Page 1
Model Name Using Similar Mechanism DTC-A8 Tape Transport Mechanism Type DATM-55 SPECIFICATIONS L 13942296513 – Continued on next page – DIGITAL AUDIO TAPE DECK Sony Corporation 9-960-833-12 u163 2002A0500-1 Home Audio Company C 2002.1 Published by Sony Engineering Corporation http://www.xiaoyu163.com...
Page 2
3 7 63 1515 0 MODEL IDENTIFICATION – Model Number label (Printed in Back Panel) – MODEL NO. PCM-R500 DIGITAL AUDIO TAPE DECK US, Canadian model : AC 120 V 60 Hz 34 W : AC 230 V ⁄ 50/60Hz 34 W...
Page 3
SONY PARTS WHOSE PART NUMBERS APPEAR AS DE FONCTIONNEMENT. NE REMPLACER CES COM- SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB- POSANTS QUE PAR DES PIÈCES SONY DONT LES u163 LISHED BY SONY. NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
Page 4
http://www.xiaoyu163.com 3 7 63 1515 0 SECTION 1 This section is extracted from instruction manual. GENERAL L 13942296513 u163 – 4 – http://www.xiaoyu163.com...
Page 14
http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 SECTION 2 DISASSEMBLY Note: Follow the disassembly procedure in the numerical order given. HOLDER ASS’Y CASE 3 nylon washer 1 screw (step) 2 case 1 four screws (case)(M3 × 10) 4 screw (BVTT3 ×...
Page 15
http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 DRUM 3 two screws CAPSTAN MOTOR (B2 × 3) 3 two screws (B2 × 3) 2 capstan motor 2 connector (CN52) 1 flexible board (CN7) 4 drum 1 three screws (P1.7 ×...
Page 16
http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 SECTION 3 ADJUSTMENTS PRECAUTION 6. When adjusting tape pass and each guide, as shown below, it is 8. After adjustment is completed, perform the following checks to (4) Check that after performing the FF ()) or REW (0) a good practice to remove the holder assy and use the DAT cas- verify the tape speed.
Page 17
http://www.xiaoyu163.com 3 7 63 1515 0 3-1. MECHANICAL ADJUSTMENTS FWD Back Tension Adjustment When replacing any drum related parts, after S2, T2 and F guide adjustments have been made, tape pass fine adjustment (×1.5FWD Adjustment Method: 1. Enter the Test Mode 2 (Torque Measurement Mode) (see page mode) in Electrical adjustment should be performed.
Page 18
http://www.xiaoyu163.com 3 7 63 1515 0 Check that there is a difference of 650 ± 15 µsec between the 5. Put the REC MODE switch to the STANDARD 48k (ATF: ON) position and put the REMOTE switch to either the WIRED or oscilloscope’s SWP signal and the RF signal.
Page 19
http://www.xiaoyu163.com 3 7 63 1515 0 Replacement of Back-up Battery Adjustment and Check Locations : The back-up battery for clock is designed to serve for more than DIGITAL board – component side – seven years under normal service conditions (room temperature and ordinary humidity).
Page 21
http://www.xiaoyu163.com 3 7 63 1515 0 SECTION 4 DIAGRAMS • Circuit Boards Location Note: AUDIO board and DIGITAL board are supplyed as MAIN board. REG BOARD REMOTE BOARD DIGITAL OUT BOARD PRIMARY BOARD DIGITAL BOARD DIGITAL IN BOARD UNBAL BOARD ANA OUT BOARD REM SW BOARD ANA IN BOARD...
Page 22
http://www.xiaoyu163.com 3 7 63 1515 0 4-1. BLOCK DIAGRAMS (1) Power Section D503 T901 -33V REG -33V Q502, 503 FL701 F1, F2 D502 S901 IL901 +6V REG FWD PM FPM KICK PM902 POWER ~ AC IN IC902 DRIVE Q504, 505 PLUNGER FPM ON Q509, 511...
Page 23
PCM-R500 3 7 6 3 1 5 1 5 0 (2) Digital Audio Section J801 T801 DIGITAL IC508 IN/OUT SIGNAL SELECT – (1/4,4/4) AES/EBU IN IC511 NORMALIZER DIGITAL ADDI RS-422 RECEIVER IC508 (2/4) IC801 (1/2) IC509 (1/2) COAXIAL DADT...
Page 24
PCM-R500 3 7 6 3 1 5 1 5 0 (3) Analog Audio Section LINE AMP LINE AMP RV301 IC323 (1/2) IC324 (1/2) A/D CONVERTER J305-1 REC LEVEL IC307 CH-1 (L) SBM DIGITAL FILTER LINE AMP – AINR+ IC308...
