Table of Contents
Advertisement
Quick Links
460 Express Series
Table of Contents
1. Introduction........................................................................................................ 1-1
2. Model Specific Information............................................................................... 2-1
3. Controls and Indicators .................................................................................... 3-1
4. Basic Systems Operation ................................................................................. 4-1
V2112700 (Rev. 0)
460 Express Series
Advertisement
Chapters
Table of Contents
Related Manuals for Cruisers Yachts 460 Express Series
Summary of Contents for Cruisers Yachts 460 Express Series
- Page 1 460 Express Series Table of Contents 1. Introduction......................1-1 2. Model Specific Information................2-1 3. Controls and Indicators ..................3-1 4. Basic Systems Operation ................. 4-1 V2112700 (Rev. 0) 460 Express Series...
-
Page 2: Express Series
460 Express Series 460 Express Series... -
Page 3: Table Of Contents
Warranty Information ............ 1-5 Skipper’s Kit ..............1-2 Dealership Responsibilities..........1-5 Your Responsibilities ............1-5 Owner’s Manual ..............1-2 Warranty Service ..............1-5 Safety Symbols ..............1-3 Safety Label Location Layout........1-6 Owner’s Manuals for Onboard Systems and Components..............1-4 460 Express Series... -
Page 4: Welcome Aboard
The Skipper’s Kit contains the 460 Express Series owner’s manual. Also included is information about onboard systems and components We wish to thank you for making our 460 Express Series your furnished by suppliers other than Cruisers Yachts. recreational choice for boating enjoyment. Extensive design and engineering research went into the development of all Cruisers Owner’s Manual... -
Page 5: Safety Symbols
Keep a sound mind during an emergency and always think safety. Section 4 contains principles of operation for the major systems onboard the 460 Express Series. The Safety Alert Symbol means ATTENTION! Be alert to the possibility of personal injury or death. -
Page 6: Owner's Manuals For Onboard Systems And Components
Cruisers Yachts. Depending on the options you chose, the kit may contain some or all of the following literature: •... -
Page 7: Warranty Information
Cruisers Yachts are located inside the Skipper’s outlined in the owner’s manuals and service guides. Kit. Your Cruisers Yachts Dealer will go through these with you. It is your responsibility to fill out any warranty registration that may be Warranty Service required. -
Page 8: Safety Label Location Layout
KEEP CLOSED WHEN ENGINE OR GENERATOR ARE RUNNING. NORMAL: Open Outside Valves a nd Close Center EMERGENCY : Close Va ve to Emp y or Contaminated Tank and Open Center 440 LABEL LOC Do Not Open All Three Va ves 460 Express Series... - Page 9 Standard Waste Layout..........2-24 Plumbing Hardware ............. 2-10 Grey Water Layout............2-25 Diesel Engine General Layout ........2-11 Cockpit Draining ............2-26 General Layout – Engine Room Lifting and Storing Your Boat ........2-27 Layout (Volvo Option)..........2-13 460 Express Series...
-
Page 10: Specifications
T TAMD75P EDC, 480 HP (358 KW), Electronic Controls, FWC, VD T 8.1 S HO, 420 HP (313 KW), FWC, VD Yanmar Volvo T 6LY2A-STP, 440 HP (328 KW), Electronic Controls, FWC, VD T 8.1 GXi, 420 HP (313 KW), FWC, VD 460 Express Series... -
Page 11: Deck Hardware General Layout
