Generac Portable Products 2400 PSI Pressure Washer TABLE OF CONTENTS SAFETY RULES Safety Rules........2-4 This is the safety alert symbol.
Page 3
Generac Portable Products 2400 PSI Pressure Washer WARNING DANGER Fuel and its vapors are extremely flammable and Running engine gives off carbon monoxide, an explosive. odorless, colorless, poison gas. Fire or explosion can cause severe burns or Some chemicals or detergents may be harmful if death.
Page 4
Generac Portable Products 2400 PSI Pressure Washer WARNING CAUTION Excessively high or low operating speeds increase risk Running engines produce heat and hot exhaust of injury and damage to pressure washer. gases.Temperature of muffler and nearby areas can reach or exceed 150°F (65°C).
Generac Portable Products 2400 PSI Pressure Washer KNOW YOUR PRESSURE WASHER Read this owner’s manual and safety rules before operating your pressure washer. Compare the illustrations with your pressure washer to familiarize yourself with the locations of various controls and adjustments.
Generac Portable Products 2400 PSI Pressure Washer ASSEMBLY Perform these tasks to prepare unit: Attach handle to main unit. IMPORTANT: Read entire owner’s manual before you Add oil to engine. attempt to assemble or operate your new pressure washer. Add fuel to fuel tank.
Generac Portable Products 2400 PSI Pressure Washer Add Engine Oil and Fuel Before connecting garden hose to water inlet, inspect inlet screen (Figure 5). Clean screen if it contains • Place pressure washer on a level surface. debris, replace it if damaged. DO NOT RUN PRESSURE WASHER IF SCREEN IS DAMAGED.
Generac Portable Products 2400 PSI Pressure Washer Add proper fuel to fuel tank. Attach nozzle extension to spray gun (Figure 6). Tighten by hand. Check for properly attached hose connections. Figure 6 — Connect Nozzle Extension to Spray Gun Check to make sure that there are no kinks, cuts, or damage to high pressure hose.
Generac Portable Products 2400 PSI Pressure Washer How to Use Spray Tips Pull back on collar, insert new spray tip and release collar. Tug on spray tip to make sure it is securely in place. The quick–connect on the nozzle extension allows you to For most effective cleaning, keep spray tip from 8 to switch between several different spray tips.The spray tips...
Generac Portable Products 2400 PSI Pressure Washer Cleaning and Applying Chemical Pressure Washer Rinsing IMPORTANT: Use soaps designed specifically for After you have applied detergent, scour the surface pressure washers. Household detergents could damage and rinse it clean as follows: the pump.
Generac Portable Products 2400 PSI Pressure Washer Check Gun and Nozzle Extension To remove contaminants from the pump, follow these steps: Examine the hose connection to the spray gun and make Set up pressure washer as described in “Preparing sure it is secure.Test the trigger by pressing it and making Pressure Washer For Use”.
Generac Portable Products 2400 PSI Pressure Washer Reinstall spray tip and in-line filter into nozzle extension. Use a 8mm allen wrench to remove the black pump oil cap between the high pressure outlet and garden hose Reconnect nozzle extension to spray gun.
Generac Portable Products 2400 PSI Pressure Washer PREPARING THE UNIT CAUTION FOR STORAGE You must protect your unit from freezing temperatures. • Failure to do so will permanently damage your pump and Water should not remain in the unit for long periods of render your unit inoperable.
Generac Portable Products 2400 PSI Pressure Washer TROUBLESHOOTING Problem Cause Correction Low pressure spray tip installed. Replace spray tip with high pressure spray tip. Water inlet is blocked. Clear inlet. Inadequate water supply. Provide adequate water flow. Inlet hose is kinked or leaking.
Page 20
LIMITED WARRANTY "Generac Portable Products is a licensed trademark of Briggs & Stratton Power Products. Briggs & Stratton Power Products will repair or replace, free of charge, any part, or parts of the equipment** that are defective in material or workmanship or both.