Table of Contents
Advertisement
Installation and Operating Instructions for Gas Log Heaters
Installation and Operating Instructions for Unvented Zero Clearance Fireplace Heaters
Models UV-EF-MIL (24/30)-N AND UV-EF-MIL (24/30)-P
MODEL UV-EF-MIL 24N/
UV-EF-MIL 30N
For use with Natural Gas
THIS APPLIANCE MAY BE
INSTALLED IN AN
AFTERMARKET,
PERMANENTLY LOCATED,
MANUFACTURED (MOBILE)
HOME, WHERE NOT
PROHIBITED BY LOCAL
CODES.
THIS APPLIANCE IS ONLY FOR
USE WITH THE TYPE OF GAS
INDICATED ON THE RATING
PLATE. THIS APPLIANCE IS
NOT CONVERTIBLE FOR USE
WITH OTHER GASES.
WARNING: If the information in this manual is
not followed exactly, a fire or explosion may
result causing property damage, personal injury,
or loss of life.
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any other
appliance.
WHAT TO DO IF YOU SMELL GAS
*Do not try and light any appliance.
*Do not touch any electrical switch.
*Do not use any phone in your building.
*Immediately call your gas supplier from a
neighbor's phone. Follow your gas supplier's
instructions.
*If you cannot reach your gas supplier, call the
fire department.
*Installation and service must be performed by a
qualified installer, service agency, or the gas
supplier.
The Appalachian Stove
UV36RFP & UV-42RFP
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
UNVENTED GAS APPLIANCE
MODEL UV-EF-MIL 24P
UV-EF-MIL 30P
For use with Propane/LP gas
WARNING: This appliance is for
installation only in a solid fuel
burning masonry or UL 127
factory built fireplace or in a
listed ventless firebox enclosure.
It has been design certified for
these installations. Exception:
DO NOT install this appliance in
a factory built fireplace that
includes instructions stating it
has not been tested or should
not be used with unvented gas
logs.
State or local codes may only
allow operation of this appliance
in a vented configuration. Check
your state or local codes.
US Patent #5,397,233, #5,591,024 and
other Patents Pending
This is an unvented gas-fired heater. It
uses air (oxygen) from the room in
which it is installed. Provisions for
adequate combustion and ventilation
air must be provided. (See page 3 for
additional information).
This unit tested to the Unvented Room Heater
Standard ANS Z21.11.2a-2008
This appliance operates as an unvented domestic room
heater when fitted to a masonry or factory built fireplace with
the flue damper closed or as a decorative appliance when the
flue damper is fully open. It must not be used for any other
purpose and must be fitted in a masonry or factory built
fireplace. If certain requirements are met, then this product
also qualifies under ANS Z21.60b-2004 CGA2.26b-2004
Decorative appliance for installation in Solid-Fuel Burning
Fireplaces.
The Appalachian Stove and Fabricators
Phone: (828)-253-0164
158-L-09-5
•
329 Emma Rd.
Asheville, NC 28806
Fax:(828)-254-7803
Advertisement
Table of Contents
Related Manuals for Appalachian Stove & Fabricators UV-EF-MIL 24-N
Summary of Contents for Appalachian Stove & Fabricators UV-EF-MIL 24-N
- Page 1 The Appalachian Stove Installation and Operating Instructions for Gas Log Heaters Installation and Operating Instructions for Unvented Zero Clearance Fireplace Heaters Models UV-EF-MIL (24/30)-N AND UV-EF-MIL (24/30)-P UV36RFP & UV-42RFP INSTALLER: Leave this manual with the appliance. CONSUMER: Retain this manual for future reference. UNVENTED GAS APPLIANCE MODEL UV-EF-MIL 24P MODEL UV-EF-MIL 24N/...
-
Page 2: Table Of Contents
Contents Important Information............Page 3 Installation.................Page 4 Unpacking................Page 5 Fireplace Preparation............Page 5 Log Positioning..............Page 5 Gas Connection..............Page 4 Gas Pressure Check............Page 4 Installation and Clearances..........Page 4-5 Instructions for Vented Applications........Page 8 Lighting Instructions............Page 6 To Turn Off Gas Appliance..........Page 6 Flame Check..............Page 7 Parts List ................Page 7 Exploded View..............Page 7... -
Page 3: Important Information
are considered part of the unconfined space. Important Information WARNING: If the area in which the heater may be operated does WARNING: ANY CHANGE TO THIS HEATER OR ITS not meet the required volume for indoor combustion air, combustion CONTROLS CAN BE DANGEROUS. and ventilation air shall be provided by one of the methods described IMPORTANT: READ THESE INSTRUCTIONS CAREFULLY in the... -
Page 4: Installation
GAS CONNECTION Pressure Test Point CHECK GAS TYPE. Use only the gas type indicated on the heater’s rating plate. If the gas listed on the plate is not the type of gas supply DO NOT INSTALL. Contact your dealer for proper model. Always use an external regulator for all LP appliances to reduce the supply tank pressure to a maximum 13”WC. -
Page 5: Unpacking
WARNING: Do not Installation (Continued from previous page) The canopy must be installed in accordance with the instructions allow fans to blow directly provided with it. Unpacking into the fireplace. Avoid Noncombustible materials used in this installation such as slate, Open carton and remove any drafts that alter burner marble, tile, et cetera, must be at least ½”... -
Page 6: For Your Safety Read Before Lighting
FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not follow these instructions exactly, a fire or explosion may Result causing property damage, personal injury or loss of life. FROM A NEIGHBOR’S PHONE. FOLLOW This appliance has a pilot which must be YOUR GAS SUPPLIER’S INSTRUCTIONS. -
Page 7: Flame Check
Flame Check A periodic visual check of the flames should be made. The pilot flame should always be present when the appliance is in operation. See figures D and E. In normal operation (at a full rate for approximately 15 minutes), the following flame appearances should be observed: Rear flames: The flames at the rear or at either side of the top log should be very similar, yellow in color, and should extend about three... -
Page 8: Instructions For Vented Applications
Other Important Items: 1. Operator should not adjust the flame by the control knob. (See Important Information and Lighting Instructions.) 2. Extended use may cause air hole on left rear burner tube to clog up. This will make the flames appear taller which could cause a carbon or sooting problem. -
Page 10: Fireplace Screen
Location Centrally locate the unit in the fireplace and deep enough into the firepit to accomplish adequate draft. Ensure that the grate front feet sit inside the front edge of the fireplace. Fireplace screen The fireplace screen must be in place when the appliance is operating, and unless other provisions for combustion air are made, the screen must have an opening(s) for the introduction of combustion air. -
Page 11: Limited Warranty Policy
Two Year Limited Warranty This warranty is limited to fireplaces manufactured and assembled by Appalachian Stove and Fabricators, henceforth “Appalachian.” Warranty Coverage If any component of a fireplace covered under this warranty is returned to Appalachian and found to be defective within two years from the date of purchase, Appalachian will, at its option, repair or replace the defective component at no charge.