Page 1 Digital Video Camcorder PV-DV100 PV-DV200 Mini PV-DV400 PV-DV600 AC Adaptor PV-DAC10 Model: PV-DAC10 Models: PV-DV100/ PV-DV200 PV-DV400/ PV-DV600 ITEM SPECIFICATION 1 2 3 4 ITEM SPECIFICATION 1 2 3 4 Digital Video Camera: 7.2 V DC (Battery) 10.2 mm (0.4 inch) Electronic Viewfinder –...
Page 2: Table Of Contents
Use Marks shown in the chart below to distinguish the different models included in this Service Manual. MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 NOT USED TABLE OF CONTENTS SAFETY PRECAUTIONS ..........
Page 3: Safety Precautions
SAFETY PRECAUTIONS GENERAL GUIDELINES Hot-Check Circuit 1. IMPORTANT SAFETY NOTICE There are special components used in this equipment AC VOLTMETER which are important for safety. These parts are marked by in the Schematic Diagrams, Circuit Board Layout, Exploded Views and Replacement Parts List. It is essential that these critical parts should be replaced with manufacturer's specified parts to prevent X-RADIATION, shock, fire, or other hazards.
Page 4: X-Radiation (Model: A, B)
X-RADIATION (MODEL: A, WARNING : 1. The potential source of X-Radiation in EVF sets is the High Voltage section and the picture tube. 2. When using a picture tube test jig for service, ensure that jig is capable of handling 10 kV without causing X-Radiation. NOTE : It is important to use an accurate periodically calibrated high voltage meter.
Page 5: Service Notes
SERVICE NOTES EXTENSION CABLES FOR SERVICE POSITION Using the following Extension Cables (No.1 ~ No.4), place the unit as shown for check and service as shown in Fig. 1-1. PART NUMBER PART NAME CONNECTION LSUA0028 32Pin Extension Cable FP301 on Main C.B.A. ~ CCD F.P.C. on Lens Unit LSUA0020 20Pin Extension Cable FP701 on Main C.B.A.
Page 6 Note: marked parts are supplied as service fixtures. CCD F.P.C. Eject Switch Lens Unit Top F.P.C. Top Operation Unit Zoom Switch Unit Lens F.P.C. Slide EVF Unit (Model: A, B) Main (LSUA0020) C.B.A. Color EVF Unit FP701 (Model: C, D) (LSUA0028) FP301 Power C.B.A.
Page 7 INTERCONNECTION OF EXTENSION CABLES Note: marked parts are supplied as service fixtures. Top F.P.C. Connector Cable Eject Switch Zoom Switch Unit Lens Unit (LSUA0028) CCD F.P.C. EVF Unit (Model: A, B) Lens F.P.C. Color EVF Unit (LSUA0020) (Model: C, D) Jack C.B.A.
Page 8 SIMPLIFIED FAULT FINDING DATA (SELF-DIAGNOSTIC SYSTEM) When following conditions occur, the Power LED will flash according to the condition. Power LED CONDITION POWER LED FLASHING TIMING & POWER OFF TIMING After 1 minute flash, power will be turned off. T = 2.56 sec T-Reel Lock 0.16 sec After 1 minute flash, power will be turned off.
Page 9 SHORT JIG C.B.A. METHOD FOR LOADING/UNLOADING OF CAUTION: MECHANISM Be sure to attach the Short JIG C.B.A. to protect the microcontrollers (IC6001 and IC302) after servicing. CAUTION: (1) Open the LCD Unit. If loading does not start after DC Power Supply is applied, (2) Remove 2 Screws (A).
Page 10 HOW TO REMOVE A JAMMED TAPE Manual Method (1) Remove the Cabinet Parts. Refer to "CABINET SECTION" Electrical Method in DISASSEMBLY/ASSEMBLY PROCEDURES. CAUTION: (2) Remove the Head Amp C.B.A. from Mechanism. Refer to If loading does not start after DC Power Supply is applied, "MECHANISM SECTION"...
Page 11: Eeprom Data
EEPROM DATA 3 How to initialize the EEPROM IC When the EEPROM IC or Main C.B.A. is replaced, be sure CAUTION: to write the initial data to EEPROM IC. And adjust the Be sure to save the EEPROM data using PC-EVR camcorder.
Page 12 HOW TO USE THE DVC HEAD CLEANING TAPE / LSUQ0003 Please use the cleaning tape as described below. Note: This cleaning tape has a total playback time of 45 minutes. Once used, it is not reusable. 1. Confirm the picture. 2.
Page 13: Special Note
PCB with glue. So carefully twist the MODEL MARK component when removing it so as not to break or damage any fail under the component. PV-DV100 b. Take care not to break the copper foil on the printed PV-DV200 board. PV-DV400...
Page 14: Ic, Transistor And Chip Part Information
IC, TRANSISTOR AND CHIP PART INFORMATION GENERAL C.B.A./ASS'Y PARTS 2SD1819, 2SD1819A, 2SC4081T106R, MSB1218A, 2SA1576T106R, 2SB1218A, UN5114 (R1=10K, R2=47K), 2SB1218AI, 2SB1585, 2SB970, AD80008BUS, AN2109NFHQ, ADM3202ARU, AK4516AVF-E1, AK6480AF-E1, UN5115 (R1=10K, R2=OPEN), 2SA1037K146R, 2SB709A, AN2516S-EV1, AN8021NS-E1, BA6289F-E2, AN2536FHQ, AN2545FHQ, UN9111J (R1=10K, R2=10K), 2SC3931, 2SK1580, 2SD1119, BA10324AFVE1, BR9040FV-DE2, AN3742FHN-EB, AN3732FHQ, UN9115J (R1=10K),...
Page 15: Disassembly/Assembly Procedures
DISASSEMBLY/ASSEMBLY PROCEDURES CABINET SECTION Disassembly Flowchart This flow chart indicates the disassembly steps of the cabinet parts and the P.C.Boards in order to gain access to item (s) to be serviced. When reassembling, perform the step (s) in the reverse order. Bend, route and dress the wires as they were originally. COLOR EVF PORTION SIDE CASE L UNIT PORTION FRONT CASE UNIT PORTION...
Page 16 Main Parts Portion (S-1) STEP Fig. /LOC. PART REMOVE Front Case Unit 3(S-1), 2(S-2), FP4801 (S-2) Left Cover 2(S-3), 2(S-4) View A 5(S-5), (S-6), Open Side Case R Unit FP7, FP302 Analog C.B.A. B3501 (S-7), FP1, FP2, FP3, FP4, FP5, FP6, FP8, FP9, FP301, Main C.B.A.
Page 17 FP302 (L-1) raise Power C.B.A. (S-5) (S-6) (S-5) Slot A B3501 Rubber of Analog C.B.A. IR Filter Knob (Model: D) (Model: C, D) Lens Unit (S-8) (S-5) Side Case Slot of IR Filter Plate R Unit (Model: C, D) (S-5) Reassembly Note: Reassembly Note: When installing the Lens Unit, install so that the Rubber of...
Page 18 FRONT CASE UNIT PORTION Cassette Cover Unit Slot B Lock Lever Slot B Garage Slide STEP Fig. Boss A Unit PART REMOVE /LOC. Pin B Cylinder F.P.C. Hooking Portion 2(S-1) Front C.B.A. Shoe (S-2) Pin B 3(S-3), Lens Ring, Boss A Hood Screw Hood Piece 2(L-1)
Page 19 SIDE CASE R UNIT PORTION (S-2) Right Cover Unit Speaker Unit STEP Fig. PART REMOVE /LOC. Open (S-2) LCD Case Unit 2(S-1), (L-1), Unsolder (L-2) Right Cover Unit 2(S-2), (S-3), 2(L-2) (S-4) Slot Speaker Unit (S-4) Boss Toripod Frame (S-5) Toripod Frame (S-3) (S-5)
Page 20 LCD PORTION (LCD Case B Unit) LCD Case B Slots LCD Unit STEP Fig. PART REMOVE /LOC. LCD Shield (S-3) Case LCD Case A Unit 2(S-1), 6(L-1) 2(S-2) LCD Shield Case raise FP8001 FP8001 LCD Shaft Unit (S-2) (S-3) LCD Case B 2(S-3) LCD Shaft Unit LCD C.B.A.
Page 21 (Lead Light Panel Unit) LCD Panel Unit (L-3) Lead Light Panel Unit LCD Sheet (L-2) Unit LCD C.B.A. (L-3) (L-2) LCD Lamp Unit LCD Panel (L-2) Holder Reflect Sheet (L-2) LCD Lamp Open Unsolder Unit FP8003 Lead Light Panel View A Unsolder Note: Reassembly Note:...
Page 22 LENS PORTION A Reassembly Note: 1. Installation of the Optical Filter (1) Install the Optical Filter in the Lens Unit correctly. Note: STEP Fig. (Model: A, B) PART /LOC. REMOVE Be sure to install the Optical Filter with the thinnest layer of the Optical Filter facing toward the Lens Unit.
Page 23 LENS PORTION B Focus (S-3) Motor Unit STEP Zoom Motor Unit Fig. PART REMOVE /LOC. Unsolder Holder Portion A Slots of Holder Lens Piece Unit 3(S-1) Lens Insulator ----- (S-4) View A IR Filter Plate 2(S-2) Unsolder Focus Motor Unit 2(S-3), Unsolder Reassembly Note: When installing the Zoom Motor Unit, install so that the...
