Weber lp gas barbecue owner's manual 2000 lx series (36 pages)
Summary of Contents for Weber SUMMITT M425
Page 1
S U M M IT 425 & 450 LP Gas Barbecues Operating Guide Read before assembly Summit 450 LP Summit 425 LP Serial Number Serial Number FOR YOUR SAFETY WARNING: F o l l ow all leak ch e ck pro c e d u r e s 1.
LP unit or LP gas in a natural Do not operate the Weber Gas Barbecue if there is a gas unit is dangerous and will void your warranty. gas leak present.
TABLE OF CONTENTS Warnings Steam-N-Chips Smoker Warranty Maintenance 10-12 A Word of Thanks Spider Stopper Guards Inspection and Cleaning of the Standards and Codes Information Spider Stopper Guards Operating Area Main Burner Flame Pattern Storage Main Burner Cleaning Procedure Replacing the Main Burners *REFER TO YOUR STEP-BY-STEP SECTION AT Crossover Ignition System Operations THIS TIME...
Weber does not authorize any person or company to assume for it any other obligation or liability in connection with the sale, installation, use, removal, return, or replacement of its equipment; and no such representations are binding on We b e r.
Keep the cooking area clear of flammable vapors and liquids, such as gasoline, alcohol, etc., and The Weber Gas Barbecue is portable so you can easily combustible materials. change its location in your yard or on your patio.
LIGHTING EACH HEAT ZONE OPERATES INDEPENDENTLY. 1) Open the lid. Figure 1. Summary lighting instructions are on the control panel. 2) Check that the fuel scale reads more than “E”. Note - E = empty; F = full. 3) Make sure all burner control knobs are OFF. (Push each burner control knob down and turn clockwise.) WARNING: The b urner control knobs must be in the High...
MANUAL LIGHTING EACH HEAT ZONE OPERATES INDEPENDENTL Y. DANGER When the excess flow control is activated, a small amount of gas is still flowing to the burners. After turning OFF the tank and burner control knobs,wait at least 5 minutes for the gas High Medium to clear before attempting to light the barbecue.
COOKING CLEANING The Weber Gas Barbecue should not be moved when CAUTION: Turn your Weber Gas Barbecue OFF and operating or hot. wait for it to cool before cleaning. CAUTION: Do not clean your Flavorizer Bars or cooking grills in a self-cleaning oven. Replacement...
As a starting point, place a handful of FireSpice Chips or a few FireSpice Chunks in the bottom of the smoker body. a c c u mulate on the inside of your Weber Gas Barbecue. Figure 4. Since the chunks vary in size, place as many as This residue need not be removed and will not adve r s e l y you can in the smoker allowing room for the water pan.
Spider Stopper Guards with a soft bristle brush (an old toothbrush for example). Check that there are no gaps in the Spider Stopper Guards’ seams or in the fit around the burners or valves. Weber Spider Stopper Guard Figure 6...
Main Burner Flame Pa t t e r n Replacing Main Burners 1. Your Weber Gas Barbecue must be OFF and cool. The Weber Gas Barbecue burners have been factory set for the correct air and gas mixture. The correct flame 2.
Page 12
MAINTENANCE 9. Unlatch the Spider Stopper Guards and remove. 11. Slide the burner assembly from each Heat Zone. The Figure 12. left and right burners are connected by the Crossover tube. Figure 14 (a). Pull out of here Crossover tube Figure 12 10.
Check to see if the igniter is loose in the frame. Orifice Tighten if necessary; See Step “Install igniter” for correct procedure. If the Crossover Ignition System still fails to light, contact Weber-Stephen Customer Service. White wire Black wire Figure 16 Figure 18...
Fuel scale shows that there is gas in the Fuel scale must be adjusted with Check adjustment of fuel scale. LP tank, but tank is empty. an empty tank. If problems cannot be corrected by using these methods, please contact Weber-Stephen Customer Service.
While we give much attention to our products, Manifold assembly unfortunately an occasional error may occur. If a part is Manifold mounting clips (2) missing, do not go back to the store. Call the Weber Control panel Customer Service Center toll free 1-888-33-SUMMIT Igniter button (2) (1-888-337-8664) to receive immediate assistance.
Page 19
Gas catcher ignition chamber (2) unfortunately an occasional error may occur. If a part is Spider stopper guard (4) missing, do not go back to the store. Call the Weber Manifold assembly Customer Service Center toll free 1-888-33-SUMMIT Manifold mounting clips (2) (1-888-337-8664) to receive immediate assistance.
Flavorizer and Crossover are registered U.S. trademarks; Summit, Grill Cozy, Gas Catcher, Spider Stopper, and Steam-N-Chips, are trademarks, all of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Summit Series Gas Barbecues are covered by U.S. Patent Nos. 4,677,964; 4,727,853; 4,777,927;...