30. Phone/TV Jack 8. Windlass Deck Switch In 20. Cockpit Speaker 31. Swim Platform Cleat 9. Horn 21. Actuated Hatch Switch 32. Swim Ladder 10. Amidship Cleat 22. Actuated Hatch 33. Subwoofer 11. Waste Deck Plate DECKHRDWARE 460 Express Series... -
Page 12: Interior General Layout - Double Stateroom Option
2. A/C Unit 10. Coffee Maker 17. Dinette 3. AC/DC Panel 11. Head Vanity 18. Stereo 4. TV/DVD 12. Head 19. ASR Closet 5. ASR TV/DVD 13. Shower 20. ASR 6. Refrigerator 14. FSR Closet 7. Stove GL-INTERIOR 460 Express Series... -
Page 13: Cockpit Light Plan Layout / Interior Light Plan Layout
19. Reading Light 20. Closet Light 21. Fluorescent Light 22. Fluorescent Light 23. Overhead Light 24. Carbon Monoxide Detector 25. White Courtesy Lights 37-R013D 26. Dual Receptacle Box 27. Dual Receptacle Box-GFCI w/Weatherproof Cover 28. Light Switch 460 Express Series... -
Page 14: Stereo Layout
STEREO LAYOUT 1. Exterior Speaker with Grill 2. Interior Speaker 3. Head Unit, CD Player 4. Stereo Remote 5. 6 Disc CD Changer 6. 200 Watt Amplifier 7. 100 Watt Amplifier 8. Fader Switch 9. Subwoofer 37-R009B 460 Express Series... -
Page 15: A/C Plan View
5. Port Plenum to Forward Head 2. Air Conditioner 6. Port Plenum to Galley 3. Port Plenum to Aft Head 7. Center A/C Unit to Starboard Plenum 4. Port Plenum to FSR 8. Center A/C Unit to Salon 460 Express Series... -
Page 16: Starboard A/C View
Section 2 STARBOARD A/C VIEW 1. Air Conditioner 5. Starboard A/C Diffuser 2. Center A/C Unit to Starboard Plenum 6. Center A/C Diffuser 3. Center A/C Unit to Salon 7. Salon A/C Vent 4. Starboard Plenum 37-R012D-B 460 Express Series... -
Page 17: Port A/C View
6. Port Plenum 2. Port Plenum to Aft Head 7. Black Round A/C Vent 3. Port Plenum to FSR 8. Starboard A/C Diffuser 4. Port Plenum to Forward Head 9. Galley A/C Vent 5. Port Plenum to Galley 37-R012D-C 460 Express Series... -
Page 18: Plumbing Hardware
25. A/C Water Pump 34. Washdown Kit 8. Hot/Cold Transom Shower 17. Bilge Pump Float Switch 26. Engine Seacock 35. Washdown Kit Strainer 9. Waste tank 18. High Water Alarm 27. Engine Strainer Purple = optional equipment 2-10 460 Express Series... -
Page 19: Diesel Engine General Layout
21. Starboard Fuel Tank Vent Hose 22. Port Fuel Tank Fill Hose 23. Starboard Fuel Tank Fill Hose 24. Starboard Tank to Genset Fuel Filter 25. Fuel Filter to Genset 26. Genset to Starboard Tank Return 37-R006D-1 2-11 460 Express Series... - Page 20 21. Starboard Fuel Tank Vent Hose 22. Port Fuel Tank Fill Hose 23. Starboard Fuel Tank Fill Hose 24. Starboard Tank to Genset Fuel Filter 25. Fuel Filter to Genset 26. Genset to Starboard Tank Return 3, 4 37-R006D-2 2-12 460 Express Series...
-
Page 21: General Layout - Engine Room Layout (Volvo Option)
23. Battery Isolator 24. Trim Tab Pump 25. Genset Fuel Filter 26. Shore Power Cord Tub 27. Bilge Pump, 2200 GPH 28. Bilge Pump Float Switch 29. High Water Alarm Switch 37-R005D-4 Purple = optional equipment 2-13 460 Express Series... -
Page 22: General Layout - Engine Room Layout (Yanmar Option)
23. Battery Isolator 24. Trim Tab Pump 25. Genset Fuel Filter 26. Shore Power Cord Tub 27. Bilge Pump, 2200 GPH 28. Bilge Pump Float Switch 29. High Water Alarm Switch 37-R005D-2 Purple = optional equipment 2-14 460 Express Series... -
Page 23: Fuel Tank And Fittings
Model Specific Information FUEL TANK AND FITTINGS 1. Starboard and Port Fuel Tanks 2. Neoprene Gasket 3. Neoprene Gasket 4. Mylar Sound Foam 37-R002D 2-15 460 Express Series... - Page 24 1. Brass Elbow 2. Fuel Switch 3. Fuel Barb 4. Reducer 5. Fuel Barb 6. Fuel Tank Vent 7. Elbow 8. Fuel Switch 9. Reducer 10. Fuel Barb Purple = optional equipment (located on starboard tank only) 37-R003D 2-16 460 Express Series...
