Sony PMW-EX1R camera as a rugged and transportable package. Please read through this entire guide to familiarize yourself with the Gates EX1R housing. The following setup guidelines will explain how to prepare and use your camera and housing so you’ll get the best results from your imaging endeavors.
Page 3
Remove any caps, lenses or leather guide. filters from the camera lens. Slide the focus ring into the forward position. Gates Underwater Products, Inc 13685 Stowe Drive • Poway, CA • 92064 • 858.391.0052 • 800.875.1052 • Fax 858.391.0053 Customer.srvc@GatesHousings.com • www.GatesHousings.com 01/13/10...
Release the latches. Start with the side latches, then the top. To remove the camera tray rotate the latches 90 degrees. Gates Underwater Products, Inc 13685 Stowe Drive • Poway, CA • 92064 • 858.391.0052 • 800.875.1052 • 858.391.0053 Customer.srvc@GatesHousings.com • www.GatesHousings.com 01/13/10...
Page 5
Installing the EX1R Camera into the Housing Secure the camera to the tray with the thumbscrew. Tighten snugly, but do not over tighten. If necessary use a coin to tighten. The camera should be secure to the tray with no play or movement.
Page 6
Slide the camera into the housing. It should do so without obstruction and mate with the alignment collar behind the port opening. Gates Underwater Products, Inc 13685 Stowe Drive • Poway, CA • 92064 • 858.391.0052 • 800.875.1052 • 858.391.0053 Customer.srvc@GatesHousings.com • www.GatesHousings.com 01/13/10...
Page 7
Secure the camera tray by rotating the locking latches 90 degrees to the rear. Push in all controls and verify operation. Gates Underwater Products, Inc 13685 Stowe Drive • Poway, CA • 92064 • 858.391.0052 • 800.875.1052 • Fax 858.391.0053 Customer.srvc@GatesHousings.com • www.GatesHousings.com 01/13/10...
Page 8
The housing shells should mate without obstruction. Close and lock the latches a the same time. Gates Underwater Products, Inc 13685 Stowe Drive • Poway, CA • 92064 • 858.391.0052 • 800.875.1052 • 858.391.0053 Customer.srvc@GatesHousings.com • www.GatesHousings.com 01/13/10...
Page 9
Inspect the parting line is even and closed all the way around the housing. Gates Underwater Products, Inc 13685 Stowe Drive • Poway, CA • 92064 • 858.391.0052 • 800.875.1052 • Fax 858.391.0053 Customer.srvc@GatesHousings.com • www.GatesHousings.com 01/13/10...
Slide the foot onto the dovetail and secure with the knurled brass nut. Foot slides from back to front. Gates Underwater Products, Inc 13685 Stowe Drive • Poway, CA • 92064 • 858.391.0052 • 800.875.1052 • 858.391.0053 Customer.srvc@GatesHousings.com • www.GatesHousings.com 01/13/10...
Page 11
Buoyancy and Trim The EX1R housing utilizes trim weights on the inside and bottom of the housing for adjusting buoyancy and trim to your liking. In the basic configuration the housing uses 4.7 lb / 2. kg of trim weight, divided into one 11 oz weight (secured to the inside rear shell, just to the right of the viewfinder), six 8 oz and four 4 oz weights (secured to the bottom of the housing).
Page 12
The controls are designed to operate properly in this position. Flip Macro Zoom Record / Standby Flip Filter Gates Underwater Products, Inc 13685 Stowe Drive • Poway, CA • 92064 • 858.391.0052 • 800.875.1052 • 858.391.0053 Customer.srvc@GatesHousings.com • www.GatesHousings.com 01/13/10...
Page 13
ND Filter A/M Focus WB Presets / Gain WB Set Roller / Select Power On/Off Picture Profile Menu Gates Underwater Products, Inc 13685 Stowe Drive • Poway, CA • 92064 • 858.391.0052 • 800.875.1052 • Fax 858.391.0053 Customer.srvc@GatesHousings.com • www.GatesHousings.com 01/13/10...
Position the Lockout Collar here to use the Manual Iris control. Gates Underwater Products, Inc 13685 Stowe Drive • Poway, CA • 92064 • 858.391.0052 • 800.875.1052 • 858.391.0053 Customer.srvc@GatesHousings.com • www.GatesHousings.com 01/13/10...
Page 15
: When not in use position the control with the pointer up at the top of travel. This will avoid inadvertent camera contact. Gates Underwater Products, Inc 13685 Stowe Drive • Poway, CA • 92064 • 858.391.0052 • 800.875.1052 • Fax 858.391.0053 Customer.srvc@GatesHousings.com •...
Similar to Picture Profile, rotating the control pin away from the hole serves as a lockout feature against activation. Gates Underwater Products, Inc 13685 Stowe Drive • Poway, CA • 92064 • 858.391.0052 • 800.875.1052 • 858.391.0053 Customer.srvc@GatesHousings.com •...
See the section ‘Using the SP44 Dome Port’ for additional information using diopters with the SP44 Dome Port. Flip Filter Flip Diopter Gates Underwater Products, Inc 13685 Stowe Drive • Poway, CA • 92064 • 858.391.0052 • 800.875.1052 • Fax 858.391.0053 Customer.srvc@GatesHousings.com • www.GatesHousings.com 01/13/10...
Page 18
Use of other diopters The EX1R housing can accommodate the use of diopters affixed to the camera body in conjunction with the FP44 flat port. Depending on the manufacturer the diopters may be stacked. Note that the color correction filter cannot be used in this configuration.
Page 19
• +1 Diopter: To gain 100% image sharpness when using the SP44 dome port, the addition of a + 1 diopter is recommended. The flip diopter is standard on every EX1R housing and can be employed at any time.
Changing Ports housing. Gates offers several ports for your EX1R housing, which attach with a bayonet- style mount. Port changes are easy and straightforward: Removal. You will see alignment dots on the housing and on the port. When aligned, the port is fully engaged and ready for underwater use.
Gates offers approved cleaning solutions and lint free cloths as accessory items. Use of these materials will not void your warranty. Gates Underwater Products, Inc 13685 Stowe Drive • Poway, CA • 92064 • 858.391.0052 • 800.875.1052 • Fax 858.391.0053 Customer.srvc@GatesHousings.com •...
Page 22
The EX1R cameras require the use of the XLR audio adapter. Plug this into the CH-1 connector on the camera and then plug the submersible microphone into this adapter. Be sure to fully engage the connectors.
Page 23
Optional Water Alarm If your EX1R housing includes the optional water alarm, there are three alarm conditions to watch for: Condition Siren New battery Bright intense blink while siren Ascending tones played 4 (when inserted) plays. times. Water intrusion Bright intense blink.
Page 24
This section covers mounting of the optional monitor to the EX1R housing and connection to the camera. Refer to the Setup, Use and Care guide for the monitor to be used with the EX1R housing for other details. The Gates EM43 monitor is shown here for reference.
Page 25
The 6 pin HD connector is shown. Other monitors may use single pin SD connector. Gates Underwater Products, Inc 13685 Stowe Drive • Poway, CA • 92064 • 858.391.0052 • 800.875.1052 • Fax 858.391.0053 Customer.srvc@GatesHousings.com • www.GatesHousings.com 01/13/10...
Your housing comes ready to accept different lighting systems depending on your requirements. If you purchased lighting systems from Gates you will find a separate document to guide you through installation to your Gates EX1R housing. You can also find it on Gates web site at www.GatesHousings.com.