Table of Contents
Advertisement
Smoke drawers need to be emptied and all ashes removed.
The top grates can be kept clean with use of wire brush to keep openings clear.
Ceramic tiles should be inspected once a week. They are not porous like lava rock; so most
all drippings will be burned off when drippings hit the tiles, greatly reducing flare-ups.
When cleaning of tiles becomes necessary, service can be performed in the following manner:
1.
Make sure tiles are cool before touching.
2.
Remove from Broiler. Check bottom grate; make sure all openings are free of
debris. Also check below the bottom grate for any built-up grease on burners or
smoke box.
3.
Scrub lightly with wire brush any excessive build-up. It should come off easily
with regular cleaning. If build-up on tiles has become difficult to remove, let the
tiles soak over night in a bucket of water or degreaser solution.
4.
When replacing tiles, be sure to space evenly, allowing ½" or so, in between.
The usual method is 15 tiles per grate (three wide and five deep).
5.
For exterior cleaning, your CHITWOOD SMOKE BROILER may be kept looking
new by using a soft rag and a mild detergent solution. NEVER USE HARSH OR
ABRASIVE CLEANING AGENTS ON THE OUTSIDE OF YOUR BROILER.
SERVICE FREQUENCY
The need for servicing will, to a great extent, be determined by the broiler's usage. The
following chart outlines our suggestion for service intervals:
DAYS PER WEEK
7
5
1 – 4
It is strongly suggested that a trained gas appliance service company examine the Broiler at
least yearly.
REPAIR GUIDELINES
It is not necessary to remove the broiler from its installed position to gain access for normal
servicing.
Contact JADE RANGE or a licensed, trained service person experienced in commercial gas
foodservice equipment for all maintenance and repairs. If it becomes necessary to replace any
gas control device such as a burner valve, pilot, needle valve, etc., the replacement part should
be ordered from the factory ONLY, unless it has been determined that the EXACT part is
available from a local parts supplier.
To contact JADE RANGE, write us at:
P/N 24-137 REV A 7/00
HOURS PER DAY
10 – 24
4 – 6
1 – 3
SERVICE INTERVAL
30 – 60 days
120 days
180 days
Page 8
Advertisement
Table of Contents
