iii. OPERATION MANUAL ......................10 iv. DIMENSIONS ........................17 1. INTRODUCTION ........................20 2. TUNER ..........................21 3. AUDIO AMPLIFIER STAGES ....................23 A. MAIN AMPLIFIER (TPA3110) ....................23 B.
  • Page 3 LC-32LE511 LC-40LE511 LC-40LE531 B. CI Module Problem ....................... 69 C. Staying in Stand-by Mode ..................... 70 D. IR Problem ........................71 E. Keypad Touchpad Problems ..................72 F. USB Problems ........................ 73 G. No Sound Problem ....................... 73 H. Standby On/Off Problem ....................73 I.

  • Page 4: Specifications

    Cautions regarding use in high and low temperature environments • As a part of our policy of continuous im- provement, SHARP reserves the right to • When the unit is used in a low temperature space (e.g. room, offi ce), the make design and specifi cation changes picture may leave trails or appear slightly delayed.

  • Page 5: Electrical Specifications

    • As a part of our policy of continuous im- 576p) Transmission Standards: Proles provement, SHARP reserves the right to • When the unit is used in a low temperature space (e.g. room, offi ce), the DVB-T, MPEG2,DVB-T, MPEG4 HD - MPEG-4 H.264/AVC HP@L 4.0, MP@L 4.0 (HD)
  • Page 6 • As a part of our policy of continuous im- 576p) Transmission Standards: Proles provement, SHARP reserves the right to • When the unit is used in a low temperature space (e.g. room, offi ce), the DVB-T, MPEG2,DVB-T, MPEG4 HD - MPEG-4 H.264/AVC HP@L 4.0, MP@L 4.0 (HD)

  • Page 7: Important Service Safety Precautions

    LC-32LE511 LC-40LE511 LC-40LE531 IMPORTANT SERVICE SAFETY PRECAUTION Service work should be performed only by qualified service technicians who are thoroughly familiar with all safety checks and the servicing guidelines which follow: WARNING 1. For continued safety, no modification of any circuit should be attempted. 2.
  • Page 8 LC-32LE511 LC-40LE511 LC-40LE531 PRECAUTIONS FOR USING LEAD-FREE SOLDER 1 Employing lead-free solder “ALL PWB” of this model employs lead-free solder. The LF symbol indicates lead-free solder, and is attached on the PWBs and service manuals. The alphabetical character following LF shows the type of lead-free solder. Example: Indicates lead-free solder of tin, silver and copper.
  • Page 9 If the product is used for business purposes and you want to discard it: Please contact your SHARP dealer who will inform you about the take-back of the product. You might be charged for the costs arising from take-back and recycling. Small products (and small amounts) might be taken back by your local collection facilities.

  • Page 10: Operation Manual

    LC-32LE511 LC-40LE511 LC-40LE531 OPERATION MANUAL Remote Control Buttons Standby Image size Sleep Timer Mono/Stereo - Dual I-II / Currrent Language (*) (in DVB channels) / Play preview (in Media Browser mode) Favourite Mode Selection (in DVB channels) Numeric buttons Electronic programme guide(in DVB channels) No function Media Browser Navigation buttons (Up/Down/Left/Right)
  • Page 11 LC-32LE511 LC-40LE511 LC-40LE531 Operation Manual (Continued) LCD TV and Operating Buttons FRONT and REAR VIEW Control buttons VIEW Control Buttons Standby/On button TV/AV button Programme Up/Down buttons Volume Up/Down buttons Standby-LED The Power-switch is used for turning the TV “Off” or into “Standby-Mode”...
  • Page 12 LC-32LE511 LC-40LE511 LC-40LE531 Operation Manual (Continued) PC/YPbPr Audio Inputs are used for connecting audio signals of a PC or a device that connects to the TV via YPbPr. Connect the PC audio cable between the AUDIO INPUTS on the TV and audio output of your PC to enable PC audio.

  • Page 13: Power Connection

    LC-32LE511 LC-40LE511 LC-40LE531 Operation Manual (Continued) USB Disk Connection Power Connection • Plug your USB device to the USB input of the TV. IMPORTANT: The TV set is designed to operate on Note: Plug or unplug your USB disk while the TV is 220-240V AC, 50 Hz socket.
  • Page 14 LC-32LE511 LC-40LE511 LC-40LE531 Operation Manual (Continued) • For more information on recording programmes, Side HDMI Connection (HDMI 4) see sections “Instant Recording”, “Timeshifting”, The side HDMI is convenient connection for external “Electronic Programme Guide”, “Recordings Library” HDMI devices, use an appropriate HDMI cable and or “Recording Timers”...

  • Page 15: Using Side Av Connectors

    LC-32LE511 LC-40LE511 LC-40LE531 Operation Manual (Continued) Connecting to a DVD Player Using Side AV Connectors If you want to connect a DVD player to your LCD You can connect a range of optional equipment to your TV, you can use connectors of the TV set. DVD LED TV using side connectors of the TV.

  • Page 16: Remote Control Handset

    LC-32LE511 LC-40LE511 LC-40LE531 Operation Manual (Continued) To Switch the TV Off Remote Control Handset • Switch the “ ” button bottom right edge under the • Remove the battery cover located on the back of the remote control by gently pulling backwards from screen to position 2 as illustrated, to isolate the the indicated part.

  • Page 17: Dimensions

    LC-32LE511 LC-40LE511 LC-40LE531 DIMENSIONS LC-32LE511 Dimensional Drawings Speci cations TV BROADCASTING PAL/SECAM B/G D/K K’ I/I’ L/L’ RECEIVING CHANNELS VHF (BAND I/III) • UHF (BAND U) • HYPERBAND • NUMBER OF PRESET CHANNELS 10.000 • CHANNEL INDICATOR On Screen Display •...
  • Page 18 LC-32LE511 LC-40LE511 LC-40LE531 DIMENSIONS LC-40LE511E Dimensional Drawings Specifi cations TV BROADCASTING PAL/SECAM B/G D/K K’ I/I’ L/L’ RECEIVING CHANNELS VHF (BAND I/III) UHF (BAND U) HYPERBAND NUMBER OF PRESET CHANNELS 10.000 CHANNEL INDICATOR On Screen Display RF AERIAL INPUT 75 Ohm (unbalanced) OPERATING VOLTAGE 220-240V AC, 50 Hz.
  • Page 19 LC-32LE511 LC-40LE511 LC-40LE531 DIMENSIONS LC-40LE531E Dimensional Drawings Specications TV BROADCASTING PAL/SECAM B/G D/K K’ I/I’ L/L’ RECEIVING CHANNELS VHF (BAND I/III) UHF (BAND U) HYPERBAND NUMBER OF PRESET CHANNELS 10.000 CHANNEL INDICATOR On Screen Display RF AERIAL INPUT 75 Ohm (unbalanced) OPERATING VOLTAGE 220-240V AC, 50 Hz.

  • Page 20: Introduction

    LC-32LE511 LC-40LE511 LC-40LE531 INTRODUCTION 1. INTRODUCTION 17MB70-2 mainboard is based on Broadcom concept IC. This IC combines DVB-T COFDM terrestrial and PAL/SECAM demodulators, HDMI receivers, a transport processor, a digital audio processor, graphics processing, Ethernet MAC and PHY, digital processing of analog video and audio, analog video digitizer and DAC functions, stereo high-fidelity audio DACs, a 400-MHz dual-threaded MIP processor, and a peripheral control unit providing a variety of television control functions.