Page 24 SIDE CASE L UNIT PORTION Open Jack Cover STEP Fig. PART REMOVE /LOC. Hand Strap IN/OUT Knob (Model: D) (L-1) Jack Ass’y (S-1) Strap Angle (S-2) Jack Ass'y Jack Cover Hand Strap IN/OUT Knob 2(L-1) IN/OUT Switch Jack F.P.C. FP3701, FP3751 Push (Model: D) View A...
Page 25 Zoom Switch Unit (S-6) (S-6) Jack C.B.A. Jack Angle Eject Plate FP3751 Portion A S-Jack C.B.A. (S-4) Tab of Switch (Model: B,C,D) (S-3) Eject Knob Piece FP3701 (S-5) hole Portion B Battery Eject Piece Slot of MMC Exchange Knob (Model: B, C, D) Jack F.P.C.
Page 26 TOP CASE UNIT PORTION Top Connector Cable (L-2) STEP Fig. PART REMOVE /LOC. Boss Top Case Unit (S-1), (S-2), (L-1) (L-3) Color EVF Unit ----- or EVF Unit Connector Top Angle (S-3), (L-2) Top Connector Cable Connector Top Operation Unit (L-3) Top Operation Unit Top Angle...
Page 27 EVF UNIT PORTION (Model: A, B) Eye Cap Unit (L-1) Turn STEP Fig. PART REMOVE /LOC. EVF Case Unit Eye Cap Unit 2(L-1) (L-1) Eye Sight RIng EVF Angle Unit (S-1), 2(S-2) EVF F.P.C. Holder 2(L-2) EVF Case A Unit 2(S-3) View A Note:...
Page 28 Deflection Yoke EVF F.P.C. View A P902 FP801 C.B.A. EVF Angle Unit Socket Unit (S-1) (S-2) Deflection Yoke Anode Pin (L-2) Lead (YELLOW) (L-2) EVF F.P.C. Holder Fig. D28 Lead (BLUE) EVF Case A Unit View "A" 5.35 mm 1.35 mm EVF ESD Angle Unit Deflection Yoke...
Page 29 COLOR EVF UNIT PORTION (Model: C, Push Eye Cap Unit STEP Fig. PART REMOVE /LOC. Eye Cap Unit 2(S-1) LCD EVF Case A 2(S-2) EVF Panel Unit FP901 (S-1) EVF F.P.C. Holder 2(L-1) View A Reassembly Notes: EVF Fixing Angle 3(S-3), 2(L-2) When installing the Eye Cap Unit, tighten 2 Screws (S-1) while pushing as indicated by the arrow.
Page 30 (S-3) EVF Protect A EVF LCD Holder EVF Fixing Angle LCD Panel EVF Rubber (L-2) LCD EVF Case Protect (L-2) Plate LED Diffusion (S-3) Plate (L-4) LED Lens Protect B Color EVF B (L-4) C.B.A. FP902 EVF F.P.C. (L-3) P901 Color EVF A LCD EVF Angle Unit C.B.A.
Page 31: Mechanism Section
MECHANISM SECTION Disassembly Method This procedure starts with the condition that the cabinet parts and Main C.B.A. have been removed. When reassembling, perform the step(s) in the reverse order. Perform all disassembly/reassembly and alignments procedures in STOP Position except disassembly/reassembly and alignment procedures which have the special notes.
Page 32 Inner Parts Location Note: BOX indicates alignment (Gear alignment or Tape Path Alignment with L.I.S.T.A.) required when a part is replaced. TOP VIEW Head Amp C.B.A. Cylinder Unit T Post Unit Cylinder Base Unit Capstan Unit Loading Motor Unit S Post Unit Dumper Unit Rail Reduction Gear B...
Page 33 BOTTOM VIEW Mechanism F.P.C. Unit T Arm Unit S Arm Unit Timing Belt T4 Drive Arm Mode Switch Drive Pulley Main Plate Unit MIC Switch DEW Sensor Fig. DM1-2 2-19...
Page 34 STOP Position Confirmation Check the following points to confirm that the Mechanism is in STOP Position from the top side. S Post Unit shoud be positioned T Post Unit shoud be positioned T4 Height Plate in end of the guide slots in end of the guide slots Through Hole S Post Unit...
Page 35 Perform all disassembly/reassembly and alignments procedures in STOP Position except disassembly/reassembly and alignment procedures which have the special notes. Head Amp C.B.A. FP5001 1 Head Amp C.B.A. Cylinder Unit (on Head Amp C.B.A.) (S-1) (S-1) (L-1) Fig. DM3 Disassembly Notes: 1.
Page 36 Guide Piece L, Guide Piece R, Garage Unit 4 Garage Unit Pin B Slot B shaft of Garage Unit Push Pin A Pin B Slot B Hole A Slide Pin A Gear of Dumper Unit Hole A Lock Lever (S-2) (L-2) (S-2) (L-2)
Page 37 Cylinder Unit 5 Cylinder Unit Bosses (S-3) Fig. DM5 Disassembly Notes: Reassembly Notes: 1. Use extreme care when removing or replacing the Cylinder 1. Installation of Cylinder Unit Unit. Do not touch the Video Heads during servicing. 1) Install the Cylinder Unit so that 2 Holes on the Cylinder Use extreme care to handle the Cylinder Unit.
Page 38 Dumper Unit 6 Dumper Unit (S-4) Fig. DM6 2-24...
Page 39: Dew Sensor
DEW Sensor View A CAUTION: DO NOT touch 0 mm ~ 2 mm the element part 7 DEW Sensor Sheet 3 mm ~ 5 mm 4 mm ~ 7 mm DEW Sensor Screwdriver chassis View A DEW Sensor Leads Unsolder Unsolder Portion A Fig.
Page 40 Mechanism F.P.C. Unit 8 Mechanism F.P.C. Unit Solder (Loading Motor x2) (S-5) double-sided adhesive tape Sensor Holder R Sensor Holder L Sensor Sensor View A View B double-sided double-sided adhesive tape adhesive tape Slide Solder (Mode Switch x4) Lock Lever Unit Cassette Down Switch Solder...
Page 41 Reduction Gear B Gear of Note: Loading Motor This hole on Reduction Unit Gear is not used to align. 9 Reduction Gear B (C-1) Gear of Mode Switch Fig. DM9 2-27...
Page 42 Mechanism Cover Unit (L-4) 10 Mechanism Cover Unit Projection on S Brake Drive Lever See Reassembly Notes Slide Hole on Gear Lever (C-2) (S-6) Projection on S Brake Drive Lever Hole on Gear of Mechanism Cover Unit Turn (reverse side of Mechanism Cover Unit) Mechanism F.P.C.
Page 43 Idler Arm Unit, Center Gear Slot Pin on chassis Portion A Slot 11 Idler Arm Unit Hole on Idler Arm Unit Small Gear of Center Gear Gear of Idler Arm Unit Side View 12 Center Gear Hole on Idler Arm Unit Fig.
Page 44 Tension Arm Unit 13 Tension Arm Unit Hooking Portion B (C-3) Cam Follower Pin Cam Follower Pin Slot Spring Projection on Sensor F.P.C. approx. 1 mm Hooking Portion A Projection on Sensor F.P.C. S Connection Gear Unit S Reel Table Band of Tension Arm Unit groove of S Reel Table Fig.
Page 45 S Reel Table, T Reel Table (W-1) (W-1) 14 S Reel 15 T Reel Table Table (C-4) (C-4) Gear of T Brake Unit Fig. DM13 Reassembly Notes: 1. Installation of S Reel Table and T Reel Table 1) Install 2 Washers (W-1) onto each Pins. 2) Confirm that the Gear of T Reel Table engages with the Gear of T Brake Unit.
Page 46 S Connection Gear Unit Projection on Sensor F.P.C. Projection on Spring Hooking Portion Sensor F.P.C. Slide 16 S Connection Gear Unit Fig. DM14 Disassembly Notes: Reassembly Notes: 1. When removing the S Connection Gear Unit, slide it as 1. After installing the S Connection Gear Unit, confirm that the indicated by the arrow.
Page 47 T Break Unit 17 T Brake Unit (S-7) Plate (L-5) Fig. DM15 Disassembly Notes: Reassembly Notes: 1. When removing the T Brake Unit, remove Screw (S-7) and 1. When installing the T Brake Unit, DO NOT apply pressure the Plate. Then, remove the T Brake Unit while releasing to T Brake Unit Plate.
Page 48 T4 Height Plate, Pinch Arm Unit 19 Pinch Arm Unit 18 T4 Height Plate (S-8) Spring Hooking Portion A Slide Hooking Portion B T4 Drive Arm See Reassemly Notes. Hooking Portion A Hole (Through Hole) Spring Slot Hooking Portion B Pin A Hole A Fig.
Page 49 Rail S Post T Post (L-7) Slide Slide (S-9) 20 Rail (L-6) Fig. DM17 Disassembly Notes: Reassembly Notes: 1. Before removing the Rail, slide the S & T Posts by rotating 1. Installation of Rail the Mode Switch clockwise. 1) Set 4 Locking Tabs (L-7), and then push down the Rail 2.
