Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Team C TC02C
Summary of Contents for Team C TC02C
- Page 1 1:10 SCALE 2WD ELECTRIC COMPETITION BUGGY Dimensions Length Width Height...
- Page 2 Notice Thank you for purchasing this TC02C Competition Buggy by Team C. This manual shows instructions and tips to built and maintain your TC02C. Please take some time to read through to get familiar with the shown steps. We continually improve our products, due to that, actual parts my be different to the illustrations.
- Page 3 Transmitter Preparation 27MHzTransmitter Crystal Power Switch Antenna Transmitter crystal(TX) Receiver crystal(RX) Extend the antenna to the maximum Length for best performance The crystal can be replaced to change frequencies. Note : You must also change receiver crystals! Do not use AM crystals Battery Level Indicator Good Batteries Straight (neutral)
- Page 4 Transmitter Preparation A new Ni-MH battery must be charged before it is used.Refer to the charger instruction manual for charging. Set up the radio control system as indicated below Motor Battery Electronic Speed Controller Switch Transmitter Servo Receiver Start Install batteries.(Transmitter) Extend the antenna.(Transmitter) Connect the battery Extend the antenna.(Reveiver)
- Page 5 Front Suspension T02014 T02016 T02037 T02056 T02056 2.3 E-ring ………………………4 T02056 T02056 3x34.5 Hinge pin front inner T02016 ………………………2 Front Suspension T02092 T02015 T02008 T02026 T02083 M3x15 Screw …………4 T02092 Ball stud-Long T02083(M3x15) …………………2 Assemble both Left and Right Assemble both Left and Right...
- Page 6 Buffer T02080 T02080 T02043 T02023 T02043 T02061 T02043 T02023 T02043 T02023 T02080 T02043 4.0 E-ring ……………………1 T02043 T02080 3x6x2.5 Ball Bearing ……………………4 T02061 Ball stud-Silvery T02080 ……………………1 Buffer T02044 T02093 T02044 4.5x5.4 Block Carrier …………………………2 T02024 T02044 M3x10 Screw ……………2 T02093 Ball stud-Short T02044 …………………2...
- Page 7 Front Suspension T02082(3x10) T02019 T02082 M3x10 Screw ……………2 Front Suspension T02093 T02042 T02093 T02042 T02011 T02012 T02100 T02054 T02034 T02054 T02054 T02054 T02100 5x10x4 ball bearing T02054 2.3 E-ring T02042 2x9.8 Shaft T02042 4.0 E-ring T02054 3x27.5 Hinge pin front outer T02093 Ball stud - short …………4 …………2...
- Page 8 Projection.Note direction Front Suspension Front Upper(Right) approx.38mm T02029 Projection.Note direction T02091 Front Upper (Left) T02029 approx.38mm Projection.Note direction Steering Tip approx.34mm T02029 4.8mm Ball End(Long) T02091 3x54 Turnbuckle ……4 …………8 Front Suspension Front Suspension T02082(M3x22) T02063 T02082(M3x10) T02020 T02082 M3x22 Screw T02082 M3x10 Screw T02063 5mm Ball stud ……2...
- Page 9 Differential T02099(10x15x4) T02050(2.6x6x3) T02046 T02049(17x23x1) T02007(2.5x25) T02098(5x8x2.5) T02046 T02048(2.37) T02047 T02007(M2.5) T02004 T02049(17x23x1) T02098(5x8x2.5) T02099(10x15x4) T02007 T02049 17x23x1 Washer T02098 5x8x2.5 ball bearing T02099 10x15x4 ball bearing ……………………………2 ……2 T02007 M2.5x25 Screw T02007 M2.5 Nylon Nut T02048 2.37mm Ball ……………………2 ………………12 ……………1 ……1...
- Page 10 Rear Chassis T02082(M3x12) T02203 T02082 M3x12 Screw …………4 Motor Mount T02082(M3x10) T02224 T02213(M3x27) T02208 Screw Cement T02082 M3x10 Screw ……………1 T02082 M3x27 Screw ……3 Apply threadlocker(screw cement) Screw Cement...
- Page 11 Spur Gear T02084 M4 Flanged Nylon Nut T02039 ………………1 T02211 T02211 5x7 Top shaft spacer ……………………1 T02039 T02040 T02038 T02038 T02084 T02001 T02038 Motor Motor Motor Tighten the screws with one sheet of paper T02053 M3x3 Screw inserted between both gears. ……………………1 T02083 M3x8 Screw T02083(M3x8)
- Page 12 Rear Shock Tower T02082(M3x22) T02063 T02025 T02205 T02082 M3x10 Screw ………………2 T02082 M3x12 Screw T02063 T02082(M3x12) ……………2 T02082(M3x10) T02082 M3x22 Screw T02082(M3x12) …2 T02082(M3x10) T02082(M3x22) Rear Suspension T02082 M3x10 Screw T02082(M3x10) ………………6 T02082(M3x10) Rear Suspension T02093 Ball stud-short …………………2 <Left> T02034 2x9.8 Shaft T02058 T02013...
- Page 13 Rear Suspension T02013 T02057 T02013 3.1x6x1 Plastic Washer T02057 3x30.5 Hinge pin Rear outer T02057 2.3 E-ring T02057 …………4 ………………………2 …………2 T02057 Rear Suspension Projection.Note direction T02029 4.8mm Ball End(Long) Right Upper approx.35mm …………4 T02029 T02029 T02091 3x54 Turnbuckle T02091 …………2 Rear Suspension T02093...