  • Page 21: Circuit Descriptions

    LC-32LE511 LC-40LE511 LC-40LE531 CIRCUIT DESCRIPTIONS Sound system output is supplying 2x8W (10%THD) for stereo 8��speakers Supported peripherals are: x 1 RF input VHF I, VHF III, UHF @ 75Ohm(Common) x 1 Side AV (CVBS, R/L_Audio) x 2 SCART socket(Common) x 1 YPbPr (Common) x 1 Side S-Video(Common) x 1 PC input(Common) x 4 HDMI 1.3 input(Common)
  • Page 22 LC-32LE511 LC-40LE511 LC-40LE531 Active Antenna Circuit 1.1. Features of FT2112 • Digital DVB-T T2, DTMB & analogue (48.25MHz to 863.25MHz) reception • Single 5V supply voltage only • Built-in 5-33V DC-DC converter • Single power supply to the RF tuner & IF VGA amplifier section •...

  • Page 23: Audio Amplifier Stages

    LC-32LE511 LC-40LE511 LC-40LE531 1.2.Tuner Pinning 3. AUDIO AMPLIFIER STAGES A. MAIN AMPLIFIER (TPA3110) a. General Description 17MB70 uses TPA 3110 15-W filter-free stereo Class-D audio power amplifier for main audio output. The TPA3110D2 is a 15-W (per channel) efficient, Class-D audio power amplifier for driving bridged-tied stereo speakers.
  • Page 24 LC-32LE511 LC-40LE511 LC-40LE531 The TPA3110D2 can drive stereo speakers as low as 4 ���������������������y of the TPA3110D2, 90%, eliminates the need for an external heat sink when playing music. The outputs are also fully protected against shorts to GND, VCC, and output-to-output. The short- circuit protection and thermal protection includes an auto-recovery feature.
  • Page 25 LC-32LE511 LC-40LE511 LC-40LE531 d. Recommended Operating Conditions e. Pin Functions I/O/P DESCRIPTION NAME Number Shutdown logic input for audio amp (LOW = outputs Hi-Z, HIGH = outputs enabled). TTL logic levels with compliance to AVCC. Open drain output used to display short circuit or dc detect fault status. Voltage compliant to AVCC.

  • Page 26: Line-Out And Head-Phone Amplifier Stage (Cxa3813N)

    LC-32LE511 LC-40LE511 LC-40LE531 B. LINE-OUT and HEAD-PHONE AMPLIFIER STAGE (CXA3813N) a. Functional Block Diagram b. Absolute Ratings c. Recommended Operating Conditions...

  • Page 27: Subwoofer Amplifier Stage (Tpa3112)

    LC-32LE511 LC-40LE511 LC-40LE531 d. Pin Functions C. SUBWOOFER AMPLIFIER STAGE (TPA3112) a. General Description The TPA3112D1 is a 25-W efficient, Class-D audio power amplifier for driving a bridge tied speaker. Advanced EMI Suppression Technology enables the use of inexpensive ferrite bead filters at the outputs while meeting EMC requirements.
  • Page 28 LC-32LE511 LC-40LE511 LC-40LE531 c. Absolute Ratings d. Recommended Operating Conditions e. Pin Functions...

  • Page 29: Power Stage

    LC-32LE511 LC-40LE511 LC-40LE531 4. POWER STAGE 17MB70 general power managment block diagram is shown below. 17PW26 power board is used in 32” 17MB70 TV sets. 3,3V stby, 5V stby, 3,3V, 5V, 12V, 24V and 33V can be generated by PW26. Below blocks are generated by step- downs and regulators on MB70 board.
  • Page 30 LC-32LE511 LC-40LE511 LC-40LE531 Power Blocks on MB70: Below blocks are generated by step-downs and regulators on MB70 board.
  • Page 31 LC-32LE511 LC-40LE511 LC-40LE531 FAIRCHILD FAN2110 (U19-U20) a) General Description...
  • Page 32 LC-32LE511 LC-40LE511 LC-40LE531 Pin Configuration Figure 3. MLP 5x6mm Pin Configuration (Bottom View) Pin Definitions Pin # Name Description P1, 6-12 Switching Node. Junction of high-side and low-side MOSFETs. P2, 2-5 Power Input Voltage. Connect to the main input power source. P3, 21-23 PGND Power Ground.
  • Page 33 LC-32LE511 LC-40LE511 LC-40LE531 Absolute Maximum Ratings Stresses exceeding the absolute maximum ratings may damage the device. The device may not function or be operable above the recommended operating conditions and stressing the parts to these levels is not recommended. In addition, extended exposure to stresses above the recommended operating conditions may affect device reliability.
  • Page 34 LC-32LE511 LC-40LE511 LC-40LE531 Fault condition protection includes cycle-by-cycle current limiting and thermal shutdown. An adjustable soft-start reduces the stress on the input source at startup. In shutdown mode the regulator draws 20μA of supply current. The MP1583 requires a minimum number of external components, providing a compact solution.
  • Page 35 LC-32LE511 LC-40LE511 LC-40LE531 cycle for low dropout applications. With peak current mode control and internal compensation, the MP2012 is stable with ceramic capacitors and small inductors. Fault condition protection includes cycle-by-cycle current limiting and thermal shutdown. MP2012 is available in the small 6-pin 3mmx3mm QFN package. x 2.7-6V Input Operation Range x Output Adjustable from 0.8V to VIN x ��������������������������...

  • Page 36: Microcontroller(Broadcom)

    LC-32LE511 LC-40LE511 LC-40LE531 5. MICROCONTROLLER(Broadcom) BCM3556 a) General Description The BCM3556 is the next generation of System-on-a-Chip (SoC) Digital Television (DTV) products from Broadcom® with 1080p60 input and output capability targetedfor the EU Market. It combines a high level of integration with best-of-class picture quality, enabling TV manufacturers to reduce overall system cost (BOM) and improve picture quality, all with a single SoC.
  • Page 37 LC-32LE511 LC-40LE511 LC-40LE531 The BCM3556 supports direct PC inputs up to UXGA 1600x1200 formats with autophase and automode detection and supports dual LVDS outputs to support 1080p60 panels. The BCM3556 integrates a 400-MHz 32-bit MIPS dual CPU with two 32-KB instructioncaches and a combined 64-KB data cache with a 128-KB L2 cache, and a 32-bit 800/1066-MHz DDR2.
  • Page 38 LC-32LE511 LC-40LE511 LC-40LE531 c) BCM3556 - Block Diagram...

  • Page 39: Video Back-End Processor (Trident)

    LC-32LE511 LC-40LE511 LC-40LE531 6. VIDEO BACK-END PROCESSOR (Trident) PNX5120EH a) General Description The PNX5120EH is an advanced video picture improvement IC and the world's first solution, NXP’s Motion Accurate Picture Processing (MAPP), to combine movie judder cancellation, motion sharpness and vivid color management in a single device. Aimed primarily at digital and hybrid flat panel televisions in the mid-end and high-end European,Asian and U.S.

  • Page 40: Fpga (Spartan-3E)

    LC-32LE511 LC-40LE511 LC-40LE531 7. FPGA (Spartan-3E) XC3S1200E a) General Description The Spartan™-3E family of Field-Programmable Gate Arrays (FPGAs) is specifically designed to meet the needs of high volume, cost-sensitive consumer electronic applications. The five-member family offers densities ranging from 100,000 to 1.6 million system gates,...
  • Page 41 LC-32LE511 LC-40LE511 LC-40LE531 The Spartan-3E family builds on the success of the earlier Spartan-3 family by increasing the amount of logic per I/O, significantly reducing the cost per logic cell. New features improve system performance and reduce the cost of configuration. These Spartan-3E enhancements, combined with advanced 90 nm process technology, deliver more functionality and bandwidth per dollar than was previously possible, setting new standards in the programmable logic industry.