Page 25
PCM-R500 3 7 6 3 1 5 1 5 0 (4) System Control Section DRUM BUFFER MOTOR DRIVE IC522 D PWM FLUORESCENT IC1 (2/2), Q1, 2 (1/2) INDICATOR TUBE FL701 POWER TRANSFORMER DRM ON T901 P24-P1 2G-11G DRUM 18-20, 24...
Page 26
http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3...
Page 27
http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3...
Page 28
http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 http://www.xiaoyu163.com...
Page 29
http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 http://www.xiaoyu163.com...
Page 30
http://www.xiaoyu163.com w w w http://www.xiaoyu163.com...
Page 31
http://www.xiaoyu163.com w w w http://www.xiaoyu163.com...
Page 35
http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 http://www.xiaoyu163.com...
Page 36
http://www.xiaoyu163.com 3 7 63 1515 0 • IC Block Diagrams IC1 CXA1364R (RF AMP board) 48 47 46 45 42 41 40 39 38 LIM OUT ALPC LIM GND A PC MOD1 IN REC OCA LOGIC MOD2 IN LIM VCC A HA IN ENV OUT A RA OUT...
Page 39
http://www.xiaoyu163.com 3 7 63 1515 0 IC518 MSM6782-01-MS (DIGITAL board) IC523 M54641L (DIGITAL board) CONTROL TIME REGISTER REGISTER STD.P (SEC-YEAR, WEEK) OUT2 POWER DECODER OUT1 INPUT IN 1 CONTROL DATA ADDRESS DATA BUFFER COUNTER IN 2 INPUT POWER REFERENCE IC702 MSM6338RS (DISPLAY board) READ WRITE LOGIC...
Page 40
http://www.xiaoyu163.com 3 7 63 1515 0 4-12. IC PIN FUNCTION DESCRIPTION • AUDIO BOARD IC308 CXD8482Q (SBM + Digital Filter) Pin No. Pin Name Function TEST Test input pin. “H” for test mode and “L” for normal mode. (Fixed at “L” level in this set.) —...
Page 41
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Function — Empty pin FS select of data output. (“H”: 2FS output or EX mode, “L”: FS output) OSEL (Fixed at “L” level in this set.) OBIT Bit select of data output. (“H”: 24 bits, “L”: 16 bits) (Fixed at “L” level in this set.) Write clock output (Not used in this set, empty pin.) L/R channel data signal output —...
Page 42
http://www.xiaoyu163.com 3 7 63 1515 0 • DIGITAL BOARD IC501 CXP87540-033Q (Main Microcomputer) Pin No. Pin Name Function SBM-ON SBM (Super Bit Mapping) ON/OFF select pin (“L”: OFF, “H”: ON) XBAL Analog input select (“L”: BAL, “H”: UNBAL) OBIT-SEL Not used. 4, 5 —...
Page 43
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Function SR-DTO Pin for serial data output to master DAT-DSP IC. SR-CK Pin for serial clock output to master DAT-DSP IC. AVSS — Ground AVREF — Reference voltage pin (+5V) AVDD —...
Page 44
http://www.xiaoyu163.com 3 7 63 1515 0 • DIGITAL BOARD IC502 CXP87532-012Q (Mechanism Microcomputer) Pin No. Pin Name Function FPM-KI FWD plunger kick control output CAP-RVS Capstan rotation direction control output. “H” for FWD and “L” for REV. BPM-ON Brake plunger ON control output BPM-KI Brake plunger kick control output DRM-ON...
Page 45
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Pin Description — — Not used. — XMECH-REQ Communication request input from main microcomputer (IC501). MECH-DTI Serial data input from main microcomputer (IC501). MECH-DTO Serial data output to main microcomputer (IC501). MECH-SCK Serial clock input from main microcomputer (IC501).
Page 46
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Function — Not used. — XTLK Reel motor T LOCK control output. “L” for T LOCK. FPM-ON FWD plunger ON control output L 13942296513 u163 – 78 – http://www.xiaoyu163.com...
Page 48
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Function TST4 Test pin (Fixed at “L” level.) RX-PLL phase comparator output SELC Oscillation frequency select signal input (Fixed at “L” level in this set.) MUTA Mute input. “H” to mute, and REC monitor sound is also muted. PLCO RX-PLL’s external VCO clock input (512fs reference) Output of phase comparator signal for RX-PLL.
Page 50
http://www.xiaoyu163.com 3 7 63 1515 0 • DISPLAY BOARD IC701 CXP82320-077Q (Display Controller) Pin No. Pin Name Function MODE Fixed at “H” level. Remote control input from IC704. TEST Test mode setting pin A1 METER Address 1 output to IC702. A2 METER Address 2 output to IC702.
http://www.xiaoyu163.com 3 7 63 1515 0 SECTION 5 EXPLODED VIEWS NOTE: • Items marked “*” are not stocked since they • -XX and -X mean standardized parts, so they The components identified by mark ! or dotted line with mark ! are may have some difference from the original are seldom required for routine service.