- Page 14 Shock Absorber Front-Short Rear-Short T02064/T02065 2.3 E-ring T02095 Put a little oil ………………………8 T02094 T02097 T02096 Shock Piston T02097 Put a little oil T02097(2.8x1.9) ………………4 T02097(3.1x1) T02097(2.8x1.9) T02065 T02097(3.1x1) T02097(2.8x1.9) T02097 2.8x1.9 O-ring T02064 T02095 T02097(2.8x1.9) …………………8 T02096 T02094 T02096 T02097 3.1x1 Plastic Washer T02095(Long) T02094(Short)
- Page 15 Shock Absorber Front-Short for adjusting the spring tension T02094/T02095 Compress the spring and install T02031 T02071(Short) T02094/T02095 12x1 O-ring T02031 Rear-Short ……………4 T02072(Long) Front Suspension T02084(M3) T02082(M3x15) T02084 M3 Nylon Nut ………………2 T02082 M3x15 Screw ………2 Assemble as many times as specified Assemble both Left and Right Assemble both Left and Right...
- Page 16 Rear Suspension T02084(M3) T02084 M3 Nylon Nut ………………2 T02082(M3x15) T02082 M3x15 Screw ………2 Front Suspension T02082(M3x10) T02222 T02082(M3x10) T02082 M3x10 Screw ……………6 Assemble both Left and Right...
- Page 17 Rear Suspension Rear Suspension T02083 M3x10 Screw ……………5 T02083 M3x12 Screw ……………2 T02083(M3x10) T02083(M3x12) T02083(M3x10) T02083(M3x10) T02083(M3x10) Battery Mount / Body Mount T02083(M3x10) T02083 M3x8 Screw T02025 ………………4 T02083 M3x10 Screw ……………2 T02212 T02083(M3x8) T02083(M3x8) T02083(M3x8)
- Page 18 Steering Servo T02081 Select for your servo T02030 T02061 Steering Servo-H(24T) Steering Servo-S(23T) T02028 Sanwa servo T02028 T02082(2.6x8) T02035 T02027 Steering Servo-F(25T) T02082 T02030 4.8 Ball End(Short) T02081 3x7x0.8 Washer T02061 Ball stud - silvery ……………2 ………………1 ………………4 T02035 1.5 Servo spacer T02030 M3x10 Screw T02082 M2.6x8 Screw T02082 M3x8 Screw...
- Page 19 Receiver / ESC T02087 Receiver T02087 Double-sided Tape T02213 T02213 M3x3 Screw ……………………1 Battery Battery T02223 T02086 Battery T02086 Small clip ……………4 Must be purchased separately Must be purchased separately...
- Page 20 Wing T02086 T02086 Small clip ……………2 T02220 T02025 Tyre Front T02074 Rear T02075 T02075(Sponge) T02074(Sponge) T02032 T02033 After fitting wheels to tyres, apply instant glue as shown. Assemble as many times as specified Must be purchased separately Must be purchased separately...
- Page 21 Tyre T02084 M4 Flanged Nylon Nut ……………4 T02084 Tyre T02221 Assemble both Left and Right...
- Page 22 Body Mask the windows from the inside. Paint the body shell from the inside using spray colors. Body T02086 T02221 T02086 Small clip ……………3 Assemble as many times as specified...
- Page 24 Parts list for TC02C off-road buggy - 1 T02203 T02204 T02205 T02206 T02207 Rear shock tower 1pcs 1pcs 1pcs Rear arm mount-R Rear chassis plate Differential-L Differential-R 1pcs Rear brace mount 1pcs 1pcs T02211 T02213 T02212 T02208 M3x27 Screw Motor plate...
- Page 25 Parts list for TC02C off-road buggy - 2 T02029 T02030 T02031 T02032 T02033 Upper cover nylon cap 2pcs Spring Mount 4.8 Ball End - Long 2pcs 6pcs 5.8 Ball End Front rim Rear rim 4.8 Ball End - Short 3x10 Screw...
- Page 26 Parts list for TC02C off-road buggy - 3 T02063 T02064 T02065 T02094 12x1 O-ring Shock Absorber top cover 2pcs 3x42.5 Front Shock Absorber Shaft 3x51 Rear Shock Absorber Shaft 8x1 O-ring 2pcs 2pcs 2pcs 2pcs 2.3 E-ring Front damper case 2.3 E-ring...
- Page 27 Parts list for TC02C off-road buggy-4 Tu0222 T02087 Tu0219 Antenna pipe set cover 1pcs M3x3 Double-sided tape 1pcs Antenna pipe set Front arm mount 1Set C-Type-Holder 25 Degree - R C-Type-Holder 25 Degree - L 1pcs 1pcs 1pcs Tu0220 Tu0224...
- Page 28 TC02C Driver Track / City SETUP SHEET for the Event Date TeamC TC02C Conditions Low traction Bumpy Med traction Smooth Grass Soft dirt Hard soil High traction Sandy Clay Dusty Other Front Suspension Front Shocks Shock Mounting&Camber link Toe-in (+)/Out (-) °...
- Page 29 HOBBYPRO COMPANY LTD. Flat C-D, 5/F., Speedy Ind. BLDG., 114 How Ming Street, Kwun Tong, KLN., Hong Kong. Team C Headquarter www.teamcracing.net Team C America www.teamcamerica.com Team C Europe www.teamceurope.com...