  • Page 42: Gb F-Die Ddr2-1066 Sdram (U41-U42-U8-U9)

    LC-32LE511 LC-40LE511 LC-40LE531 • Low-cost QFP and BGA packaging options - Common footprints support easy density migration - Pb-free packaging options 8. 1Gb F-die DDR2-1066 SDRAM (U41-U42-U8-U9) Samsung K4T1G084QF a) Key Features • JEDEC standard VDD = 1.8V ± 0.1V Power Supply •VDDQ = 1.8V ±...
  • Page 43 LC-32LE511 LC-40LE511 LC-40LE531 bus is used to convey row, column, and bank address information in a RAS/CAS multiplexing style. For example, 1Gb(x8) device receive 14/10/3 addressing. The 1Gb DDR2 device operates with a single 1.8V ± 0.1V power supply and 1.8V ± 0.1V VDDQ.

  • Page 44: M X 16 Bit Ddrii Synchronous Dram (U28-U29)

    LC-32LE511 LC-40LE511 LC-40LE531 9. 32M x 16 bit DDRII Synchronous DRAM (U28-U29) EtronTech EM68B16CWPA a) Key Features • JEDEC Standard Compliant • JEDEC standard 1.8V I/O (SSTL_18-compatible) • Power supplies: VDD & VDDQ = +1.8V ± 0.1V • Operating temperatue: 0 – 85 °C •...
  • Page 45 LC-32LE511 LC-40LE511 LC-40LE531 The EM68B16C is a high-speed CMOS Double-Data-Rate-Two (DDR2), synchronous dynamic random-access memory (SDRAM) containing 512 Mbits in a 16-bit wide data I/Os. It is internally configured as a quad bank DRAM, 4 banks x 8Mb addresses x 16 I/Os The device is designed to comply with DDR2 DRAM key features such as posted CAS# with additive latency, Write latency = Read latency -1, Off-Chip Driver (OCD) impedance adjustment, and On Die Termination(ODT).

  • Page 46: Gbit Nand Flash Memory (U35)

    LC-32LE511 LC-40LE511 LC-40LE531 4Gbit NAND Flash Memory (U35) ST NAND04G-B2D a) Key Features �������������������������������� – Up to 8 Gbit memory array – Up to 8 Gbit memory array – Cost-effective solution for mass storage – Cost-effective solution for mass storage applications applications ������������face...
  • Page 47 LC-32LE511 LC-40LE511 LC-40LE531 b) Pinning...

  • Page 48: Mbit Nand Flash Memory (U17)

    LC-32LE511 LC-40LE511 LC-40LE531 128Mbit NAND Flash Memory (U17) ST NAND128-A a) Key Features �������������������������� ������������������ MEMORIES – Block erase time: 2ms (Typ) – Up to 1 Gbit memory array ����������������� – Up to 32 Mbit spare area ���������������������� – Cost effective solutions for mass storage ���������������������������...

  • Page 49: Usb Interface

    LC-32LE511 LC-40LE511 LC-40LE531 V SS I/O15 I/O7 I/O14 I/O7 I/O6 I/O6 I/O13 I/O5 I/O5 I/O4 I/O12 I/O4 NAND Flash NAND Flash V DD V DD V DD V DD (x8) (x16) V SS V SS V SS I/O11 I/O3 I/O3 I/O2 I/O10 I/O1...

  • Page 50: Ci Interface

    LC-32LE511 LC-40LE511 LC-40LE531 CI Interface 17MB70 Digital CI ve Smart Card Interface Block diagram: DVB-C/T2 Demodulator Sony CXD2820R a) Key Features DESCRIPTION The Sony CXD2820R is a combined DVB-T2, DVB-T and DVB-C demodulator that conforms to the ETSI EN 302-755 (second generation Terrestrial) ETSI EN 300-744 (Terrestrial) and ETSI EN 300-429 (Cable) standards.
  • Page 51 LC-32LE511 LC-40LE511 LC-40LE531 • Stream processor for automatic common- and data-PLP combination • Null-packet insertion • Access to channel echo profile and constellation via I2C FEATURES DVB-C • Wide symbol range, 0.7 to 7.2Msym/s • Integrated matched filter 0.15 roll-off factor •...
  • Page 52 LC-32LE511 LC-40LE511 LC-40LE531 A I N P / A I N M 1 2 - b i t A D C L D P C / D V B - T 2 S t r e a m B C H C o r e P r o c e s s o r D e c o d e r...
  • Page 53 LC-32LE511 LC-40LE511 LC-40LE531 5V tolerant GPIO0 General purpose I/O Controllable pull-up TS error flag 5V tolerant TSERR _GPIO2 General purpose I/O Controllable pull-up Controllable pull-up TSSYNC TS sync flag Selectable output current Controllable pull-up TSVALID TS valid flag Selectable output current Controllable pull-up TSCLK TS clock output...
  • Page 54 LC-32LE511 LC-40LE511 LC-40LE531 CXD2820R Name Function Equivalent Circuit Note Controllable pull-up TSDATA4 TS data output Selectable output current Controllable pull-up TSDATA5 TS data output Selectable output current Controllable pull-up TSDATA6 TS data output Selectable output current Controllable pull-up TSDATA7 TS data output Selectable output current Digital Ground 3.3V digital power...
  • Page 55 LC-32LE511 LC-40LE511 LC-40LE531 CXD2820R Name Function Equivalent Circuit Note supply MVSS Digital Ground PVSS Analog Ground 1.2V analog power PVDD Supplies PLL power supply 2.5V analog power Supplies crystal oscillator XVDD supply power Leave open when external XTALO Crystal oscillator output clock input to XTALI XTALI Crystal oscillator input...

  • Page 56: Low Power&Cec Microcontroller

    LC-32LE511 LC-40LE511 LC-40LE531 LOW POWER&CEC MICROCONTROLLER NEC uPD78F0503 Pinning...

  • Page 57: Hdmi Switch

    LC-32LE511 LC-40LE511 LC-40LE531 CEC Circuit Design for CEC option: 3V3_STBY R1008 3V3_STBY R1001 C924 U115 LM358D 1 OUT1 3V3_STBY UC_CEC IN1- OUT2 IN1+ IN2- IN2+ R1000 C921 R1007 C925 R1003 470R 100n Q129 CEC_OUT 220R BC848B R1006 3V3_STBY R997 3V3_STBY HDMI SWITCH Silicon Image SiI9287B a) Key Features...
  • Page 58 LC-32LE511 LC-40LE511 LC-40LE531 b) Block Diagram...
  • Page 59 LC-32LE511 LC-40LE511 LC-40LE531 Figure 8. Pin Diagram...
  • Page 60 LC-32LE511 LC-40LE511 LC-40LE531 Pin Name Description R0X0P TMDS Input TMDS input Port 0 data pair for HDMI and MHL. R0X0N R0X1P TMDS Input TMDS input Port 0 data pairs for HDMI. R0X1N R0X2P R0X2N R0XCP TMDS Input TMDS input Port 0 clock pair for HDMI and MHL. R0XCN R1X0P TMDS...
  • Page 61 Signal Name Type Description LC-32LE511 TX0P TMDS Output HDMI Output Port Data. LC-40LE511 TMDS Low Voltage Differential Signal output data pairs. TX0N LC-40LE531 TX1P TX1N TX2P TX2N TXCP TMDS Output HDMI Output Port Clock. TMDS Low Voltage Differential Signal output clock pair. TXCN Pin Name Type...
  • Page 62 this pin is used as the TPWR output, indicating that the selected HDMI input LC-32LE511 port is receiving an active TMDS clock. This pin has an internal pull-up to the MICOMVCC33 power supply. If this signal is pulled-down, a 4.7K ohm LC-40LE511 resistor should be used.

