Introduction - Cautions - CARNES HBGH Installation, Operation And Maintenance Manual

CAUTION!
MANUAL HAS BEEN READ AND UNDERSTOOD. READ AND SAVE THESE INSTRUCTIONS FOR FUTURE USE.
CAUTION
— Perform all basic safety steps before starting unit.
1. Proper mounting of unit cabinet to wall as described in following pages.
2. Make sure voltage and phase supply matches that of Product Identification Label located on left side of unit
cabinet and located on back plane in electrical section.
3. Qualified installers should be used for electrical and plumbing installation, being aware of all current and
corresponding codes.
WARNING: HOT SURFACES
The process of humidification, using an electrode style humidifier, creates steam through the boiling process.
Temperatures of this boiling water and steam can reach 212°F (100°C). This system in turn, creates extremely hot
surfaces (cylinder surface, steam hose, steam pipe, condensate hose/pipe, distribution piping) and hot water or
visible/non-visible steam. Even discharged condensate water can be extremely hot. Contact with these surfaces
water or steam can cause personal injury. To avoid severe burns, always proceed with extreme caution. Before any
service or maintenance is performed, turn off unit, disconnect electrical service and allow humidifier unit to cool down
completely.
WARNING
Before any service or maintenance is performed make sure main power supply is disconnected and safety labeled
(If Carnes unit is set up with a built-in circuit breaker, turn off circuit breaker and additionally turn off main power
supply breaker). Failure to turn off main power supply could result in fire, electrical shock or both, resulting in damage
to property, personal injury or death.
CAUTION
Follow all recommendations, instructions and precautions in this Installation, Operation and Maintenance Manual to
maximize performance, maintain efficiency and to provide a safe operational environment.
INTRODUCTION
DO NOT INSTALL, USE OR OPERATE THIS EQUIPMENT UNTIL THIS
— De-energize Electrical Supply
CAUTIONS
— Water/Steam and Distribution Methods
3