Page 1
User’s manual :WY50QT-58 PREFACE Thanks for your purchasing the motorcycle , and sincerely welcome WY50QT-58 you to be our motorcycle user. To enjoy a more safe and pleasurable driving, firstly please familiarity with the manual must carry on before driving. Your personal safety depends not only on the vigilance and familiar operation skills, but also relates to whether you are familiar with the mechanical performance.
Page 2
The important points to attention The driver and passenger This motorcycle is limited to one driver. Never exceed the max load capacity of motorcycle. For the safety, avoid driving the motorcycle in atrocious weather or cold weather (under -12℃). For the road condition Only drive on the highroad.
Contents …………………………… Driving operation Ⅰ. Notice for safe driving ……………………………… Brake operation ………………………… Rules for safe driving …………………………1 Power off the engine …………………………… Parking operation Payload…………………………………………2 、 Maintenance and service Ⅳ Ⅱ . Various parts name and instruction …………………… Maintenance periodic form …...
Payload Admonition: Only put light goods in sundry boxes or other deposited place. The deposited shouldn’t be overweighted according to the following blank 1: Blank 1 Deposited Weight (kg) Carrier Rear Box The max payload of this motorcycle is 75kg, including the weight of the driver and goods.
Fig2 The broken line(……)indicate the parts unseen in the picture - 4 - Meter and indicator(Fig3) ⑴Fuel meter: Indicate the fuel volume in the fuel tank ⑵Right turning signal : Sparkling when the button turns right ⑶odometer: Record the mileage ⑷Speedometer: show the speed when the vehicle running.
Fuel meter(Fig5) • Fuel meter (1) indicate the fuel volume in the fuel tank. When the needle points to (F), it indicates that the effective residue fuel is 5L. When the needle points at red section, it indicates the remainder of fuel is 1.2L Fig5 Lighting switches (1)...
Fig8 Fig9 Cushion lock( 10) • Insert the key 1 into the key hole 2, then turn the key clockwise to open the cushion. • Press down the cushion until a closedown voice is heard. Pull up the cushion’s rear side to make sure the cushion is locked well, then take out the key.
Page 8
Inspection of Engine Oil Inspect the engine oil level(Fig12、Fig13) 1. Keep the motor steady on the ground, screw up the oil dip rod and clean it, then reinsert and inspect oil. 2. If the oil level reach to down limit sign (2), replenish the standard oil to the level below upper limit sign(3), then insert and screw down the lid back.Check if it’s in good situation Fig 12...
Abrasion mark of the brake ( 16) (1) Reference marks (2) Indicate marks. If fully brake. Change the brake block when reference marks and indicate marks are situated in a straight line. Notice : Once maintenance for brake system is needed, find the nearest professional repair department .
Drive motorcycle: WARNING: • The temperature of exhaust pipe is much high during driving, you will be injured if touching with it carelessly, evn within little time after stopping, the tempreture can also cause injury, so wear trousers to protect your legs against injury. •...
2. Front brake and rear brake work at the same time Notice: When driving down on a cliffy brae, close the accelerograph entirely and use both of the brake . Don’t do brake operation continuously to make it too hot, which will system to make the speed lower affect the performance of brake.
Ⅳ、Maintenance and service Maintenance periodic form This maintenance is based on the odometer , See the Maintenance periodic form as an important guide for your motor’s maintenance on schedule. You should increase the frequency of maintenance if you use the motor at a high speed in a bad situation for a long time.Some main parts of your motor should be inspected by a careerman after a repair for most parts or collision, like Frame, hanger, or turning parts , Repare or replace broken parts to secure your safety.
Blank3 continue speedometer(×1000km) Every month Item page ﹡ Rotate the belt C/1000km I, if need:R ﹡ Gearbox engine oil (Note3) (300km)R Brake system Brake cock ﹡ Head light ﹡ Hanging system ﹡ (Note2) The nuts\bolts Wheel, tyre *﹡ Turning bearing *﹡...
Blank 4 continue Trouble Trouble reason solution phenomenon The octane value of the fuel is too low Change flue Oil path blocked Clean oil path Ignition in wrong time Check wire and change CDI Spark too weak or flameout Check ignition and clear out The vehicle has bad Mixed air too dense or too thin...
Idle speed adjustment (Fig22、Fig23) The carburetor has been adjusted to the best situation before selling out. If it is not well adjusted, ask a professional person to adjust it as the following instruction • Warm up several minutes after engine starts Fig22 •...
(Fig 25) Change gear oil We suggest oil octane number: SAE 80W/90( you can use antifreezing oil in very cold area) Oil capacity Changing capacity : 0.1L • Place the vehicle by the main stand. • Screw out the immersion bolt 1 and oil-drain bolt 2. Fig25 •...
Vehicle Storage STORAGE If the vehicle hasn’t been used for a long time, some steps should be taken to prevent malfunction and damage to the parts. Besides, before the long-time storage, proper repairs should also be done. • Change the engine oil. •...
Ⅶ. Tool set Toolbox(Fig28)is placed in the luggage box under the saddle, and toolbox contains the following tools: Wrench 8x10mm Wrench 12×14mm Screwdriver Hexagonal wrench Fig28 Handle of screwdriver Sleeve wrench 18.5×17mm - 30 - Ⅷ. Main technique Parameter Table5 Item Parameter Item...
- 34 - Owner’s Manual; (ii). Give notice to dealer approved by Wangye USA Co., LLC or other qualified service facility of any and all apparent defects immediately upon discovery, and make the entire motorcycle available at the time for inspection and repair at the dealer’s place of business;...
Page 21
Wangye USA, and the above warranty constitutes your sole remedy and the full liability of Wangye USA. In no event shall Wangye USA be liable for special, incidental or consequential damages howsoever caused, whether by negligence or otherwise resulting directly or indirectly from the use of the Motorcycle, or the Motorcycle’s...