  • Page 63: Lnb Supply And Control Ic

    LC-32LE511 LC-40LE511 LC-40LE531 LNB supply and control IC ST LNBH23L a) Key Features �������������������������������������������� �������-in DC-DC converter for single 12 V supply operation and high efficiency (typ. 93% @0.5 A) ������������������������������������������������������ ����������������������������������������������������������pecification ������������������������������������������������������������������������ ����������������-in 22 kHz tone generator suits widely accepted standards �����-drop post regulator and high efficiency step-up PWM with integrated power NMOS allow low power losses �������������������-temperature internal protections with I²C diagnostic bits...

  • Page 64: Software Update

    LC-32LE511 LC-40LE511 LC-40LE531 b) Block Diagram Software Update 18.1 Main SW update In MB70 project you can update the main IC software by using USB ports. You can find the SW update procedure below. 1. Software files should copy directly inside of a flash memory(not in a folder). 2.

  • Page 65: Software Update

    5. Please choose “USB Operations” tab to update standby-micro sw file by using remote controler. 6. Please wait approximately for 30 seconds To reach the latest sw files please use; https://www.vestelservice.com/100359/New_Projects/Sharp/Sharp_2011/9_Customer _support/SW/ Troubleshooting A. No Backlight Problem Problem: If TV is working, led is normal and there is no picture and backlight on the panel.

  • Page 66: Troubleshooting

    LC-32LE511 https://www.vestelservice.com/100359/New_Projects/Sharp/Sharp_2011/9_Customer LC-40LE511 _support/SW/ LC-40LE531 TROUBLESHOOTING Troubleshooting A. No Backlight Problem Problem: If TV is working, led is normal and there is no picture and backlight on the panel. Possible couses: Backlight pin, dimming pin, backlight supply, stby on/off pin BACKLIGHT_ON/OFF pin should be high when the backlight is ON.
  • Page 67 LC-32LE511 LC-40LE511 LC-40LE531 Dimming pin should be high or square wave in open position. If it is low, please check S32 for BRCM side and panel or power cables, connectors.
  • Page 68 LC-32LE511 LC-40LE511 LC-40LE531 STBY_ON/OFF_NOT should be high for standby condition, please check R203. B. CI Module Problem Problem: CI is not working when CI module inserted. Possible couses: Supply, suply control pin, detect pins, mechanical positions of pins.

  • Page 69: Ci Module Problem

    LC-32LE511 LC-40LE511 LC-40LE531 B. CI Module Problem Problem: CI is not working when CI module inserted. Possible couses: Supply, suply control pin, detect pins, mechanical positions of pins. x CI supply should be 5V when CI module inserted. If it is not 5V please check CI_PWR_CTRL, this pin should be low.

  • Page 70: Staying In Stand-By Mode

    LC-32LE511 LC-40LE511 LC-40LE531 C. Staying in Stand-by Mode Problem: Staying in stand-by mode, no other operation This problem indicates a short on Vcc voltages. Protect pin should be logic high while normal operation. When there is a short circuit protect pin will be logic low. If you detect logic low on protect pin, unplug the TV set and control voltage points with a multimeter to find the shorted voltage to ground.

  • Page 71: Ir Problem

    LC-32LE511 LC-40LE511 LC-40LE531 D. IR Problem Problem: LED or IR not working Check LED card supply on MB70 chasis.

  • Page 72: Keypad Touchpad Problems

    LC-32LE511 LC-40LE511 LC-40LE531 E. Keypad Touchpad Problems Problem: Keypad or Touchpad is not working Check keypad supply on MB70.

  • Page 73: Usb Problems

    LC-32LE511 LC-40LE511 LC-40LE531 F. USB Problems Problem: USB is not working or no USB Detection. Check USB Supply, It should be nearly 5V. Also USB Enable should be logic high. G. No Sound Problem Problem: No audio at main TV speaker outputs. Check supply voltages of VDD_AUDIO, 8V_VCC and 12V_VCC with a voltage-meter.

  • Page 74: No Signal Problem

    LC-32LE511 LC-40LE511 LC-40LE531 to check SW printouts via Teraterm. These printouts may give a clue about the problem. You can use Scart-1 for terraterm connection. I. No Signal Problem Problem: No signal in TV mode. Check tuner supply voltage; 5V_TUN. Check tuner options are correctly set in Service menu. Check AGC voltage at RF_AGC pin of tuner.

  • Page 75: Lc Lc Lc

    LC-32LE511 LC-40LE511 LC-40LE531 SERVICE MENU SETTINGS Service Menu Settings In order to reach service menu, First Press “MENU” buton, then write “4725” by uisng remote controller. You can see the service menu main screen below. You can check SW releases by using this menu.
  • Page 76 LC-32LE511 LC-40LE511 LC-40LE531 Video Settings Audio Settings...
  • Page 77 LC-32LE511 LC-40LE511 LC-40LE531 Options-1 Menu Options-2 Menu...
  • Page 78 LC-32LE511 LC-40LE511 LC-40LE531 Tuner Settings Menu Source Settings Menu...
  • Page 79 LC-32LE511 LC-40LE511 LC-40LE531 Diagnostic Menu General Block Diagram...

  • Page 80: General Block Diagram

    LC-32LE511 LC-40LE511 Diagnostic Menu LC-40LE531 GENERAL BLOCK DIAGRAM General Block Diagram NLAST66...

  • Page 81: Overal Wiring Diagram

    LC-32LE511 LC-40LE511 LC-40LE531 OVERAL WIRING DIAGRAM 22. OVERAL WIRING DIAGRAM MB70 / PW07 OVERALL WIRING DIAGRAM Overal Wiring Diagram LC-32LE511 MODEL LC-32LE511E MB70 MAIN BOARD PW07 POWER SUPPLY PANEL INVERTER BOARD PL306 CN29 CN26 3V3_VCC PW_KEYBOARD 24V_VCC 24V_VCC INVERTER CABLE...
  • Page 82 LC-32LE511 LC-40LE511 LC-40LE531 Overal Wiring Diagram LC-40LE511 MB70 / PW07 OVERALL WIRING DIAGRAM MODEL LC-32LE511E MB70 MAIN BOARD POWER SUPPLY PW07 PANEL INVERTER BOARD PL306 CN29 CN26 3V3_VCC PW_KEYBOARD 24V_VCC 24V_VCC INVERTER CABLE PART CODE 30070913 3V3_VCC 7 OPTION1 5V_VCC...
  • Page 83 LC-32LE511 LC-40LE511 MB70 / PW07 OVERALL WIRING DIAGRAM LC-40LE531 Overal Wiring Diagram LC-40LE531 MODEL LC-40LE531E MB70 MAIN BOARD POWER SUPPLY PW07 PANEL INVERTER BOARD PL306 CN29 CN26 CN20 3V3_VCC PW_KEYBOARD 2 PANEL_VCC 24V_VCC 3 PANEL_VCC 24V_VCC 4 PANEL_VCC INVERTER CABLE 5 PANEL_VCC 6 PANEL_VCC PARTS CODE 30071199...