Page 50 Cylinder Base Unit S Post T Post (S-11a) (S-11b) (S-11c) (S-10) Slide Slide 21 Cylinder Base Unit chassis holes Bosses Fig. DM18 Disassembly Notes: Reassembly Notes: 1. Slide the S & T Posts as indicated by the arrow. 1. Before installing the Cylinder Base Unit, confirm that the S &...
Page 51 S & T Arm Unit, S & T Post Unit Slot on S Arm Unit Slot on T Arm Unit T Post Unit S Post Unit Projection Projection hole on T Arm Unit hole on S Arm Unit 25 T Post Unit 24 S Post Unit 22 S Arm Unit T Arm Unit...
Page 52 Loading Motor Unit 26 Loading Motor Unit (S-11) chassis holes Bosses Fig. DM20 2-38...
Page 53 Sensor F.P.C. 27 Sensor F.P.C. Slide (S-13) Slide (S-13) holes holes Pins Pins Fig. DM21 Disassembly Notes: Reassembly Notes: 1. When removing the Sensor F.P.C., slide it as indicated by 1. Installation of Sensor F.P.C. the arrow. 1) Install the Sensor F.P.C. so that Pins on chassis are in holes on the Sensor F.P.C.
Page 54 Tension Drive Arm, S Brake Drive Lever Intermediate Gear Mode Switch outside groove 28 Tension Drive inside groove Main Plate Unit Cam Gear Cam Follower Pin 29 S Brake Drive Lever Cam Follower Pin Fig. DM22 Reassembly Notes: 1. Installation of S Brake Drive Lever, Tension Drive Arm 1) Confirm that the Intermediate Gear, Main Plate Unit, Mode Switch, and Cam Gear are in proper position.
Page 55 Cam Gear Mode Switch hole (Through Hole) Intermediate Gear half circle Line Up mark Circle indent B Circle Indent Main Plate Unit Circle indent A Line Up hole (Through Hole) 30 Cam Gear Fig. DM23 Reassembly Notes: 1. Alignment of Intermediate Gear, Main Plate Unit, Mode Switch, Cam Gear 1) Before installing the Cam Gear, align the hole on Intermediate Gear with hole on chassis (Through Hole),...
Page 56 Pinch Drive Arm, Intermediate Gear Pin on Main Plate Unit 32 Intermediate Gear Slot Pin on Main Plate Unit 31 Pinch Drive Arm Fig. DM24 2-42...
Page 57: Mode Switch
Mode Switch (S-14) 33 Mode Switch Boss chassis hole Fig. DM25 Reassembly Notes: 1. When installing the Mode Switch, install the Mode Switch without tottering 2-43...
Page 58 MIC Switch 34 MIC Switch chassis holes Bosses (S-15) Fig. DM26 2-44...
Page 59 Main Plate Unit Guide Pin on chassis 35 Main Plate Unit Pin on T4 Drive Arm Slots Guide Pin on chassis Fig. DM27 Reassembly Notes: 1. Installation of Main Plate Unit 1) Install the Main Plate Unit so that Pin on T4 Drive Arm and Guide Pin on chassis are in Slots on Main Plate Unit correctly.
Page 60 T4 Drive Arm 36 T4 Drive Arm Fig. DM28 2-46...
Page 61 Drive Pulley "a" "d" "b" "c" Timing Belt groove of Drive Pulley 37 Drive Pulley Timing Belt "d" Fig. DM29 Reassembly Notes: 1. DO NOT let the Timing Belt twist. Be careful so as not to let the Timing Belt touch the greased portion.
Page 62 Capstan Unit, Timing Belt, Capstan Adjust Spring Pin A Boss groove of Capstan Unit 39 Timing Belt Pin B 40 Capstan Adjust Spring (S-17) 38 Capstan Unit Pin B hole (S-16) Pin A Fig. DM30 Reassembly Notes: 1. When installing the Capstan Unit, hook the Timing Belt to the groove of Capstan Unit.
Page 63 Lock Lever Unit, Lock Pick Lever Pin A Hooking Portion Pin B Lock Lever Spring hole slot 42 Lock Pick Lever slot slot (C-5) Guide Pin on chassis 41 Lock Lever Unit slot Fig. DM31 Reassembly Notes: 1. Installation of Lock Lever Unit 1) Install the Lock Lever Unit so that Pin A and Pin B are inserted to slots on Lock Lever Unit and Guide Pin on chassis is inserted to slot on Lock Lever Unit.
Page 64: Adjustment Procedures
ADJUSTMENT PROCEDURES SERVICE FIXTURES & TOOLS 49% Transmission Tape VFK1217 Color Bar Standard VFM3010EHS Linear Alignment VFM3000EHSM Tape Tape (Keeping condition: Keep at 18 C ~ 28 C) (Keeping condition: Keep at 18 C ~ 28 C) Extension Cable 32P LSUA0028 DVC Head Cleaning LSUQ0003 Reel FG Adjustment...
Page 65 Light Box VFKS002Y Infinity Lens VFK1164TCM02 Grease Grease and AC Adaptor (with Focus Chart) LSUQ0002 VFKS0081 49mm Ring Color Conversion Color Conversion Filter (C14) Filter (C10) VFK1164TAR49 VFK1164TFCT2 AC Adaptor for C-Movie can be used. (DC +6V) Either plug can be used. (AC Adaptor is not supplied) not supplied ATF I/F (AC 100V)
Page 66: Electrical Adjustment
ELECTRICAL ADJUSTMENT INTRODUCTION Most of Electrical adjustments can be adjusted using Personal Computer with PC-EVR Adjustment Software. The Set-up of PC-EVR Adjustment and the VR (Variable Resister) Adjustment Procedure are described in this section. For ADJUSTMENT ITEM (section) for the model you are servicing, please refer to the following table. MODEL ADJUSTMENT SYTEM ADJUSTMENT ITEM (Section)
Page 67: Initial Guideline
INITIAL GUIDELINE The table below shows which adjustments are necessary according to the unit parts and individual parts to be replaced. Make sure to perform these adjustments shown below as necessary. Replacement Parts Adjustment Item Camera Hall Amp Adjustment Iris PWM Adjustment Zoom tracking Adjustment A/D Input Adjustment White Balance Adjustment...
Page 68: Test Equipment
TEST EQUIPMENT How to make the Reel FG Adjustment Cassette To do all of these electrical adjustments, the following equip- ments are required. 1) Purchase a DV cassette tape locally. 1. Dual-Trace Oscilloscope 2) Remove 4 Screws on the DV cassette tape. Voltage Range: 0.001 to 50 V/Div.
Page 69 PREPARATION 4. Connect the Camera Connecting Cable to B3 on the unit. 1. Open the LCD panel. LCD Panel Fig. E3-1 Camera Connectiong Cable 2. Remove Screws (A), the Right Cover Unit and the Short JIG C.B.A. from the unit. Fig.
Page 70 <Computer Assisted Adjustment System> Personal Computer Connect to RS232C Connector Inter Link Cable SW115 (M103 EXMOD1) SW114 SW110 (M103 VPP) (RS232C SEL) P101 SW103 P108 (RECI) SW109 (IRIS) Operation Panel SW111 (5 V SEL) Camera Connecting Cable P102 SW108 (BST TEST) Interface Board SW113 (POWER ON)
Page 71: Main Menu
SET UP OF PC-EVR ADJUSTMENT HOW TO USE MAIN MENU PROGRAM Main Menu 1. Turn on the Personal Computer. ® Windows 95 will be set up automatically. Select a Sub Menu to check, adjust the unit etc. by pressing 2. Restart it in MS-DOS mode. (UP/DOWN) Key in Main Menu.
Page 72 VR ADJUSTMENT Centering Adjustment Purpose: MONOCHROME EVF SECTION To set the optimum picture position on the EVF picture. Note: Symptom of Misadjustment: Camcorder need NOT to be powered off and on after each The EVF picture will be shifted. adjustment procedure. Test Point : ---------- Preparation...
Page 73 Brightness Adjustment Purpose: To set the optimum EVF brightness level. Symptom of Misadjustment: The EVF picture will be too white or black. Test Point : ---------- Adjustment : VR903 (EVF C.B.A.) Specification: Natural Gradation INPUT : Color Bar Chart Mode : CAMERA Equipment : Viewfinder...
Page 74 TEST POINTS AND CONTROL LOCATION EVF C.B.A. (A, B) VR901 VR903 BRIGHTNESS VERTICAL SIZE VR902 FOCUS (Foil Side) Color EVF A C.B.A. (C, D) TP905 TP901 TP903 TP902 (Foil Side) LCD C.B.A. TP8001 TP8003 TP8002 TP8007 TP8006 (Component Side) Test Point Information Test Point with no Test Pin.
Page 75: Tape Path Alignment With L.i.s.t.a
2. Requirements Here are the requirements for running LISTA. a. Panasonic Personal Computer b. Satellite Box (AC 100 V) d. ATF I/F (AC 100 V) c. MIC Reader (AC 100 V) "Set to PK5"...