-
Page 25: Forward Engine Room Bulkhead (Volvo)
9. Oil X-Change-R Board 3. Starboard Engine Fuel Filter 10. Fuel Crossover Assembly 4. Port Engine Fuel Filter 11. Fuel Crossover Panel 5. Fuel Filter Board 12. Fuel Crossover Board 6. Blower Board -CHANGE- SYSTEM 37-R005D-3 2-17 460 Express Series... -
Page 26: Forward Engine Room Bulkhead (Yanmar)
12. Oil X-Change-R Board 4. Port Engine Fuel Filter 13. Fuel Crossover Assembly 5. Fuel Filter Board 14. Fuel Crossover Panel 6. Engine Room Light 15. Fuel Crossover Board 7. Blower Board 8. Blower -CHANGE- SYSTEM 37-R005D-1 2-18 460 Express Series... -
Page 27: Engine Room Electrical Panel
12. Terminal Bar (Negative) ENG NE ROOM C B PANEL BLOWERS 13. Battery Parallel Switch POWER LOWER MA N AUTOMATIC B LGE PUMPS 14. Engine Room C.B. Panel PME #1 6 15. Lower Engine Room Board 37-R009D 2-19 460 Express Series... -
Page 28: Hull Bonding Wire Layout
Section 2 HULL BONDING WIRE LAYOUT 37-R015D 2-20 460 Express Series... - Page 29 Port Transom Buss Bar (Jumper) (Jumper) Starboard Transom Buss Bar AC/DC Panel (Jumper) (Jumper) AC/DC Panel Port A/C Unit (10000 BTU) AC/DC Panel Starboard A/C Unit (16000 BTU) AC/DC Panel A/C Seacock AC/DC Panel Macerator Seacock AC/DC Panel Windlass 2-21 460 Express Series...
-
Page 30: Fresh Water Layout
16. Head Units 8. Galley Faucet, w/Spray 17. Flush Vent 9. ASR Head Faucet TRANSOM SHOWER & CITY WATER DETAIL MSR SHOWER DETAIL SEE MSR SHOWER DETAIL COCKPIT ICEMAKER 4 15 17 COCKPIT 37-R010D-1r WINDSHIELD SINK WASHER 2-22 460 Express Series... -
Page 31: Waste Layout W/Macerator
6. Waste Deck Plate 7. Waste Hose 8. Deck Pump Out Hose (To Deck) 9. Pump Out Hose (To Macerator) 10. Waste Tank Vent Hose 11. Pump Out Hose (To Seacock) Purple = optional equipment 37-R010D-4 2-23 460 Express Series... -
Page 32: Standard Waste Layout
Section 2 STANDARD WASTE LAYOUT 1. Waste Tank 5. Waste Hose 2. Head Unit, Standard 6. Pump Out Hose 3. Vent 7. Waste Tank Vent Hose 4. Waste Deck Plate 37-R010D-3r 2-24 460 Express Series... -
Page 33: Grey Water Layout
25. Engine Intake Hose 35. Washdown Strainer Hose 8. Galley Sink 18. Port A/C Condensation Hose 26. Engine Seacock 9. A/C Seacock 19. Starboard A/C Condensation 27. Engine Strainer (Merc/Volvo) 10. A/C Strainer Hose 28. Generator 2-25 460 Express Series... -
Page 34: Cockpit Draining
Section 2 COCKPIT DRAINING 1. Thru Hull 2. Thru Hull 3. Sink Drain Waste 4. Drain 5. Tee 6. Drain Hose (Storage, Sink and Hatch) 7. Drain Hose (Cockpit) 37-R004B 2-26 460 Express Series... -
Page 35: Lifting And Storing Your Boat
Undue stress will be put on the hull that may distortion. Contact your Cruisers Yachts Dealer to order a cradle. cause damage which is not covered under the warranty. - Page 36 Section 2 PLACE SLING HERE 105" (2.67m) 156" (3.96m) 37-R007B 297" (7.54m) 80" 186" 37-R013B (2.03m) (4.72m) 2-28 460 Express Series...