  • Page 84: Schematic Diagrams

    LC-32LE511 LC-40LE511 LC-40LE531 SCHEMATIC DIAGRAMS 23. Schematic Diagrams HDMI - USB - Ethernet & Keyboard Diagram HDMI (SIL9287) HDMI_TX2P HDMI_RX_0_DATA2_P TP253 PW_KEYBOARD HDMI_TX2N HDMI_RX_0_DATA2_N 3V3_STBY 12V_VCC 330R KEYBOARD HDMI_TX1P HDMI_RX_0_DATA1_P TOUCH_PAD_OPTION HDMI_TX1N HDMI_RX_0_DATA1_N 24V_VCC 330R 3V3_STBY HDMI_TX0P HDMI_RX_0_DATA0_P C579 HDMI_TX0N HDMI_RX_0_DATA0_N HDMI_TXCP HDMI_RX_0_CLK_P...
  • Page 85 LC-32LE511 LC-40LE511 LC-40LE531 CI AND NAND FLASH & Panel_SW & DIM NAND FLASH 330R NAND_3V3 3V3_VCC 3V3_VCC NAND_WPZ C137 C239 NC29 100n 330p 5V_VCC NC28 F139 5V_VCC CI_PWR 330R NC27 C290 C242 220u 100n NC26 R172 NAND_DATA_0 NAND_DATA_7 BC858B NAND_DATA0/EBI_DATA8 I/O7 R330 R329...
  • Page 86 LC-32LE511 LC-40LE511 LC-40LE531 RAM Interface R929 DDR_VTT R547 DDR_VTT DDR01_A00 DDR01_A00 DDR01A12 DDR01_A01 DDR01A03 DDR01A12 DDR01_A01 DDR01_A03 DDR01_A02 DDR01_A02 DDR01A00 DDR0_DQ14 DDR01A07 DDR01_A03 DDR01_A03 DDR01_BA2 DDR01BA2 DDR01A07 DDR01A01 DDR0_DQ10 DDR01A00 DDR0_DQ07 DDR01A02 DDR0_DQ11 DDR01A09 DDR0_A04 DDR0_A04 DDR01BA0 DDR01A03 DDR01_BA0 DDR01A01 DDR0_DQ06 DDR01A03 DDR0_DQ15...
  • Page 87 LC-32LE511 LC-40LE511 LC-40LE531 HDMI (SIL9287) & Main Power R139 POWER SOCKET 3V3_VCC 3V3_VCC HDMI_3V3 TP236 LM1117 C558 HDMISW_SDA 100n 100n 3V3_STBY A/D DIMMING SELECTION 4V2_STBY CN29 C117 C116 VOUT R186 S105 3V3_STBY C321 C252 4V2_STBY PW_KEYBOARD 3V3_VCC HDMISW_SCL 100n S107 24V_VCC 3V3_VCC 24V_VCC...
  • Page 88 LC-32LE511 LC-40LE511 LC-40LE531 BCM Power / GND 3V3_AGC U114 5V_TUN_RF_AGC AH27 AGC_VDDO LM1117 F191 AB11 A_2V5 AUDMX_AVSS0 3V3_AGC AA11 5V_TUN A_2V5 AUDMX_AVSS1 330R C914 C264 C251 VOUT AUDMX_AVDD2P5 AUDMX_AVSS2 AUDMX_LDO_CAP AUDMX_AVSS3 AA10 AUDMX_AVSS4 AF23 AB10 AUD_AVDD2P5_0 AUDMX_AVSS5 AE22 AB21 AUD_AVDD2P5_1 AUD_AVSS_00 R979 R975...
  • Page 89 LC-32LE511 LC-40LE511 LC-40LE531 Tuner & AV & Peripherals R333 R338 C302 100n 100n Near Tuner LM1117 100n SD_G SD_INCM_G R917 supply pin VGA_G_IN C303 100n 8V_VCC 5V_TUN VGA_B_IN R339 SD_B SD_INCM_B C512 100n 330R AD10 AC10 C693 C320 R337 SD_R SD_INCM_R VOUT C246...
  • Page 90 LC-32LE511 LC-40LE511 LC-40LE531 Audio Amp. S101 12V_VCC HEADPHONE AMPLIFIER S172 S104 24V_VCC VDD_AUDIO SK24 C521 C705 S108 18V_VCC 100u 100u F112 VDD_AUDIO C655 C945 PIN2 PIN2 F187 S138 HP_L_O S165 S140 F188 S139 L_AUDIO_P C665 HP_R_O C935 C934 C479 C478 PVCCL2 AMP_EN FAULT...
  • Page 91 LC-32LE511 LC-40LE511 LC-40LE531 LVDS & Pixelence R148 TP120 R367 TP121 R146 TX_B_0_N PIX_SDA 100R TP123 R103 CN24 R380 VDD33 R147 TX_B_0_P 100R PIX_SCL TX_B_0_N VDD33 TP122 TP34 TX_B_1_N TX_B_0_P TP42 VDD12 VCD1V2 TX_B_1_P 330R TX_B_1_N 2V5_VCC TP43 TX_B_2_N C228 C460 TX_B_1_P 330p 100n...
  • Page 92 LC-32LE511 LC-40LE511 LC-40LE531 FRC (GPIO - PCI - VDI ) NAND_FRC_REN NAND_FRC_WEN R369 NAND_FRC_CLE 100R PCI_AD0 PCI_CBE0 R370 NAND_FRC_ALE 100R PCI_AD1 PCI_CBE1 100R R371 PCI_AD2 PCI_CBE2 100R R372 3V3_VCC PCI_AD3 PCI_CBE3 R305 PCI_AD4 PCI_CLK 3V3_VCC FRC_CLK R160 CN33 PCI_AD5 PCI_DEVSEL R553 R164 3V3_VCC...
  • Page 93 LC-32LE511 LC-40LE511 LC-40LE531 FRC (DDR) C1&C3 G1&G3 1V8_DDRFRC R485 C405 C222 C225 C223 C224 C215 C214 C217 1V8_DDRFRC 560R DDR_VREFFRC F143 330p 330p 330p 330p 330p 330p 330p 100n 100n 100n 100n 100n 100n 100n R484 1V8_VCC 1V8_DDRFRC 560R C726 C404 C226 Decoupling Caps for U13...
  • Page 94 LC-32LE511 LC-40LE511 LC-40LE531 FRC (VDD - VSS) & FRC_LVDS_OUT 1V25_VCCFRC 1V25_UIP_PLL C440 C128 C109 R302 100n 100n C127 3D_SHUTTER F118 3V3_VCC 3V3_PERFRC 1V25_UIP_PLL C156 100n 100n TX_2_EN TX_B_4_N AF12 AD13 1V25_VCCFRC 1V25_XTAL TX_2_EP TX_B_4_P C428 C153 100n F119 TX_2_CLKN TX_B_CLK_N TX_2_CLKP TX_B_CLK_P C942...
  • Page 95 LC-32LE511 LC-40LE511 LC-40LE531 AUDIO_IN / OUT & Peripherals_2 & CLOCK_I2C 30061217 CAP SMD 2.2UF 6.3V M X5R (0402) MXM ROHS C139 AUDMX_LEFT1 R615 AUDMX_LEFT1 C180 5V_VCC R599 AUDMX_INCM1 100R AUDMX_RIGHT1 SAV_AUD_L_IN AUDMX_LEFT4 AUDMX_RIGHT1 C894 C940 BAV99 C954 C138 C953 100n AUDMX_LEFT2 AUDMX_LEFT2 R617...
  • Page 96 LC-32LE511 LC-40LE511 LC-40LE531 DVB S2 F149 3V3_VCC S2_3V3 220R C778 C775 C951 RESET_IC R782 R784 3V3_VCC 1N4001 C382 C348 330u JTAG_TDO RESETB V_UP VO_TX EXTM F193 VDDO_3P3_8 VDDO_3P3_3 S2_3V3 LNB_OUT S189 VO_RX SCL_S2 330R S190 VCC_L JTAG_TMS HOST_SCL SDA_LNBP S188 DSQIN C331 SCL_LNBP...
  • Page 97 LC-32LE511 LC-40LE511 LC-40LE531 DVB C & DVB T2 U104 M74HC4052 1 2Y0 RFAGCMSB1222 5V_TUN R374 2V5_AVDD 2V5_VCC IF_AGC_TUNER 3V3_IF 3V3_MSB RF_AGC_TUNER 330R 5V_IF_SUP 100R 330R 100n C260 RF_AGC IF_AGC_T2 C296 C297 C295 C240 C746 R206 R587 IF_AGC 100n 100n 100n DIGITAL_IF_P ZIF_IP RF_AGC_T2...
  • Page 98 LC-32LE511 LC-40LE511 LC-40LE531 GPIO & LOW_PWR & LED C181 R959 F196 3V3_VCC LOW POWER+CEC MICROCONTROLLER KEYBOARD R297 U103 1N4148 GPIO_00 R1031 NVM_WP R320 C932 3V3_STBY 24C32 100n S204 AMBILIGHT_SENSOR 3V3_VCC 1 E0 GPIO_01 HDMI_INT R879 3V3_STBY 3V3_VCC R311 3V3_STBY MOTION_SENSOR GPIO_02 IRQ_S2 EEPROM_SCL...
  • Page 99 LC-32LE511 LC-40LE511 LC-40LE531 FPGA R842 R829 TX_A_0_N_PIX TX_B_0_N_PIX F185 F184 100R TX_A_0_P_PIX 100R TX_B_0_P_PIX 1V2_VCC +1V2_FPGA 2V5_VCC +2V5_FPGA R843 R822 PNX_VSYNC FPGA_VSYNC TX_A_1_N_PIX TX_B_1_N_PIX C844 100R TX_A_1_P_PIX 100R TX_B_1_P_PIX C843 220u 100n R830 R831 220u 100n C794 TX_A_2_N_PIX TX_B_2_N_PIX 100R TX_A_2_P_PIX 100R TX_B_2_P_PIX...
  • Page 100 LC-32LE511 LC-40LE511 LC-40LE531 Power Supply Diagram...