Page 76 g. Interface Board SW106(REC-I) Set SW104(BST_TEST) to [NORMAL]. Set SW106(REC_I) to [OFF]. SW104(BST-TEST) CAG Cable(36PIN) MIC Cable(36PIN) MCS Cable(14PIN) ATF Cable(14PIN) Post Height Adjustment Fixture(VFK1278) h. Linear Alignment Tape(VFM3000EHSM) (Keeping condition: Keep at 18 °C ~ 28 °C) k. Oscilloscope DC Power Supply GB-IB cable GB-IB cable is from A/D board in PC.
Page 77 3. Connections a) Interconnection of LISTA system. CAG Cable Camera Connecting Satellite Cable GP-IB Cable MCS Cable Interface Personal board Computer RS-232C Cable MIC Cable Reader Camcorder ATF Cable Caution: AC power source of following equipments are 100V AC. Use 100V AC power only for these equipments, otherwise they may be damaged.
Page 78 c) Connect the MIC Cable of Interface Board and the MIC Reader. MIC Reader MIC Cable Interface Board d) Connect the MIC Reader and Personal Computer with the RS-232C Cable. 1) Connect the RS-232C Cable to the MIC Reader. MIC Reader RS-232C Cable 2) Connect the RS-232C Cable to the Personal Computer.
Page 79 e) Connect the MCS Cable of Interface Board and Satellite Box. Satellite Box MCS Cable Interface Board f) Connect the Satellite Box and Personal Computer with the GP-IB Cable. Satellite Box Personal Computer GP-IB Cable 3-16...
Page 80 g) Connect the CAG Cable of Interface Board and Personal Computer. 1) Connect the CAG Cable to the Personal Computer. Personal Computer CAG Cable Interface Board h) Connect the ATF Cable of Interface Board and ATF I/F. "Set to PK5" ATF I/F ATF Cable Interface Board...
Page 81 4. Getting Start 1. Confirm SW setting of the Interface Board as follows. Set SW104(BST_TEST) to [NORMAL]. Set SW106(REC_I) to [OFF]. 2. Turn on the Personal Computer. 3. Main menu appears. 4. Start up the PC-EVR Adjustment Program refer to “SET UP OF PC-EVR ADJUSTMENT PROGRAM” and select “Enter TEST MODE”...
Page 82 5. Explanation for “AVE.10” display (AVE.10 display) Adjustment Linear Data Linear Curve Indicator AVE : µm LINEAR= GAIN : 50 [F1] AVE. [F2] AVE. (b)* (c)* [F3] AVERAGE [F4] SENSI. (d)* (e)* [F5] PGMM ADJ [F6] MIC READ (f)* (g)* [F7] MIC ZERO (h)* [F8] MIC DATA...
Page 83 6. Envelope Adjustment Note: This adjustment is required when the indicator color becomes red in “step 10” of “4. Getting Start.” If it becomes blue, this adjustment need not to be performed. Purpose: To make sure that the tape path is well stabilized. Symptom of Misadjustment: If the tape travels with instability, it may damage the tape.
Page 84 Make this part flat (square) as possible. S1 POST T1 POST Oscilloscope Oscilloscope Before Adj. After Adj. 6) After adjustment of step 4) and 5), confirm the indicator color in the Confirmation Area once again to confirm if further adjustment is necessary or not. If it is blue, the adjustment is completed (No further adjustment is necessary).
Page 85: Schematic Diagrams
Use the interconnection schematic diagram to find the Comparison chart of models & marks connection between associated connectors. MODEL MARK Example: PV-DV100 The connections between C.B.A.s are shown below. PV-DV200 PV-DV400 PV-DV600 Ref. No. of the connection parts such as lead cable, flexible cable which is supplied as a replacement parts.
Page 86: Main I (Overall) Schematic Diagram
MAIN I (OVERALL) SCHEMATIC DIAGRAM NOTE: COMPARISON CHART OF MODELS & MARKS FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 Not Used TO POWER B,C,D R9001 C.B.A. B1001...
Page 87: Main Ii (Control) Schematic Diagram
MAIN II (CONTROL) SCHEMATIC DIAGRAM NOTE: COMPARISON CHART OF MODELS & MARKS FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 PV-DV400 UNREG PV-DV600 REG+2V(D) Not Used EVF ON(H) POWER ON(L)
Page 88: Main Iii (Camera Signal Process) Schematic Diagram (A)
MAIN III (CAMERA SIGNAL PROCESS) SCHEMATIC DIAGRAM (A) NOTE: COMPARISON CHART OF MODELS & MARKS FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 REC VIDEO SIGNAL PB VIDEO SIGNAL PV-DV400 PV-DV600 Not Used C310...
Page 89: Main Iii (Camera Signal Process) Schematic Diagram (B, C, D)
MAIN III (CAMERA SIGNAL PROCESS) SCHEMATIC DIAGRAM (B, C, D) NOTE: COMPARISON CHART OF MODELS & MARKS FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 Not Used REC VIDEO SIGNAL PB VIDEO SIGNAL R415 100 C359 0.1...
Page 90: Main Iv (Video I) Schematic Diagram
MAIN IV (VIDEO I) SCHEMATIC DIAGRAM NOTE: COMPARISON CHART OF MODELS & MARKS FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 REC VIDEO SIGNAL PB VIDEO SIGNAL Not Used PB V-SYNC...
Page 91 NOTE: COMPARISON CHART OF MODELS & MARKS FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 REC VIDEO SIGNAL PB VIDEO SIGNAL REC AUDIO SIGNAL PB AUDIO SIGNAL PV-DV400 PV-DV600 RF+3V...
Page 92: Main Vi (Audio) Schematic Diagram
COMPARISON CHART MAIN VI (AUDIO) SCHEMATIC DIAGRAM FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, OF MODELS & MARKS REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 Not Used REC AUDIO SIGNAL PB AUDIO SIGNAL R4301...
Page 93: Main Vii (Drive) Schematic Diagram
NOTE: COMPARISON CHART MAIN VII (DRIVE) SCHEMATIC DIAGRAM FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, OF MODELS & MARKS REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 Not Used R2018 VH + REG +3V (D)
Page 94 COMPARISON CHART FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, OF MODELS & MARKS REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 Not Used IC2001 CAPSTAN/CYLINDER MOTOR DRIVE CONTROL IC-DETAIL BLOCK DIAGRAM, TB6534F HALL AMP MATRIX...
Page 95: Main Viii (Sub Power) Schematic Diagram
NOTE: COMPARISON CHART MAIN VIII (SUB POWER) SCHEMATIC DIAGRAM FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, OF MODELS & MARKS REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 Not Used R1211 EVF+12V Q1201 2SD1819A R1212...
Page 96: Jack Schematic Diagram
COMPARISON CHART JACK SCHEMATIC DIAGRAM FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, OF MODELS & MARKS REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 REC VIDEO SUGNAL PB VIDEO SUGNAL REC AUDIO SUGNAL PB AUDIO SUGNAL...
Page 97: Head Amp Schematic Diagram
COMPARISON CHART HEAD AMP SCHEMATIC DIAGRAM FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, OF MODELS & MARKS REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 Not Used REC VIDEO SIGNAL PB VIDEO SIGNAL REC AUDIO SIGNAL...
Page 98: Analog Schematic Diagram (D)
NOTE: COMPARISON CHART ANALOG SCHEMATIC DIAGRAM (D) FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, OF MODELS & MARKS REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 PV-DV400 REC VIDEO SIGNAL PV-DV600 C3561 X3501 Not Used R3583 C3564...
Page 99: Power Schematic Diagram
CAUTION: FOR CONTINUED PROTECTION AGAINST FIRE HAZARD, CAUTION: FOR CONTINUED PROTECTION AGAINST FIRE HAZARD, WHEN REPLACING ANY OF THESE COMPONENTS, PV-DV100 REPLACE ONLY WITH THE SAME TYPE 1A 32V FUSE. REPLACE ONLY WITH THE SAME TYPE 2A 32V FUSE. USE ONLY THE SPECIFIED PARTS.
Page 100: Microphone Unit/Front Schematic Diagram
NOTE: COMPARISON CHART MICROPHONE UNIT/FRONT SCHEMATIC DIAGRAM FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, OF MODELS & MARKS REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 Not Used REC AUDIO SIGNAL ECM UNIT Q4809 2SD1819A...
Page 101: Ccd Schematic Diagram
NOTE: COMPARISON CHART CCD SCHEMATIC DIAGRAM FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, OF MODELS & MARKS REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 Not Used REC VIDEO SIGNAL C617 R611 R615 IC602 MN37290FT...
Page 102: Evf Schematic Diagram (A, B)
EVF SCHEMATIC DIAGRAM (A, B) COMPONENTS IDENTIFIED BY THE SIGN HAVE REFER TO BEGINNING OF SCHEMATIC SECTION. SPECIAL CHARACTERISTICS IMPORTANT FOR SAFETY. MODEL MARK WHEN REPLACING ANY OF THESE COMPONENTS, PV-DV100 USE ONLY THE SPECIFIED PARTS. PV-DV200 PV-DV400 PV-DV600 Not Used VIDEO SIGNAL T901...
Page 103: Color Evf A/B Schematic Diagram (C, D)
NOTE: COMPARISON CHART COLOR EVF A/B SCHEMATIC DIAGRAM (C, D) FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, OF MODELS & MARKS REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 VIDEO SIGNAL Not Used R937 Q901...
