Copyright 2010 All rights Reserved Land Pride provides this publication “as is” without warranty of any kind, either expressed or implied. While every precaution has been taken in the preparation of this manual, Land Pride assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Land Pride reserves the right to revise and improve its products as it sees fit.
For Your Protection Thoroughly read and understand the “Safety Label” section, read all instructions noted on them. PS2096 Series Primary Seeders 313-308M WARNING Indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury, and includes hazards that are exposed when guards are removed.
Page 4
Allow only enough slack in the chain to permit turning. Do not use safety chain for towing. PS2096 Series Primary Seeders 313-308M Table of Contents Transport Machinery Safely Comply with state and local laws. Maximum transport speed for implement is 20 mph.
Page 5
Operating equipment safely requires the full attention of the operator. Avoid wearing radio headphones while operating machinery. PS2096 Series Primary Seeders 313-308M Avoid High Pressure Fluids Hazard Escaping fluid under pressure can penetrate the skin causing serious injury.
4. Some new equipment installed during repair require safety labels to be affixed to the replaced component as specified by Land Pride. When ordering new components make sure the correct safety labels are included in the request. To order new labels go to your Land Pride dealer.
Page 7
Important Safety Information 20606 6/15/10 Table of Contents 20579 20575 20606 PS2096 Series Primary Seeders 313-308M 818-230C Red Reflector 818-229C Amber Reflector 818-543C Small Grass Seed Option DANGER: Guard Missing (Beneath Guard) 838-111C Small Grass Seed Option DANGER: Keep away,...
Page 8
Table of Contents Important Safety Information 818-230C 20593 Small Grass Seed Option Red Reflector 818-055C 20592 Small Grass Seed Option SMV: Slow Moving Vehicle PS2096 Series Primary Seeders 313-308M 6/15/10...
Introduction Introduction Land Pride welcomes you to the growing family of new product owners. This Seeder has been designed with care and built by skilled workers using quality materials. Proper assembly, maintenance, and safe operating practices will help you get years of satisfactory use from the machine.
Proper tension and alignment on all drive chains. Safety decals are correctly located and legible. Replace if damaged. PS2096 Series Primary Seeders 313-308M Table of Contents Sling Bracket Refer to Figure 1-1 Reference The sling brackets allow points at each end to hook the Operator’s...
(#16) installs properly. The chain guard mounts are slotted for easier chain guard mounting. PS2096 Series Primary Seeders 313-308M Table of Contents 3. Install chain idler with welded on spacer (#2) and chain idler (#3) with 1/2”...
5. Attach the rubber seed tubes to the seed cups and then through the small seed holes below. Remove SMV and plug the 2 Holes Small Seeds Box Assembly Figure 1-6 Attach hose to seed cups and through holes below PS2096 Series Primary Seeders 313-308M 20596...
(#15) installs properly. The chain guard mounts are slotted for easier chain guard mounting. PS2096 Series Primary Seeders 313-308M Table of Contents 3. Install chain idler with welded on spacer (#2) and chain idler (#3) with 1/2”...
2. Flip locking release handles up on pull tongue. 3. Lower tongue until the links are free from the seeders lower pins. Handles Lift Cylinder Pull Tongue Assembly Figure 1-9 Bottom Holes of Upper Center Hitch Inside Smaller Pins Hitch Link 20740 PS2096 Series Primary Seeders 313-308M...
Set speed change sprocket for drive type desired. Set seed rate. See “Seed Rate Charts”. PS2096 Series Primary Seeders 313-308M Table of Contents Seeder Preparation Before proceeding with the first time set-up, or before making any adjustments mentioned in this section, make every effort to attach the seeder to a tractor.
3. To prevent the seeder from tipping backward, remove rear roller lock pin from storage position and place in parking position. Refer to Figure 2-2 4. Unhitch from tractor. 20579 Rear Roller Pin in Parking Position PS2096 Series Primary Seeders 313-308M Figure 2-2...
The front and rear roller packing wheels should turn freely. In field position, the rear roller assembly should be free to float up and down to follow the terrain of your field. See Figure 2-1 on page 15. PS2096 Series Primary Seeders 313-308M Table of Contents 6/15/10...
If this figure is different than desired, set your seed cup adjustment lever accordingly. PS2096 Series Primary Seeders 313-308M Table of Contents 5. You may want to repeat the calibration procedure if the results of your calibration vary greatly from the suggested settings on the chart.
High Range Low Range Kentucky Blue Grass (Pounds per Acre) High Range Low Range Kentucky Blue Grass (Pounds per 1000 Square Feet) High Range Low Range PS2096 Series Primary Seeders 313-308M Table of Contents 11.1 12.8 14.4 16.1 17.7 10.9 11.5...
Low Range Kentucky Blue Grass (Kilograms per 1000 Square Meters) High Range Low Range PS2096 Series Primary Seeders 313-308M Table of Contents 1021 1102 1181 1263 1341 1421 1503 1581 1021 1086 1152 1219 1286 1350 1071 1155 1235 1317 1401 1481 1563 1647...
Page 25
High Range Low Range Wheatgrass - Western (Kilograms per 1000 Square Meters) High Range Low Range 6/15/10 Table of Contents 1035 1093 151 1030 1089 1148 1206 1268 1027 1089 1151 1218 1278 PS2096 Series Primary Seeders 313-308M 1209 1027...
Petroleum will absorb into the plastic and swell the plastic components. Roller Bearings Type of Lubrication: Multi-Purpose Quantity = Coat Generously 20575 PS2096 Series Primary Seeders 313-308M Intervals in hours at which lubrication is required Hours Hours...
Optional small seeds box with 2 bushel capacity may be added to the PS2096 PS 2096 Pull Type Hitch 69” Center to Center 95” Quick Attach Type Hook-Up 9.5” L X 15” 12 Ply Tires 4” X 14” with Transport Lock valve Standard 720 lbs. PS2096 Series Primary Seeders 313-308M...
Adjustable track removers Spring tine track removers effectively scratch out the tracks from the tractor tires. #40 Roller chain All drives utilize #40 roller chain for smooth running. PS2096 Series Primary Seeders 313-308M Table of Contents PS20 Series Primary Seeder Benefits...
Seed treatment will affect seeding rate if the chemicals build up in seed cup. Unless cleaned regularly, this build up can cause breakage of the seed cup shaft. Check for foreign matter lodged in seed cup sprocket. Check for trash or mud build-up on roller end. PS2096 Series Primary Seeders 313-308M...
1180 2640 1 1/2" - 12 1330 2970 Torque tolerance + 0%, -15% of torquing values. Unless otherwise specified use torque values listed above. PS2096 Series Primary Seeders 313-308M Table of Contents Bolt Size (Metric) Grade 8 mm x M 5 X 0.8 M 6 X 1 M 8 X 1.25...