  • Page 101: Printed Wiring Board

    LC-32LE511 LC-40LE511 LC-40LE531 24. PRINTED WIRING BOARD Main Unit PWB Top Side...
  • Page 102 LC-32LE511 LC-40LE511 LC-40LE531 PRINTED WIRING BOARD (Continued) Main Unit PWB Bottom Side...

  • Page 103: Replacement Parts Listing

    20555220 MD.ASY.17PW07-32" (MB61¬70_SHARP) ROC ( Power LC-32LE511 ) Q122 30001457 TR NBJT BC848B 0.1A/30V SOT23 ROHS 20554268 MD.ASY.17PW07-42" (MB61¬70_SHARP) ROC ( Power LC-40LE511-LC40LE531 ) G MD.ASY.17LD98-7-26880(25/35(SHARP)RED /GR (I/R & LED BOARD with Q123 30047143 TR PMOS FDN336P -1.3A/-20V SOT23 RoHS 20565400 cable LC-32LE511 30001457 TR NBJT BC848B 0.1A/30V SOT23 ROHS...
  • Page 104 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION 30053657 DIODE ARRAY ESD NUP4004M5 TSOP-5 RoHS F127 30060822 FERRIT SMD 90R/100MHz 2R5 M 0.1A 2x504Ro 30053657 DIODE ARRAY ESD NUP4004M5 TSOP-5 RoHS F128 30060822 FERRIT SMD 90R/100MHz 2R5 M 0.1A 2x504Ro 30018574 DIODE SCH SS33 3A/30V DO214AB ROHS F129 30060822 FERRIT SMD 90R/100MHz 2R5 M 0.1A 2x504Ro...
  • Page 105 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION F305 30060822 FERRIT SMD 90R/100MHz 2R5 M 0.1A 2x504Ro 30062560 COIL SMD 2.2UH 7A M 0R01 12x12(SHL)Ro 30016659 COIL SMD 1uH 50mA K 0R4 805 Ro F306 30060822 FERRIT SMD 90R/100MHz 2R5 M 0.1A 2x504Ro F307...
  • Page 106 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION C170 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS C171 30069618 CAP SMD 100NF 50V K X5R (0402) RoHS C280 30030097 CAP SMD 100NF 10V K X5R (0402) RoHS C173...
  • Page 107 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION C362 30030099 CAP SMD 1NF 50V K X7R (0402) ROHS 30047296 CAP SMD 22UF 6.3V M X5R (0805) ROHS C363 30030099 CAP SMD 1NF 50V K X7R (0402) ROHS C500 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS C364...
  • Page 108 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION C593 30047296 CAP SMD 22UF 6.3V M X5R (0805) ROHS C693 30066874 CAP ELCH 47UF 16V M 105C 48mA 5x5.4 ROHS C594 30066876 CAP SMD 4.7UF 10V K X7R (0805) ROHS C694 30066874 CAP ELCH 47UF 16V M 105C 48mA 5x5.4 ROHS C596...
  • Page 109 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION C969 30030099 CAP SMD 1NF 50V K X7R (0402) ROHS C889 30022342 CAP SMD 10NF 16V J X7R (0402) ROHS C890 30064783 CAP SMD 1UF 6.3V K X6S (0402) ROHS RESISTORS C891 30069137 CAP SMD 330NF 6.3V K X5R (0402) RoHS...
  • Page 110 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION R137 30021996 RES SMD 1/16W 10K J 0402 ROHS R255 30021989 RES SMD 1/16W 100K J 0402 ROHS R138 30021996 RES SMD 1/16W 10K J 0402 ROHS R256 30021989 RES SMD 1/16W 100K J 0402 ROHS R139...
  • Page 111 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION R377 30021996 RES SMD 1/16W 10K J 0402 ROHS R487 30022046 RES SMD 1/16W 2.2K J 0402 RoHS 30021989 RES SMD 1/16W 100K J 0402 ROHS R489 30022046 RES SMD 1/16W 2.2K J 0402 RoHS R382...
  • Page 112 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION R607 30021960 RES SMD 1/16W 47R J 0402 ROHS R898 30022024 RES SMD 1/16W 12K J 0402 ROHS R609 30022056 RES SMD 1/16W 220R J 0402 RoHS 30021996 RES SMD 1/16W 10K J 0402 ROHS R610 30022056 RES SMD 1/16W 220R J 0402 RoHS...
  • Page 113 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION R992 30021996 RES SMD 1/16W 10K J 0402 ROHS S166 30022132 RES SMD 1/16W 0R 0402 ROHS S168 30022132 RES SMD 1/16W 0R 0402 ROHS MISCELLANEOUS PARTS S171 30022132 RES SMD 1/16W 0R 0402 ROHS...
  • Page 114 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION 30066904 IC HDMI SWITCH SIL9287B QFN72 RoHS 30001457 TR NBJT BC848B 0.1A/30V SOT23 ROHS U111 30033737 IC AND GATE 74V1G08 (SOT 23-5) RoHS 30001457 TR NBJT BC848B 0.1A/30V SOT23 ROHS U112 30033737 IC AND GATE 74V1G08 (SOT 23-5) RoHS 30001458 TR BC858B SMD...
  • Page 115 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION 30069192 XTAL 54MHZ 19PF 15ppm 15Ohm 3225 SMDROHS 30019087 FERRIT SMD 60R/100MHz 0.025 M 3A 0805Roh 30067372 XTAL 41MHZ 9.4pF 20ppm SMD 3.2x2.5 ROHS 30019087 FERRIT SMD 60R/100MHz 0.025 M 3A 0805Roh 30048438 XTALSMD27MHZ R=40 LC=18PF 30PPMROHS 30019087 FERRIT SMD 60R/100MHz 0.025 M 3A 0805Roh 30019087 FERRIT SMD 60R/100MHz 0.025 M 3A 0805Roh...
  • Page 116 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION 30020394 FERRIT SMD 330/100MHz 0.1R M 1.5A 805Ro C116 30030097 CAP SMD 100NF 10V K X5R (0402) RoHS 30020394 FERRIT SMD 330/100MHz 0.1R M 1.5A 805Ro C117 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS 30020394 FERRIT SMD 330/100MHz 0.1R M 1.5A 805Ro...
  • Page 117 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION C175 30030097 CAP SMD 100NF 10V K X5R (0402) RoHS C246 30030097 CAP SMD 100NF 10V K X5R (0402) RoHS C176 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS C247 30030097 CAP SMD 100NF 10V K X5R (0402) RoHS C177...
  • Page 118 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION C333 30067968 CAP SMD 10UF 10V M X7R (0805) ROHS C404 30067968 CAP SMD 10UF 10V M X7R (0805) ROHS C334 30022238 CAP SMD 33PF 50V J COG (0402) ROHS C405 30067968 CAP SMD 10UF 10V M X7R (0805) ROHS C335...
  • Page 119 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION C490 30050558 CAP SMD 100NF 16V K X5R (0402) ROHS C559 30069320 CAP SMD 22UF 6.3V M X7R (1206) RoHS C491 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS 30047296 CAP SMD 22UF 6.3V M X5R (0805) ROHS C560...
  • Page 120 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION C641 30063686 CAP ELCH 100UF 16V M 105C 6.3x5.4 ROHS C771 30047296 CAP SMD 22UF 6.3V M X5R (0805) ROHS 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS C772 30047296 CAP SMD 22UF 6.3V M X5R (0805) ROHS C650...
  • Page 121 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION C839 30067968 CAP SMD 10UF 10V M X7R (0805) ROHS 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS C840 30067968 CAP SMD 10UF 10V M X7R (0805) ROHS...
  • Page 122 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS R129 30021996 RES SMD 1/16W 10K J 0402 ROHS 30021996 RES SMD 1/16W 10K J 0402 ROHS RESISTORS R130 30021996 RES SMD 1/16W 10K J 0402 ROHS...
  • Page 123 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION R219 30000721 RES SMD 1/10W 4.7K J 0805 ROHS R289 30042505 RES NET 1/32W 33R J 8P 0402 ROHS R220 30021999 RES SMD 1/16W 10R J 0402 RoHS R290 30042505 RES NET 1/32W 33R J 8P 0402 ROHS R221...
  • Page 124 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION 30021989 RES SMD 1/16W 100K J 0402 ROHS R461 30022042 RES SMD 1/16W 1K J 0402 RoHS R382 30022132 RES SMD 1/16W 0R 0402 ROHS R466 30021958 RES SMD 1/16W 47K J 0402 RoHS R383...
  • Page 125 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION R562 30021958 RES SMD 1/16W 47K J 0402 RoHS R800 30021987 RES SMD 1/16W 4.7K J 0402 RoHS R563 30022061 RES SMD 1/16W 27K J 0402 RoHS R802 30021987 RES SMD 1/16W 4.7K J 0402 RoHS R564...