Page 104: Lcd Schematic Diagram
NOTE: COMPARISON CHART LCD SCHEMATIC DIAGRAM FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, OF MODELS & MARKS REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 Not Used Q8009 2SB709A SWITCHING VIDEO SIGNAL LCD ON-ON +7.5V...
Page 105: Interconnection Schematic Diagram
NOTE: COMPARISON CHART INTERCONNECTION SCHEMATIC DIAGRAM FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, OF MODELS & MARKS REFER TO BEGINNING OF SCHEMATIC SECTION. MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 JACK C.B.A. MAIN C.B.A. CCD C.B.A. LCD SHAFT UNIT LCD C.B.A.
Page 106: Signal Waveform
0.5 V WF11 WF16 WF20 WF25 WF26 COMPARISON CHART OF MODELS & MARKS MODEL MARK PV-DV100 PV-DV200 PV-DV400 Pin 6 of IC3204 Pin 27 of IC601 Pin 48 of IC8001 Pin 48 of IC901 Pin 13 of IC3502 PV-DV600 20 µs1 20 µs1...
Page 107 PIN NO. PIN NO. PIN NO. PIN NO. PIN NO. PIN NO. PIN NO. PIN NO. COMPARISON CHART IC301 Q301 OF MODELS & MARKS MODEL MARK PV-DV100 Q701 PV-DV200 PV-DV400 PV-DV600 IC313(B,C,D) Q702 IC303 15.2 Q703 IC305 IC701 15.2 IC310(B,C,D)
Page 108 PIN NO. PIN NO. COMPARISON CHART IC3002 Q1206 TP3012 OF MODELS & MARKS -15.0 -15.0 TP3013 -15.0 -15.0 TP3014 MODEL MARK -14.3 -14.3 TP3015 PV-DV100 Q1207 TP3017 PV-DV200 TP3018 PV-DV400 -14.8 -14.8 TP3201 PV-DV600 -0.1 -0.3 TP3202 Q3001 TP3203 TP3204...
Page 109 NOTE: MAIN C.B.A. (SYSTEM CONTROL/SERVO SECTION) FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, REFER TO BEGINNING OF SCHEMATIC SECTION. MODE PLAY STOP MODE PLAY STOP MODE PLAY STOP MODE PLAY STOP MODE PLAY STOP MODE PLAY STOP MODE PLAY STOP PIN NO.
Page 110 TP13 IC4801 IC901 IC901 TP902 TP14 TP15 TP16 COMPARISON CHART OF MODELS & MARKS TP17 Q3501 TP18 MODEL MARK IC3600 IC6501 PV-DV100 PV-DV200 PV-DV400 Q3502 PV-DV600 -4.9 -9.7 Q3503 IC3601 Q4801 IC3502 Q3504 12.0 -9.3 Q4802 (C,D) Q901 Q3505 Q1010...
Page 111 COMPARISON CHART NOTE: IC8001 Q8002 IC602 OF MODELS & MARKS FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, REFER TO BEGINNING OF SCHEMATIC SECTION. -6.7 MODEL MARK -0.1 PV-DV100 Q8003 PV-DV200 PV-DV400 PV-DV600 -1.6 11.5 Q8004 15.0 Q8005 -15.2 -14.3...
Page 112: Circuit Board Layout
FOR PROPER PARTS CONTENT FOR THE MODEL YOU ARE SERVICING, MODEL MARK PLEASE REFER TO THE SCHEMATIC DIAGRAM AND PARTS LIST. SIDE THAT MAKE EASY TO SIGHT THE COMPONENT LAYOUT. PV-DV100 NOTE: PV-DV200 CIRCUIT BOARD LAYOUT INCLUDES COMPONENTS WHICH ARE NOT USED. PV-DV400...
Page 113: Main C.b.a. (A)
COMPARISON CHART OF MODELS & MARKS MODEL MARK NOTE: PV-DV100 FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, PV-DV200 REFER TO BEGINNING OF SCHEMATIC SECTION. PV-DV400 PV-DV600 (COMPONENT SIDE) LEADLESS COMPONENT PARTS LOCATION GUIDE MAIN C.B.A. (A) C330 C3235 A-4...
Page 114 FOR PROPER PARTS CONTENT FOR THE MODEL YOU ARE SERVICING, MODEL MARK PLEASE REFER TO THE SCHEMATIC DIAGRAM AND PARTS LIST. SIDE THAT MAKE EASY TO SIGHT THE COMPONENT LAYOUT. PV-DV100 NOTE: PV-DV200 CIRCUIT BOARD LAYOUT INCLUDES COMPONENTS WHICH ARE NOT USED. PV-DV400...
Page 115 COMPARISON CHART OF MODELS & MARKS MODEL MARK NOTE: PV-DV100 FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, PV-DV200 REFER TO BEGINNING OF SCHEMATIC SECTION. PV-DV400 PV-DV600 (FOIL SIDE) LEADLESS COMPONENT PARTS LOCATION GUIDE MAIN C.B.A. (A) C301 C2020 B-1...
Page 116 FOR PROPER PARTS CONTENT FOR THE MODEL YOU ARE SERVICING, MODEL MARK PLEASE REFER TO THE SCHEMATIC DIAGRAM AND PARTS LIST. SIDE THAT MAKE EASY TO SIGHT THE COMPONENT LAYOUT. PV-DV100 NOTE: PV-DV200 CIRCUIT BOARD LAYOUT INCLUDES COMPONENTS WHICH ARE NOT USED. PV-DV400...
Page 117: Main C.b.a. (B, C, D)
COMPARISON CHART OF MODELS & MARKS MODEL MARK NOTE: FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, PV-DV100 REFER TO BEGINNING OF SCHEMATIC SECTION. PV-DV200 PV-DV400 PV-DV600 (COMPONENT SIDE) LEADLESS COMPONENT PARTS LOCATION GUIDE MAIN C.B.A. (B, C, D) C301...
Page 118 FOR COMPONENT SIDE AND FOIL SIDE. LAYOUT PATETRNS ARE SINGLE PATTERN FOR EACH MODEL MARK PLEASE REFER TO THE SCHEMATIC DIAGRAM AND PARTS LIST. SIDE THAT MAKE EASY TO SIGHT THE COMPONENT LAYOUT. PV-DV100 NOTE: PV-DV200 CIRCUIT BOARD LAYOUT INCLUDES COMPONENTS WHICH ARE NOT USED. PV-DV400...
Page 119 COMPARISON CHART OF MODELS & MARKS MODEL MARK NOTE: FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, PV-DV100 REFER TO BEGINNING OF SCHEMATIC SECTION. PV-DV200 PV-DV400 PV-DV600 (FOIL SIDE) LEADLESS COMPONENT PARTS LOCATION GUIDE MAIN C.B.A. (B, C, D) C302 B-3...
Page 120: S-Jack C.b.a
R5008 COMPARISON CHART CONNECTOR C5004 L5001 R5009 OF MODELS & MARKS FP5001 C5005 L5002 R5010 MODEL MARK TEST POINT C5006 L5003 R5011 PV-DV100 TP5001 C5007 R5001 R5012 TP5002 C5008 R5002 R5013 PV-DV200 TP5003 C5009 R5003 R5014 PV-DV400 TP5004 C5010 R5004...
Page 121: Jack C.b.a
R4801 R4818 R4837 R4883 Q4804 C4806 C4823 R4802 R4819 R4838 R4884 MODEL MARK Q4805 C4807 C4824 R4803 R4820 R4839 R6502 PV-DV100 Q4806 C4808 C4825 R4804 R4821 R4840 PV-DV200 Q4807 C4809 C4826 R4805 R4823 R4841 PV-DV400 Q4808 C4810 C4827 R4806 R4824...
Page 122: Power C.b.a
PLEASE REFER TO THE SCHEMATIC DIAGRAM AND PARTS LIST. FOR COMPONENT SIDE AND FOIL SIDE. LAYOUT PATETRNS ARE SINGLE PATTERN FOR EACH REFER TO BEGINNING OF SCHEMATIC SECTION. PV-DV100 NOTE: SIDE THAT MAKE EASY TO SIGHT THE COMPONENT LAYOUT. PV-DV200 CIRCUIT BOARD LAYOUT INCLUDES COMPONENTS WHICH ARE NOT USED.
Page 123: Analog C.b.a. (D)
FOR PROPER PARTS CONTENT FOR THE MODEL YOU ARE SERVICING, FOR COMPONENT SIDE AND FOIL SIDE. LAYOUT PATETRNS ARE SINGLE PATTERN FOR EACH SIDE THAT MAKE EASY TO SIGHT THE COMPONENT LAYOUT. PLEASE REFER TO THE SCHEMATIC DIAGRAM AND PARTS LIST. PV-DV100 TARNSISTOR PV-DV200 NOTE:...
Page 124 REFER TO BEGINNING OF SCHEMATIC SECTION. FOR PROPER PARTS CONTENT FOR THE MODEL YOU ARE SERVICING, MODEL MARK PLEASE REFER TO THE SCHEMATIC DIAGRAM AND PARTS LIST. PV-DV100 NOTE: IMPORTANT SAFETY NOTICE: PV-DV200 CIRCUIT BOARD LAYOUT INCLUDES COMPONENTS WHICH ARE NOT USED.