Page 52
Part No. Description Remark 3-007-731-01 PANEL, FRONT 4-983-619-11 RING, SHUTTLE X-4947-852-1 KNOB (1) ASSY 3-354-981-01 SPRING (SUS), RING 4-908-848-31 EMBLEM, SONY 4-983-620-01 DIAL, JOG 3-917-216-31 KNOB (TIMER) 4-986-398-01 WINDOW, INDICATION * 55 1-664-483-11 REM SW BOARD X-3372-928-1 BASE ASSY, PANEL 4-951-620-01 SCREW (2.6X8), +BVTP...
Page 53
http://www.xiaoyu163.com 3 7 63 1515 0 (3) CHASSIS SECTION r A: AUDIO board r B: DIGITAL board T901 L 13942296513 not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 4-956-885-01 FOOT (F58175S2W) * 112 A-2007-648-A MAIN BOARD, COMPLETE 4-923-520-71 BUTTON,POWER 1-769-542-11 WIRE (FLAT TYPE) (31 CORE) * 114...
Page 54
http://www.xiaoyu163.com 3 7 63 1515 0 (4) CASSETTE COMPARTMENT SECTION-1 not supplied L 13942296513 supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark * 151 X-3371-758-1 PLATE ASSY, FULCRUM 3-632-859-00 SPRING, BRAKE LEVER RETURN 3-373-225-01 HOLDER (WINDOW) 3-318-203-61 SCREW (B1.7X4), TAPPING 3-373-220-01 ARM (JOINT) 3-373-216-01 SPRING (L), TORSION...
Page 55
http://www.xiaoyu163.com 3 7 63 1515 0 (5) CASSETTE COMPARTMENT SECTION-2 not supplied M905 not supplied DATM-55 L 13942296513 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-562-462-00 BELT, CAPSTAN A-2003-907-I CHASSIS (L) ASSY 3-373-214-01 PULLEY 2-623-756-01 SCREW, (B1.7X3), TAPPING 3-373-213-01 GEAR, DRIVING * 208 1-655-913-11 MOTOR BOARD...
Page 56
http://www.xiaoyu163.com 3 7 63 1515 0 (6) MECHANISM DECK SECTION-1 (DATM-55) not supplied 261 260 M901 supplied L 13942296513 not supplied PM902 not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark * 251 1-654-393-11 REC EN BOARD 3-564-035-01 SPRING, COMPRESSION 3-344-781-01 WASHER, POLYETHYLENE * 265...
Page 57
http://www.xiaoyu163.com 3 7 63 1515 0 (7) MECHANISM DECK SECTION-2 (DATM-55) M904 not supplied L 13942296513 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-912-011-01 CATCHER * 301 1-654-392-11 S END BOARD 3-929-804-01 SPRING,TENSION 3-573-470-00 SPRING, COMPRESSION X-3371-230-1 LEVER (CLEANER) ASSY X-3371-518-1 ROLLER GUIDE ASSY X-3362-029-1 SLANT BLOCK (R2) ASSY...
http://www.xiaoyu163.com 3 7 63 1515 0 SECTION 8 ANA IN ANA OUT ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in the • SEMICONDUCTORS The components identified by mark ! or dotted line with mark ! are parts list may be different from the parts speci- In each case, u: µ, for example: critical for safety.
Page 60
http://www.xiaoyu163.com 3 7 63 1515 0 ANA OUT DIG IN DIG OUT Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C379 1-136-165-00 FILM 0.1uF < VARIABLE RESISTOR > < CONNECTOR > RV102 1-223-877-11 RES, VAR, CARBON 10K (ANALOG OUT CH-1 (L) LEVEL) CN311 1-691-766-41 PLUG (MICRO CONNECTOR) 4P...
Page 61
http://www.xiaoyu163.com 3 7 63 1515 0 DIG OUT DISPLAY Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < JACK > < TRANSISTOR > J802 1-750-787-11 CONNECTOR (XLR TYPE) 3P Q701 8-729-620-05 TRANSISTOR 2SC2603-EF (DIGITAL OUT AES/EBU) Q702 8-729-620-05 TRANSISTOR 2SC2603-EF Q703...
Page 75
PCM-R500 Printing Method for Large Sized Documents Such As Circuit Diagrams 3 7 63 1515 0 Printing the page that exceeds A4-size two pages (or letter size) is possible by specifying the print range. (Acrobat Reader Version 4.0 or later) 1.
Page 76
PCM-R500 3 7 63 1515 0 REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page.
Need help?
Do you have a question about the PCM-R500 and is the answer not in the manual?
Questions and answers