Dynacraft 6V QUAD Owner's Manual

Hide thumbs

Table Of Contents

OWNER'S MANUAL

6V QUAD

DO NOT RETURN TO STORE!

QUESTIONS OR COMMENTS?

STOP

1-800-288-1560

FOR AGES 18-36 MONTHS

MAXIMUM WEIGHT: 40 lbs. (18 kgs.)

NOTE: Illustrations in this Manual are for reference purposes only and may not reﬂect the exact

appearance of the actual product. Speciﬁcations are subject to change without notice.

Table of Contents

Summary of Contents for Dynacraft 6V QUAD

Page 1 OWNER’S MANUAL 6V QUAD DO NOT RETURN TO STORE! QUESTIONS OR COMMENTS? STOP 1-800-288-1560 FOR AGES 18-36 MONTHS MAXIMUM WEIGHT: 40 lbs. (18 kgs.) NOTE: Illustrations in this Manual are for reference purposes only and may not reﬂect the exact...
Page 2: Table Of Contents
TABLE OF CONTENTS A Introduction, Safety and Warnings B Before You Begin Assembly C List of Assembled Parts D Assembly E How to Use F Detailed Maintenance and Repair G Troubleshooting Guide H Warranty ELECTRIC CAR SPECIFICATIONS SUITABLE AGE 18-36 months CAPACITY under 40lbs (18kgs) SPEED...
Page 3: A Introduction, Safety And Warnings
INTRODUCTION, SAFETY, AND WARNINGS ABOUT THIS MANUAL: This Manual was written to help you and your child get the most performance, comfort, enjoyment and safety when riding your new electric ride- on toy. It is important for you to understand your new electric ride-on toy. By reading this manual before you let your child go out on his/her first ride, you will know how to get the most from your new electric ride-on toy.
Page 4 Always wear appropriate clothing and shoes, including long sleeved shirts and long pants and lace-up or similar shoes with rubber soles. Never ride barefoot or in sandals and make sure that shoelaces or other fasteners are tied and kept away from the wheels and drive system of the ride-on toy.
Page 5 • Observe the age and weight limitations on the cover of this manual. • Alway stay seated while riding the electric ride-on toy. To stop you must take your hand off of the throttle button on the handlebar. • Children must be supervised by an adult at all times to be safe. • Always be alert and ride your electric ride-on toy defensively.
Page 6: Using The Charger
• That all guards and pads originally supplied by the manufacturer are in proper place and in serviceable condition; • That the area that the unit is to be operated in is safe and suitable for safe operation; • That all safety labels are in place and understood by everyone, including the rider; • That any and all axle guards, chain guards, or other covers or guards supplied by the manufacturer are in place and in serviceable condition;...
Page 7: B Before You Begin Assembly
BEFORE YOU BEGIN ASSEMBLY WARNING Remove all packing and items from the display box. Make sure that the power switch is turned “OFF” before assembling the electric ride-on toy. ESTIMATED ASSEMBLY TIME You should allow approximately 20 minutes for assembly, not including initial charging time.
Page 8: C List Of Assembled Parts
LIST OF ASSEMBLED PARTS 1. Main Body (with seat) 2. Charger (6 volt, 0.5A) 3. Handlebar Assembly If you experience a problem with this product, or are missing a part, please call us at 1-800-288-1560, rather than return this product to the store. Please identity all parts before assembly and save all packaging material until assembly is complete to ensure that no parts are discarded.
Page 9: D Assembly
ASSEMBLY Your new vehicle requires adult assembly. Please set aside around 20 minutes for assembly. Please identify all parts before assembly and save all packaging material until assembly is complete to ensure that no parts are discarded. WARNING Children can be harmed by small parts, sharp edges and sharp points in the vehicle’s unassembled state, or by electrical items.
Page 10: Battery Charging
• Connect handlebar and control module • Turn the vehicle upright. connectors as shown. • Pull up on the handlebar to ensure that the steering column is secure. BATTERY CHARGING IMPORTANT! Before first time use, charge the battery for at least 18 hours. Charge the battery for at least 12 hours after each use of the vehicle.
Page 11 • Never allow children to charge the battery. Battery charging must be done by adults only. A child could be injured by the electricity involved in charging the battery. • Never lift or carry the battery by the wires or connector. This can damage the battery and possibly cause a fire resulting in serious injury.
Page 12 • The DC charging outlet is located on • Connect DC pin from provided the back of the quad under the left charger to DC charging outlet. rear wheel fender. Plug DC charger into wall outlet. • The red light on the charger turns green when the battery is fully NOTE: A red light on the charger charged.
Page 13: E How To Use
HOW TO USE WARNING This quad is equipped with a self-resetting built-in thermal fuse. Please see page 15 for more details. SAFETY PRECAUTIONS • Your new battery must be charged for at least 18 hours before you use it in your vehicle for the first time.
Page 14: F Detailed Maintenance And Repair
DETAILED MAINTENANCE AND REPAIR (Turn power “OFF” before conducting any maintenance procedures) HOW TO CHANGE BATTERY • Loosen the screw • Loosen the screw on • Disconnect the control on the back end of the battery retainer and module connector from the the seat.
Page 15 BATTERY CARE AND DISPOSAL Do not store the battery in temperatures above 75° F (23.5° C) or below 14° F (-10°C). THIS SCOOTER CONTAINS SEALED LEAD ACID BATTERIES WHICH MUST BE RECYCLED IN ACCORDANCE TO YOUR LOCAL AND STATE LAWS. PLEASE CAREFULLY READ AND UNDERSTAND THE FOLLOWING DISPOSAL INSTRUCTIONS: Disposal: This product contains sealed lead acid batteries which must be disposed of...
Page 16 MAINTAINING YOUR VEHICLE Occasionally use a lightweight oil to lubricate moving parts such as wheels and the steering linkages. Park the vehicle indoors or cover it with a tarp to protect it from wet weather. Keep the vehicle away from sources of heat, such as stoves and heaters. Plastic parts may melt.
Page 17: G Troubleshooting Guide
Battery Care instructions, your battery may be dead. Replace with a new 6 volt battery. Motor damage Visit the Dynacraft website and replace with a new motor. Vehicle was running Loose wires or connectors Check all wires and connectors. Make sure...
Page 18 Problem Possible Cause Solution Tripped thermal fuse The built-in thermal fuse may “trip” and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe. Once a fuse has “tripped”, release the button on the handle and wait 25 seconds before operating the vehicle again.
Page 19 Problem Possible Cause Solution Vehicle runs sluggishly Undercharged battery Charge the battery. A new battery should have been charged for at least 18 hours before using the vehicle for the first time. After first- time use, recharge the battery for at least 14 hours after each use.
Page 20: H Warranty
Parents that allow their children to ride taking such actions will assume their own risk and the risk of injury to their children, and Dynacraft will not be responsible. THE PURCHASE OF THIS ELECTRIC RIDE-ON TOY WILL CONFIRM THE BUYER’S AGREEMENT THAT DYNACRAFT’S LIABILITY UNDER THIS WARRANTY SHALL BE NO...
Page 21 Having this information is required and helps us handle your call more effectively. DO NOT return this item to the store. STOP Please call Dynacraft for assistance. Dynacraft BSC, Inc. 2014 Printed in China 89 S. Kelly Rd., American Canyon, CA 94503 Call Toll Free 1.800.288-1560...

Dynacraft 6V QUAD Owner's Manual

Table of Contents

Related Manuals for Dynacraft 6V QUAD

Summary of Contents for Dynacraft 6V QUAD

Table of Contents