Page 125: Ccd C.b.a
(DUAL PATTERNS) (DUAL PATTERNS) LSJB8011 COLOR EVF A COMPARISON CHART OF MODELS & MARKS IC901 MODEL MARK LEADLESS COMPONENT PARTS LOCATION GIODE CONNECTOR COLOR EVF A C.B.A. FP901 PV-DV100 C901 C911 C921 L902 R910 R926 R937 FP902 PV-DV200 C902 C912 C922...
Page 126: Lcd C.b.a
REFER TO BEGINNING OF SCHEMATIC SECTION. FOR PROPER PARTS CONTENT FOR THE MODEL YOU ARE SERVICING, MODEL MARK PLEASE REFER TO THE SCHEMATIC DIAGRAM AND PARTS LIST. PV-DV100 NOTE: PV-DV200 CIRCUIT BOARD LAYOUT INCLUDES COMPONENTS WHICH ARE NOT USED. PV-DV400...
Page 127: Block Diagrams Ccd Drive Block Diagram
BLOCK DIAGRAMS CCD DRIVE BLOCK DIAGRAM REC VIDEO(CAMERA) SIGNAL CCD C.B.A. MAIN C.B.A. IC602 (CCD) IC601 (CAMERA SIGNAL PROCESS/ DAC) Q602 Q601 R608 R610 C610 DOUBLE FP601 FP301 IMAGE GAMMA APERTURE (TO IC303(7)) TO VIDEO SIGNAL PROCESS I SAMPLING BUFFER BUFFER CONTROL CONTROL...
Page 128: Video Signal Process I Block Diagram
VIDEO SIGNAL PROCESS I BLOCK DIAGRAM (PV-DV100) REC VIDEO SIGNAL PB VIDEO SIGNAL MAIN C.B.A. IC303 (CAMERA DIGITAL SIGNAL PROCESS) IC3001 (VIDEO DIGITAL SIGNAL PROCESS) FCK(13.5MHz) CAMERA CLOCK 2(13.5MHz) PB-C DATA (4 BIT) PB-Y DATA (8 BIT) (8 BIT) (8 BIT)
Page 129 VIDEO SIGNAL PROCESS I BLOCK DIAGRAM (PV-DV200/PV-DV400/PV-DV600) REC VIDEO SIGNAL PB VIDEO SIGNAL MAIN C.B.A. IC303 (CAMERA DIGITAL SIGNAL PROCESS) IC3001 (VIDEO DIGITAL SIGNAL PROCESS) FCK(13.5MHz) CAMERA CLOCK 2(13.5MHz) PB-C DATA (4 BIT) PB-Y DATA (8 BIT) (8 BIT) (8 BIT) REC/PB-C DATA (8 BIT) DIGITAL (FROM IC605 (2))
Page 130: Video Signal Process Ii Block Diagram
VIDEO SIGNAL PROCESS II BLOCK DIAGRAM REC VIDEO SIGNAL PB VIDEO SIGNAL REC AUDIO SIGNAL PB AUDIO SIGNAL HEAD AMP C.B.A. MAIN C.B.A. IC3201 (SHUFFLING/FORMATTING) IC5001 (HEAD AMP) EQ SERIAL CLOCK FROM/TO EQ SERIAL DATA SYSTEM CONTROL SHUFFLING BLOCK DIAGRAM FP501 EQ STROBE PULSE CONTROL...
Page 131: Analog Video I/F Block Diagram
ANALOG VIDEO I/F BLOCK DIAGRAM REC VIDEO SIGNAL PB VIDEO SIGNAL JACK C.B.A. MAIN C.B.A. ANALOG C.B.A. IC3502 (Y/C SEPARATION) IC3503 (V/H SYNC SEPARATION) Q3506,3509 B3501 JK3701 (TO IC3001 (180)) Q3502 Q3503,3504 Q3505 BUFFER Q3512 FP3701 B3501 V/H SYNC VIDEO BUFFER BUFFER Q3510,3511...
Page 132: Audio Signal Process Block Diagram
AUDIO SIGNAL PROCESS BLOCK DIAGRAM REC AUDIO SIGNAL PB AUDIO SIGNAL MAIN C.B.A. FRONT C.B.A. IC4001(AUDIO I/F) ECM UNIT IC4801 (EQUALIZER AMP) Q4811 Q4805,4806 Q4801 FP10 FP4801 FJ4801 BUFFER BUFFER (TO IC3201 (89)) CONVERTER AUDIO DATA 0 Q4812 Q4807,4808 Q4803 FP10 FP4801 FJ4801...
Page 133: System Control Block Diagram
SYSTEM CONTROL BLOCK DIAGRAM (PV-DV100) MAIN C.B.A. TOP OPERATION UNIT IC6007 (DAC) IC6001 (VCR MICROCONTROLLER) POWER OUTPUT CHROMA GAIN CONTROL POWER LED ON (L) MENU TO EVF Q6001 OSD-R WIDE CONTROL BLOCK DIAGRAM MENU SW TO ANALOG Q6008 REC/PAUSE INPUT LUMA GAIN CONTROL...
Page 134 SYSTEM CONTROL BLOCK DIAGRAM (PV-DV200/PV-DV400/PV-DV600) MAIN C.B.A. TOP OPERATION UNIT IC6007 (DAC) IC6001 (VCR MICROCONTROLLER) POWER OUTPUT CHROMA GAIN CONTROL POWER LED ON (L) MENU Q6001 TO EVF WIDE CONTROL OSD-R BLOCK DIAGRAM MENU SW TO ANALOG REC/PAUSE INPUT LUMA GAIN CONTROL DAC CS (H) Q6008 VIDEO I/F...
Page 135: Servo Block Diagram
SERVO BLOCK DIAGRAM CYLINDER UNIT MAIN C.B.A. IC2003 (CYLINDER MOTOR DRIVE) DRIVE IC3201 (SHUFFLING / FORMATTING) 5, 6 CYLINDER MOTOR DRIVE 3, 4 DRIVE 7, 8 IC2001 (CYLINDER/CAPSTAN MOTOR DRIVE) CYL DRIVE CLOCK DRIVE CYLINDER CYLINDER CYL PG LEAD PG HEAD FG HEAD LOGIC VOLTAGE...
Page 136: Af Block Diagram
AF BLOCK DIAGRAM ( PV-DV100) MAIN C.B.A. FRONT C.B.A. MF VR UNIT IC302 (CAMERA MICROCONTROLLER) FJ4802 V-REF (H) FP10 FP4801 FJ4802 MANUAL FOCUS 1 (FROM IC605 (8)) HALL AMP GAIN CONTROL MF VR FP10 FP4801 FJ4802 FROM MANUAL FOCUS 0...
Page 137 AF BLOCK DIAGRAM ( PV-DV200/PV-DV400/PV-DV600) MAIN C.B.A. FRONT C.B.A. MF VR UNIT IC302 (CAMERA MICROCONTROLLER) FJ4802 V-REF (H) FP10 FP4801 FJ4802 MANUAL FOCUS 1 (FROM IC605 (8)) HALL AMP GAIN CONTROL MF VR FP10 FP4801 FJ4802 FROM MANUAL FOCUS 0 (FROM IC605 (9)) CCD DRIVE IRIS CONTROL...
Page 138: Lcd Block Diagram
LCD BLOCK DIAGRAM VIDEO SIGNAL (REC & PB) MAIN C.B.A. LCD SHAFT UNIT LCD C.B.A. Q8009 +12V LCD PANEL UNIT FP8002 Q8008 IC8001 (LCD RGB SIGNAL PROCESS) Q8010 FP8002 +7.5V Q8007 FP8002 D8001 REVERSE/NORMAL Q8011 FP8002 LCD REVERSE (L) Q8006 44 VCC(+3V) STH2 FP8002...
Page 139: Evf Block Diagram
EVF BLOCK DIAGRAM VIDEO SIGNAL (REC & PB) EVF C.B.A. L902 C913 P902 P902 IC901 (EVF DRIVE) Q903 FROM VIDEO SIGNAL FP901 PROCESS I BLOCK LUMA CHARACTER H.DEFLECTION DIAGRAM COIL T901 FP901 V/H SYNC V SYNC FROM SYSTEM CONTROL EVF-OSD V-OSC BLOCK DIAGRAM SEPARATION...
Page 140: Color Evf Block Diagram
COLOR EVF BLOCK DIAGRAM VIDEO SIGNAL (REC & PB) COLOR EVF A C.B.A. EVF LCD PANEL UNIT Q901 L901 IC901 (EVF RGB SIGNAL PROCESS) D901 Q902 VCC(+3V) VCC(+3V) FP902 L902 VCC(+3V) HCK2 FP902 L904 +12V 18 VCC(+12V) VCK2 FP902 LCD DRIVE HCK1 FP902 OUTPUT...
Page 141: Power Supply Block Diagram
POWER SUPPLY BLOCK DIAGRAM POWER C.B.A. F1004 1A/32V LCD UNREG F1003 1A/32V UNREG (TO IC6001(94)) BATTERY (T) (TO IC6001(95)) BATTERY (D) L1010 AF +5V L1009 CAM +5V (A) L1007 REG +5V (A) L1011 HA +5V L1013 SW +5V (A) L1012 SP +5V JK1001 L1008...