  • Page 126 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION R941 30022051 RES SMD 1/16W 2.7K J 0402 ROHS R874 30021958 RES SMD 1/16W 47K J 0402 RoHS R942 30022051 RES SMD 1/16W 2.7K J 0402 ROHS R875 30021958 RES SMD 1/16W 47K J 0402 RoHS R943...
  • Page 127 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION 30022052 RES SMD 1/16W 200R J 0402 RoHS 35028251 GROUND TERMINAL Main Board 8.5X8.3 Rohs 30022132 RES SMD 1/16W 0R 0402 ROHS 30022132 RES SMD 1/16W 0R 0402 ROHS 30022132 RES SMD 1/16W 0R 0402 ROHS S104 30001734 RES SMD 1/10W 0R 0805 ROHS...
  • Page 128 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION 30038507 DIODE SMD 1N4148 0.15A/100V SOD123 RoHS TRANSISTORS 30038480 DIODE SMD ZEN C5.6V SOD123 ROHS 30001457 TR NBJT BC848B 0.1A/30V SOT23 ROHS 30048473 DIODE DUALSMD BAW56 4A/75V/4A SOT23ROHS Q106 30069749 TR NMOS BSH105 1.05A/30V SOT23 ROHS 30048473 DIODE DUALSMD BAW56 4A/75V/4A SOT23ROHS...
  • Page 129 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION F164 30061050 FERRIT SMD 600R/100MHz 3A 0.2R(1206)RoHS F324 30060822 FERRIT SMD 90R/100MHz 2R5 M 0.1A 2x504Ro F165 30061050 FERRIT SMD 600R/100MHz 3A 0.2R(1206)RoHS F325 30060822 FERRIT SMD 90R/100MHz 2R5 M 0.1A 2x504Ro F170 30020394 FERRIT SMD 330/100MHz 0.1R M 1.5A 805Ro 30020394 FERRIT SMD 330/100MHz 0.1R M 1.5A 805Ro...
  • Page 130 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION 30016659 COIL SMD 1uH 50mA K 0R4 805 Ro C136 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS 30025158 COIL SMD 4.7uH 0.03A M 1R 805 Ro C137 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS 30019087 FERRIT SMD 60R/100MHz 0.025 M 3A 0805Roh...
  • Page 131 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION C202 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS C271 30030097 CAP SMD 100NF 10V K X5R (0402) RoHS C203 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS C272 30030097 CAP SMD 100NF 10V K X5R (0402) RoHS C204...
  • Page 132 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION C350 30030099 CAP SMD 1NF 50V K X7R (0402) ROHS C428 30067968 CAP SMD 10UF 10V M X7R (0805) ROHS C352 30030099 CAP SMD 1NF 50V K X7R (0402) ROHS C429 30067968 CAP SMD 10UF 10V M X7R (0805) ROHS C353...
  • Page 133 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION C511 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS C585 30022248 CAP SMD 220PF 50V J COG (0402) RoHS C512 30044848 CAP SMD 100NF 16V K X7R (0402) ROHS C586 30022248 CAP SMD 220PF 50V J COG (0402) RoHS C513...
  • Page 134 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION C668 30046152 CAP SMD 1UF 50V Z Y5V (0805) ROHS C800 30022250 CAP SMD 330PF 50V K X7R (0402) RoHS C669 30061026 CAP SMD 1UF 25V K X7R (0805) ROHS C801 30022250 CAP SMD 330PF 50V K X7R (0402) RoHS C671...
  • Page 135 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION C926 30022237 CAP SMD 27PF 50V J COG (0402) ROHS C863 30067968 CAP SMD 10UF 10V M X7R (0805) ROHS C928 30030099 CAP SMD 1NF 50V K X7R (0402) ROHS C864 30067968 CAP SMD 10UF 10V M X7R (0805) ROHS C865...
  • Page 136 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION R1036 30022116 RES SMD 1/16W 75K J 0402 ROHS R154 30021996 RES SMD 1/16W 10K J 0402 ROHS R1037 30022004 RES SMD 1/16W 11K J 0402 ROHS R156 30021996 RES SMD 1/16W 10K J 0402 ROHS R1038...
  • Page 137 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION R240 30021958 RES SMD 1/16W 47K J 0402 RoHS R317 30022051 RES SMD 1/16W 2.7K J 0402 ROHS R241 30021958 RES SMD 1/16W 47K J 0402 RoHS R318 30022085 RES SMD 1/16W 33R J 0402 RoHS R242...
  • Page 138 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION R397 30022036 RES SMD 1/16W 180K J 0402 ROHS R484 30022020 RES SMD 1/16W 560R F 0402 RoHS R398 30022116 RES SMD 1/16W 75K J 0402 ROHS R485 30022020 RES SMD 1/16W 560R F 0402 RoHS R399...
  • Page 139 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION R578 30022051 RES SMD 1/16W 2.7K J 0402 ROHS R822 30021991 RES SMD 1/16W 100R J 0402 ROHS R579 30022118 RES SMD 1/16W 75R J 0402 RoHS R823 30021991 RES SMD 1/16W 100R J 0402 ROHS R580...
  • Page 140 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION R890 30021996 RES SMD 1/16W 10K J 0402 ROHS R971 30022132 RES SMD 1/16W 0R 0402 ROHS R972 30022132 RES SMD 1/16W 0R 0402 ROHS R892 30021996 RES SMD 1/16W 10K J 0402 ROHS R893...
  • Page 141 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION 30071263 SOCKET SCART 21P TOP LEFT PIP 7mm ROHS 30022132 RES SMD 1/16W 0R 0402 ROHS 30053833 RES THE SAFE 2.1R/100mA PTC 1210 ROHS S130 30022132 RES SMD 1/16W 0R 0402 ROHS 30050574 TRF MOD.10/100 (SMD) H1260 0.28mmRoHS S131...
  • Page 142 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION D214 30038507 DIODE SMD 1N4148 0.15A/100V SOD123 RoHS C115 30068234 CAP MKP SAFE 100NF 275V M X2AC15BOX ROHS D215 30066697 DIODE SCH SR110 1A/100V/30A DO41 ROHS C116 30066377 CAP CER 220PF 1KV K YRN 125C(PULSE) ROHS D219...
  • Page 143 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION C402 30070746 CAPEL 470UF 10V M105C 640mA 8X12 SHALEFT R205 30000653 RES SMD 1/10W 33R J 0805 ROHS C403 30061026 CAP SMD 1UF 25V K X7R (0805) ROHS R206 30000475 RES SMD 1/10W 10K J 0805 ROHS C404...
  • Page 144 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION R312 30020394 FERRIT SMD 330/100MHz 0.1R M 1.5A 805Ro J121 30002583 JUMPER WIRE 0.6MM R313 30000797 RES SMD 1/10W 75R J 0805 ROHS J122 30002583 JUMPER WIRE 0.6MM R314 30000475 RES SMD 1/10W 10K J 0805 ROHS J124...
  • Page 145 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION PL100- 35000176 EYELET BR 2*3MM ROHS D106 30001319 DIODE RL207 2A/1000V 70A DO-15 ROHS PL101 30070232 CONNHEADER SAFE 2P V0 7.92SIDE 3.5mm RHS D107 30051096 DIODE SMD ZEN C6.2V SOD123 ROHS PL101- 35000176 EYELET BR 2*3MM ROHS D109...
  • Page 146 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE REF No. PARTS DESCRIPTION CODE REF No. PARTS DESCRIPTION L401 30062563 Choke coil Toroid Safe 33uH 3A K 6x12Ro C230 30010561 CAP SMD 220NF 50V K X7R (0805) ROHS L402 30001735 RES SMD 1/8W 0R 1206 ROHS C231 30000256 CAP SMD 470PF 50V J COG (0805) ROHS L413...
  • Page 147 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION R258 30000747 RES SMD 1/10W 560R J 0805 ROHS R128 30050064 RES SMD 1/4W 1.62M F 1206 ROHS R259 30000593 RES SMD 1/10W 2.2K J 0805 ROHS R129 30050064 RES SMD 1/4W 1.62M F 1206 ROHS R130...
  • Page 148 LC-32LE511 LC-40LE511 LC-40LE531 PRICE PRICE CODE CODE REF No. PARTS DESCRIPTION REF No. PARTS DESCRIPTION F200 30001735 RES SMD 1/8W 0R 1206 ROHS J174 30002583 JUMPER WIRE 0.6MM J103 30002583 JUMPER WIRE 0.6MM J175 30002583 JUMPER WIRE 0.6MM J104 30002583 JUMPER WIRE 0.6MM J176 30002583 JUMPER WIRE 0.6MM J105...