-
Page 37: Controls And Indicators
12 Volt Outlet..............3-4 Engine Ignition Start/Stop ..........3-9 Keypad ................3-4 Dim................. 3-9 Steering Wheel.............. 3-4 Keypad................3-10 Compass ............... 3-4 Engine Hourmeters ............3-4 Smart Craft Display Screen........... 3-4 Volvo Display Screen............. 3-4 Gear Select Gauge............3-4 460 Express Series... -
Page 38: Dash Panel Layout
Refer to your engine owner’s manual 9 - DEPTH FINDER for details, and see your Cruisers Yachts Dealer for more information. The depth finder can be turned ON by pushing the top of the adjacent accessory switch. -
Page 39: Bow Thruster (Optional)
• To trim the bow of your boat up, push the bottom halves of both the controls to NEUTRAL when the engines are not running. switches. Refer to SUGGESTED MANEUVERING TECHNIQUES in Section 6 of the Getting Started manual. 460 Express Series... -
Page 40: High Water Alarm
After the compass has been adjusted, DO NOT allow any iron or steel objects to be placed in its vicinity - even temporarily. Refer to the owner’s manual included in the Skipper’s Kit for detailed information. 460 Express Series... -
Page 41: Mercury Smart Craft Dash Panel Layout
Controls and Indicators MERCURY SMART CRAFT DASH PANEL LAYOUT 3970-003 460 Express Series... -
Page 42: Volvo Dash Panel Layout
Section 3 VOLVO DASH PANEL LAYOUT 3970-006 460 Express Series... -
Page 43: Yanmar Dash Panel Layout
Controls and Indicators YANMAR DASH PANEL LAYOUT 3970-007A 460 Express Series... -
Page 44: Keypad Switch Functional Description
If a wiper was ON prior to the washer cycle, it will remain on at The boarding lights will toggle ON when the BOARDING button on the its commanded speed both during and after the washer cycle. keypad is pressed. They will toggle OFF when the button is pressed again. 460 Express Series... -
Page 45: Engine Room Fans
The ENTER button also serves as a reset button if an error is made entering the four-digit code. Simply press the ENTER button and start over. IMPORTANT Each key press must be within three seconds of each other or the keypad will reset. 460 Express Series... -
Page 46: Keypad
STBD ENG ROOM ENGINE ENGINE STOP STOP FANS HORN PORT STBD ENGINE ENGINE BATTERY PARALLEL START START STBD PORT WINDLASS ENGINE ENGINE POWER WASHER PUMP PUMP STBD COCKPIT PORT PUMP BOARDING ENG ROOM SPREADER ANCHOR KEYPAD 3-10 460 Express Series... -
Page 47: Basic Systems Operation
Intl Stds 32 Amp (220V AC)..........4-14 Fuel System (Crossover Valve) ........4-6 AC Electrical System ............4-15 AC Master Panel............... 4-15 Steering System............. 4-6 AC Panel Circuit Breaker Functions ......... 4-17 Steering Wheel ..............4-6 Rudder ................4-7 460 Express Series... -
Page 48: Power Train
START button is enabled. The ENGINE START indicator will light when the engine tachometer signal is sensed, indicating engine and is returned to the sea via the exhaust system. 460 Express Series... -
Page 49: Transmission
2, 3, 4. If done correctly when pressing the final verification digit the system will unlock and the unlock LED will remain illuminated. Caution: Each key press must be within three seconds of each other or the keypad will reset. 460 Express Series... -
Page 50: Strut And Cutlass Bearing
The shaft seal and rubber tubing should be inspected monthly for wear, leakage and deterioration. Excessive water entry, especially if unattended, could result in the submergence of the engine compartment, or of the entire yacht. CUTLASS BEARING CSR161-7A 460 Express Series... -
Page 51: Propellers
Improper propeller selection and installation could result in loss of the propeller, and/or excessive stresses on the power train leading to power train failure. Cruisers Yachts recommends that you consult with, and employ the skills of your Cruiser Yachts Dealer when contemplating a propeller change. -
Page 52: Fuel System (Crossover Valve)
4. With the port handle pointing aft and the starboard handle pointing outboard, both engines receive fuel from the starboard tank. 5. With the port handle pointing outboard and the starboard handle pointing aft, both engines receive fuel from the port tank. 460 Express Series... -