Page 142: Troubleshooting Hints
TROUBLESHOOTING HINTS 1. No Picture or abnormal picture when playbacking Check if the PB picture is output to Check IC3201, IC3001, and DV connector. surrounding parts on Main C.B.A. Check ENV signal at Pin 13 of FP5 No Signal on Main C.B.A. Abnormal ENV Signal (Use Pin 3 of FP5 on Main C.B.A.
Page 143 2. No Recording Check if the Recording picture Perform troubleshooting for appears on the LCD Monitor or EVF "No Camera Recording." Monitor. Check HSE signal at Pin 12 of FP5 Check IC3201 and surrounding parts on Main C.B.A. on Main C.B.A. Check IC5001 and surrounding Replace if necessary.
Page 144 3. No Recording (Input: A/V Input) Check if A/V SELECT SW is set Set A/V SELECT SW to IN. to IN. Check if the Recording picture Perform troubleshooting for appears on the LCD Monitor or EVF "No Recording." Monitor. Check Q3502, Q3503, Q3504, Replace if necessary.
Page 145 4. No Picture in the Color EVF Monitor Check if the voltage is +5V at Pin 1 Check D951 (Backlight) on Color of P901 on Color EVF A C.B.A. EVF B C.B.A. Check L903 and C921 on Color EVF A C.B.A. Check voltage at Pin 18, 25, 43, and Check L904, L901, and surrounding 44 of IC901 on Color EVF A C.B.A.
Page 146 5. No Picture in the LCD Monitor Check if the voltage is +5V +/- 0.5V Check if the voltage is +7.8V +/-1V Replace F1004 on Power Supply at TP8109 on LCD C.B.A. at Pin 18 and 19 of FP8001 on LCD C.B.A.
Page 147 6. No Camera Recording Can read IC301 and IC303 data Check IC301 serial data and power Check IC301 and power line on using PC-EVR software ? line. Main C.B.A. Replace IC302 on Main C.B.A. Check signal at Pin 7 of IC303 on Check signal at Pin 7 of IC602 on Check Lens Unit, IC703, and Main C.B.A.
Page 148 7. Can not use Multi Media Card Does the LCD Monitor or EVF Use a new MultiMediaCard and Multi Media Card is defective. Monitor indicate the Error Code ? check MultiMediaCard operation. Use a new MultiMediaCard. Check IC302, IC303, IC304 and surrounding parts on Main C.B.A.
Page 149 8. No Power Check F1001, F1002, F1003, and F1004. Replace if necessary. Connect TP3901 on Main C.B.A. to GND to let the unit turn on. Check if the voltage is approx. +7.8V at Q1001 Replace Q1001 on Power Supply C.B.A. collector on Power Supply C.B.A.
Page 150: Exploded Views
Note: Parts with no Ref. No. in "EXPLODED VIEW" are not supplied. MAIN PARTS SECTION And some Ref. No. will be skipped. Be sure to make your orders of replacement parts according to the parts list. COMPARISON CHART OF MODELS & MARKS MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600...
Page 151: Side Case L Section
SPECIAL CHARACTERISTICS IMPORTANT FOR SAFETY. COMPARISON CHART WHEN REPLACING ANY OF THESE COMPONENTS, OF MODELS & MARKS USE ONLY THE SPECIFIED PARTS. MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 (B,C,D) WARNING WARNING : DANGER OF EXPLOSION IF BATTERY IS INCORRECTLY REPLACED.
Page 152: Top Case And Evf Section (A, B)
IMPORTANT SAFETY NOTICE: COMPONENTS IDENTIFIED BY THE SIGN HAVE (Model: A, B) SPECIAL CHARACTERISTICS IMPORTANT FOR SAFETY. WHEN REPLACING ANY OF THESE COMPONENTS, USE ONLY THE SPECIFIED PARTS. COMPARISON CHART OF MODELS & MARKS MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600...
Page 153: Top Case And Color Evf Section (C, D)
IMPORTANT SAFETY NOTICE: COMPONENTS IDENTIFIED BY THE SIGN HAVE (Model: C, D) SPECIAL CHARACTERISTICS IMPORTANT FOR SAFETY. WHEN REPLACING ANY OF THESE COMPONENTS, USE ONLY THE SPECIFIED PARTS. COMPARISON CHART OF MODELS & MARKS MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600...
Page 154: Lens Section
Grease Available from Factory LSUQ0002 OF MODELS & MARKS MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600 NOTE 1 : Make sure to install the Optical Filter(Ref. No. 22) in the Lens Unit correctly. Refer to "Lens Portion A" of "Disassembly/Assembly Procedures"...
Page 155: Side Case R And Lcd Section
SIDE CASE R AND LCD SECTION IMPORTANT SAFETY NOTICE: COMPONENTS IDENTIFIED BY THE SIGN HAVE SPECIAL CHARACTERISTICS IMPORTANT FOR SAFETY. WHEN REPLACING ANY OF THESE COMPONENTS, USE ONLY THE SPECIFIED PARTS. COMPARISON CHART OF MODELS & MARKS MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600...
Page 156: Front Case Section
FRONT CASE SECTION IMPORTANT SAFETY NOTICE: COMPONENTS IDENTIFIED BY THE SIGN HAVE SPECIAL CHARACTERISTICS IMPORTANT FOR SAFETY. WHEN REPLACING ANY OF THESE COMPONENTS, USE ONLY THE SPECIFIED PARTS.
Page 157: Mechanism Section
LUBRICATION POINTS MECHANISM SECTION When the marked parts are replaced, apply the recommended lubricants or adhesive for better maintenance of the unit. Mark Kind of Lubricant Availability Part Number Purchase from Local Supplier - - - - - - - - Grease Available from Factory VFKS0081...
Page 158: Packing Parts And Accessories Section
ACCESSORIES SECTION SPECIAL CHARACTERISTICS IMPORTANT FOR SAFETY. WHEN REPLACING ANY OF THESE COMPONENTS, COMPARISON CHART USE ONLY THE SPECIFIED PARTS. OF MODELS & MARKS MODEL MARK PV-DV100 (B,C,D) PV-DV200 not supplied PV-DV400 PV-DV600 DANGER DANGER : To Prevent possible burn hazard, disconnect this unit and allow lamp to cool before replacing.
Page 159: Replacement Parts Lists
INCORRECTLY REPLACED. REPLACE ONLY WITH 3. Cut Washers (Ref No. 473, 475, and 477) are not THE SAME OR EQUIVALENT TYPE. reusable. If removed, install a new one. COMPARISON CHART OF MODELS & MARKS MODEL MARK PV-DV100 PV-DV200 PV-DV400 PV-DV600...
Page 160: Mechanical Replacement Parts List
MECHANICAL REPLACEMENT Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks PARTS LIST =QM=========================bvb=`^m=rkfq ============ipvhMOTS========E=^I_=F===========================P <The complete Exploded Views are shown in this manual.> ============ipvhMNUS========E=`Ia=F===========================P =QN=========================bsc=`^pb=_I^_p=obpfk EXPLODED VIEWS ============iphjMPTS========E=^I_=F========================!=P MAIN PARTS SECTION ============iphjMOSQ========E=`Ia=F========================!=P =QO=========================arpq=`lsbo ============ipaiMMVQ========E=^I_=F===========================P =QP=========================bsc=^kdib=rkfq ============ipu^MOVV========E=^I_=F===========================P ============ipu^MPOM========E=`Ia=F===========================P...
Page 161 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks =VQ=========================i`a=`^pb=^=rkfqI^_p=obpfk OOS=========sbjpMPPR========il^afkd=jlqlo=rkfq================T ============ipvhMOUV========E=^=F==========================!=R OOT=========su^pQQOR========p=`lkkb`qflk=db^o=rkfq============T ============ipvhMOVM========E=_=F==========================!=R OOU=========suipNNNS========qbkpflk=^oj=rkfq==================T ============ipvhMOVN========E=`=F==========================!=R OOV=========suipNMUP========q=_o^hb=rkfq======================T ============ipvhMOVO========E=a=F==========================!=R OPM=========suapMONR========jb`e^kfpj=`lsbo=rkfq==============T =VR=========================i`a=`^pb=_I^_p=obpfk OPN=========suipNMUQ========faibo=^oj=rkfq====================T ============iphjMOQQ========E=^I_=F========================!=R OPO=========ipuoMMMO========p=obbi=q^_ib======================T ============iphjMOQR========E=`Ia=F========================!=R OPP=========ipuoMMMP========q=obbi=q^_ib======================T =VS=========ipuvMNSP========i`a=pe^cq=rkfq====================R OPQ=========suipNNOP========mfk`e=^oj=rkfq====================T =VT=========ipp`MPMM========i`a=pefbia=`^pbIpqbbi=============R OPR=========su^pQQNU========d^o^db=rkfq=======================T =VU=========================ifnrfa=`ovpq^i=afpmi^v=m^kbi OPS=========bvepTTtNU=======abt=pbkplo========================T ============================rkfq OPT=========sjctMMQR========pebbqIkvilkHo^vlk=================T ============ipuvMNOS========E=^I_=F===========================R OQN=========suapMONN========`vifkabo=_^pb=rkfq================T ============suvtMOMN========E=`Ia=F===========================R OQO=========suapMONM========p=mlpq=rkfq=======================T =VV=========ipuvMNRQ========ib^a=ifdeq=m^kbi=rkfq=============R...