  • Page 149: Cabinet And Mechanical Parts Listing

    ROC.SW.AS.40"LED (MB61_SHARP) ( Rocker Switch & Cable LC-40LE511-LC40-LE531) 20565284 FOOT ASSY 40942(GLOSSY-BLACK_SHARP(PKG) ( Stand Foot Detachable LC-40LE511- LC-40LE531) 45010587 DETACHABLE SHARP ST.BLACK LCD 40 LED PKG (Screws and Foot Support of the Detachable Stand Foot L-C40LE511 LC40LE531 ) 20567124 SPK.AS.42930 LED(MB61_6P(R/L(30X131)(BL-SHARP) (Speakers LC-40LE511 LC-40LE531) 30071217...
  • Page 150 LC-32LE511 LC-40LE511 LC-40LE531 NOTES :...
  • Page 151 40043424 LED IR LENS TFT XX856 (%3 MILKY) VER6. MD.ASY.17LD98-7-26880(25/35(SHARP)RED/GR 20565400 20565102 SPK.AS.32930 LED(MB60(30X107X20(BL(SH 20565400 MD.ASY.17LD98-7-37-42880(25/35(SHARP)RED/GR) (I/R & Led Board with cable LC-32LE510) 30071826 TFT 32FHD50HZ ELED LG LC320EUN-SDV1 PL 20565102 SPK.AS.32930 LED(MB70(30X107X20(BL)SHARP ( SPEAKERS ) ROC.SW.AS.(MB60_22942_SHARP) 20569417 BC.32942 LED MB61&RO WO/KL&CH(I)V0(SHA...
  • Page 152 BC.40942L 61&S&R&L(WO/K&C&SB(PCABS(IV0SH 20567117 30070539 TFT 40FHD50HZ ELED SAM LTA400HM13 (PANEL ) ROC.SW.AS.40"LED (MB61_SHARP) 20573118 20567117 BC.40942 LED MB61 &S&L (WO/KL&C&CH(I)V0(SHARP) ( Back Cover ) FOOT ASSY 40942(GLOSSY-BLACK_SHARP(PKG 20565284 20573118 ROC.SW.AS.40" LED (MB61_SHARP)(Rocker Swith Cable ) 20565284 FOOT ASSY 40942(GLOSSY-BLACK_SHARP)PKG (STAND FOOT(DETACHABLE))
  • Page 153 BC.40942L 61&S&R&L(WO/K&C&SB(PCABS(IV0SH 20567117 30070539 TFT 40FHD50HZ ELED SAM LTA400HM13 (PANEL ) ROC.SW.AS.40"LED (MB61_SHARP) 20573118 20567117 BC.40942 LED MB61 &S&L (WO/KL&C&CH(I)V0(SHARP) ( Back Cover ) FOOT ASSY 40942(GLOSSY-BLACK_SHARP(PKG 20565284 20573118 ROC.SW.AS.40" LED (MB61_SHARP)(Rocker Swith Cable ) 20565284 FOOT ASSY 40942(GLOSSY-BLACK_SHARP)PKG (STAND FOOT(DETACHABLE))
  • Page 154 LC-32LE511 LC-40LE511 LC-40LE531 NOTES:...
  • Page 155 LC-32LE511 LC-40LE511 LC-40LE531 NOTES:...

  • Page 156: Sharp Corporation

    LC-40LE511 LC-40LE531 125mm 100mm 80mm 63mm COPYRIGHT © 2011 BY SHARP CORPORATION 50mm ALL RIGHTS RESERVED No part of this publication may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical,...

This manual is also suitable for:

Lc-40le531eLc-40le511e

Table of Contents