Page 53: Steering Wheel
The pressure on the rudder face prevents “flutter” in a 0° rudder position. RUDDER BEARING AND SEAL 55-9/16" CENTER TO CENTER OF RUDDER 55-11/16" CENTER TO CENTER OF BALL JOINTS OF RUDDER CSR173-59 CSR178-11 460 Express Series... -
Page 54: Trim Tabs
(cylinders) which lower the trim tabs. To raise the trim tabs, the rocker switch is moved which allows oil to flow from the actuator to the pump. TRIM TAB TRIM PUMP ROCKER SWITCHES SOLENOIDS TRIM TAB ZINC PLATE CSR164-15A 460 Express Series... -
Page 55: Electrical System
Any modifications to the system should the engines and ignition switches are OFF the isolator prevents house always be done by an authorized Cruisers Yachts battery loads from discharging the cranking batteries. When the Dealer not only to protect your warranty, but to protect batteries are being charged by the alternators, the isolator you from hazardous shock. -
Page 56: Dc Master Panel
DC power by automatically opening the circuit should a short or overload condition occur. The resettable circuit breakers protect the system receiving the DC power by automatically opening the circuit should a short or overload occur. 4-10 460 Express Series... -
Page 57: Dc Panel Circuit Breaker Functions
Put the breaker in the ON position to connect power to the refrigerator. SPARE This breaker is a spare for future use. STEREO/TV AMP Put the breaker in the ON position to connect power to the stereo and the TV antenna amplifier. 4-11 460 Express Series... - Page 58 There are three additional circuit breaker panels located in the yacht for localized functions. The panel locations and func- CIRCUIT BREAKER tions are shown. PANELS 35-E001B-Manual LOCATED ON THE FORWARD BULKHEAD IN THE ENGINE ROOM PANEL LOCATED BELOW THE DASH LOCATED ADJACENT TO AC/DC PANEL 4-12 460 Express Series...
-
Page 59: Us Stds 50 Amp (240V Ac)
ELECTRICAL SHOCK HAZARD EX STS AND DAMAGE TO APPLIANCES WILL OCCUR DO NOT USE SHORE POWER WHILE RED LIGHT IS ON PORT STBD DISCONNECT THE SHORE CORD AND HAVE THE SHORE OUTLET STOP SERVICED BY A QUALIFIED ELECTRICIAN BEFORE USING 3970-002 4-13 460 Express Series... -
Page 60: Intl Stds 32 Amp (220V Ac)
ELECTRICAL SHOCK HAZARD EXISTS AND DAMAGE TO APPLIANCES WILL OCCUR DO NOT USE SHORE POWER WHILE RED LIGHT IS ON PORT STBD DISCONNECT THE SHORE CORD AND HAVE THE SHORE OUTLET SERVICED BY A QUALIFIED ELECTRICIAN BEFORE USING 3970-001 4-14 460 Express Series... -
Page 61: Ac Electrical System
AC POWER The circuit breakers’ function is twofold; they allow you to manually The standard AC electrical system in the 460 Express Series is wired enable or interrupt a circuit by flipping the switch on or off, and they for 120/240 volts AC, 50 amps, single phase, 60 hertz power. This... - Page 62 Disconnecting Shore Dockside Power: Switch the yacht DOCKSIDE 240/120V AC circuit breaker OFF. Switch the yacht dockside power circuit breaker OFF. Switch the shore dockside power circuit breaker OFF. Then the dockside power cable may be disconnected. 4-16 460 Express Series...
-
Page 63: Ac Panel Circuit Breaker Functions
Switch the breaker ON to connect power to the galley range. Refer to the Skipper’s Kit for range operation instructions. OUTLETS STBD Switch the breaker ON to connect power to the salon starboard dinette 120V AC outlets, the forward head GFCI outlet and the forward stateroom starboard outlet. 4-17 460 Express Series... - Page 64 Switch the breaker ON to turn on the water heater, if equipped. HEATER SPARE This spare circuit breaker is available for optional 240V AC equipment. SPARE This spare circuit breaker is available for optional 240V AC equipment. 4-18 460 Express Series...
- Page 65 For warranty service the boat must CONTRACT, STRICT TORT, OR ANY OTHER LEGAL THEORY. THIS LIMITATION DOES NOT be returned to the selling dealer or if determined by CRUISERS YACHTS to our factory. A boat may APPLY TO CLAIMS FOR PERSONAL INJURY.
Need help?
Do you have a question about the 460 Express Series and is the answer not in the manual?
Questions and answers