Page 162 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks SERVICE FIXTURE AND TOOLS ============schNONT=========QVB=qo^kpjfppflk=q^mb=============================sba ============scjPMNMbep======`lilo=_^o=pq^ka^oa=q^mb===========================sba ============scjPMMMbepj=====ifkb^o=^ifdkjbkq=q^mb=============================sba ============iprnMMMP========as`=eb^a=`ib^kfkd=q^mb ============JJJJJJJJ========obbi=cd=^agrpqjbkq=`^ppbqqb=======Eklq=prmmifbaF ============ipr^MMOU========buqbkpflk=`^_ib=POm ============ipr^MMOM========buqbkpflk=`^_ib=OMm===============EO=éÅëF ============ipr^MMNV========buqbkpflk=`^_ib=Um ============ipr^MMOV========buqbkpflk=`^_ib=QMm ============srspMMNR========buqbkpflk=`^_ib=OUm ============ipr^MMNT========buqbkpflk=`^_ib=NUm ============ipr^MMNS========buqbkpflk=`^_ib=NMm ============ipr^MMNU========buqbkpflk=`^_ib=OQm ============ipg_UMNT========qlm=cKmK`K ============================wllj=ptfq`e=rkfq ============ipbnMRSM========E=^=F ============ipbnMRSN========E=_I`Ia=F ============================qlm=lmbo^qflk=rkfq ============ipbnMRSO========E=^I_=F ============ipbnMRSP========E=`Ia=F ============================bsc=rkfq ============ipvhMOTV========E=^I_=F ============================`lilo=bsc=rkfq ============ipvhMPMU========E=`Ia=F ============iprnMMMO========dob^pb...
Page 163: Electrical Replacement Parts List
ELECTRICAL REPLACEMENT Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks PARTS LIST f`PMMN======qPtOPu_=========f`I=ildf`=sfabl=afdfq^i=pfdk^i====bKpKaK ============================mol`bpp (E1, E2, E3, E4, E5, E6, E7, E8, E9, E10, E11, E12, E13) f`PMMO======_eTMUShs========f`I=ifkb^o=s`l f`PMMP======kgjORPUsqbN=====f`I=ifkb^o=lrqmrq=aofsbo Ref. No. Part No. Part Name Remarks f`POMN======jkOjaMMMMSc=====f`I=ildf`=perccifkd=ba^=jbjlov====bKpKaK ============================Lcloj^qqfkd...
Page 164 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks nSMMT=======Op_VTM==========`efm oPSP========bogOdbgNRNu=====jdc=`efm============NLNSt==NRM nSMMU=======Op`QMUNqNMSo====`efm oPSR========bogOdbMoMMu=====jdc=`efm============NLNSt====M= ============lo=OpaNUNV^=====`efm oPSS========bogOdbMoMMu=====jdc=`efm============NLNSt====M= oPTM========bogOdbMoMMu=====jdc=`efm============NLNSt====M= oPTN========bogOdbMoMMu=====jdc=`efm============NLNSt====M= DIODES oPTO========bogOdbgNMRu=====jdc=`efm============NLNSt===Nj aPMN========j^OpTOU=========`efm oPTQ========bogOdbgNMNu=====jdc=`efm============NLNSt==NMM ============lo=o_ROMpPMqbSN=`efm oPTR========bogOdbgNMNu=====jdc=`efm============NLNSt==NMM aPMO========j^NNN===========`efm oPTS========bogOdbgNMNu=====jdc=`efm============NLNSt==NMM ============lo=NppPRRqbJNT==`efm oPTT========bogOdbgNMNu=====jdc=`efm============NLNSt==NMM aNNMN=======oaNOpJqN_=======wbkbo=`efm=================NOs oPTU========bogOdbgNMNu=====jdc=`efm============NLNSt==NMM aNNMO=======j^NNN===========`efm oPTV========bogOdbgNMNu=====jdc=`efm============NLNSt==NMM ============lo=NppPRRqbJNT==`efm oPUM========bogOdbgNMNu=====jdc=`efm============NLNSt==NMM aNOMN=======j^UNMM==========wbkbo=`efm=================NMs oPUN========bogOdbgNMNu=====jdc=`efm============NLNSt==NMM aNOMO=======j^UMSUJj========wbkbo=`efm================SKUs oPUO========bogOdbgNMNu=====jdc=`efm============NLNSt==NMM aNOMP=======j^UNOMJe========wbkbo=`efm=================NOs...
Page 165 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks oTOU========bogOdbgNNQu=====jdc=`efm============NLNSt=NNMh oOMNQ=======bogOdbgNMPu=====jdc=`efm============NLNSt==NMh oTOV========bogOdbgNUPu=====jdc=`efm============NLNSt==NUh oOMNR=======bogOdbgQTQu=====jdc=`efm============NLNSt=QTMh oTPM========bogOdbgPSPu=====jdc=`efm============NLNSt==PSh oOMNS=======bogOdbgNMPu=====jdc=`efm============NLNSt==NMh oTPN========bogOdbgPPOu=====jdc=`efm============NLNSt=PKPh oOMNT=======bogOdbgNMNu=====jdc=`efm============NLNSt==NMM oTPO========bogOdbgNUPu=====jdc=`efm============NLNSt==NUh oOMNU=======bogOdbgQTNu=====jdc=`efm============NLNSt==QTM oTPP========bogOdbgNNQu=====jdc=`efm============NLNSt=NNMh oOMNV=======bogOdbgQTNu=====jdc=`efm============NLNSt==QTM oTPQ========bogOdbgPSPu=====jdc=`efm============NLNSt==PSh oPMMN=======bogOdbgQTNu=====jdc=`efm============NLNSt==QTM oTPR========bogOdbgPPOu=====jdc=`efm============NLNSt=PKPh oPMNS=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oTPS========bogOdbgPPOu=====jdc=`efm============NLNSt=PKPh oPMNU=======bogOdbgNMRu=====jdc=`efm============NLNSt===Nj oTPT========bogSdbvgRoSs====jdc=`efm============NLNMt==RKS oPMOM=======bogOdbgPVOu=====jdc=`efm============NLNSt=PKVh oTPU========bogSdbvgRoSs====jdc=`efm============NLNMt==RKS oPMON=======bogOdbgPVOu=====jdc=`efm============NLNSt=PKVh oTPV========bogOdbgNRQu=====jdc=`efm============NLNSt=NRMh oPMOO=======bogOdbgNMPu=====jdc=`efm============NLNSt==NMh oTQM========bogOdbgUOOu=====jdc=`efm============NLNSt=UKOh oPMOQ=======bogOdbMoMMu=====jdc=`efm============NLNSt====M= oTQN========bogOdbgNOQu=====jdc=`efm============NLNSt=NOMh oPMOR=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oTQO========bogOdbgUOOu=====jdc=`efm============NLNSt=UKOh...
Page 166 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks oPOST=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oSMRP=======bogOdbgQTNu=====jdc=`efm============NLNSt==QTM oPOSU=======bogOdbgOTNu=====jdc=`efm============NLNSt==OTM oSMRQ=======bogOdbgRSOu=====jdc=`efm============NLNSt=RKSh oPOUN=======bogOdbgRSPu=====jdc=`efm============NLNSt==RSh oSMRR=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oPOUO=======bogOdbgPPOu=====jdc=`efm============NLNSt=PKPh oSMRS=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oPOUQ=======bogOdbgPVOu=====jdc=`efm============NLNSt=PKVh oSMRT=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oPOUR=======bogOdbgSUOu=====jdc=`efm============NLNSt=SKUh oSMRU=======bogOdbgNOPu=====jdc=`efm============NLNSt==NOh oPOUS=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oSMRV=======bogOdbgPPOu=====jdc=`efm============NLNSt=PKPh oPOUT=======bogOdbgNMMu=====jdc=`efm============NLNSt===NM oSMSM=======bogOdbgNMRu=====jdc=`efm============NLNSt===Nj oPOUU=======bogOdbgPVNu=====jdc=`efm============NLNSt==PVM oSMSN=======bogOdbgNMNu=====jdc=`efm============NLNSt==NMM oPOUV=======bogOoeaOOOu=====jdc=`efm===HJMKRB===NLNSt=OKOh oSMSO=======bogOdbgOOPu=====jdc=`efm============NLNSt==OOh oPOVN=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oSMSP=======bogOdbgNOPu=====jdc=`efm============NLNSt==NOh oPOVO=======bogOdbgOTPu=====jdc=`efm============NLNSt==OTh oSMSQ=======bogOdbgPPOu=====jdc=`efm============NLNSt=PKPh oPOVP=======bogOdbgRSPu=====jdc=`efm============NLNSt==RSh oSMSR=======bogUdbvgPPMs====jdc=`efm============NLUt====PP oPVMO=======bogOdbMoMMu=====jdc=`efm============NLNSt====M= oSMSS=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oQMMN=======bogOdbMoMMu=====jdc=`efm============NLNSt====M=...
Page 167 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks oSNQR=======bogOdbgUOOu=====jdc=`efm============NLNSt=UKOh `TNP========j`rsN^NMRwcs====`=`efm=====HUMBJOMB=NMs======N oSNQS=======bogOdbgRSOu=====jdc=`efm============NLNSt=RKSh `TNQ========b`rsN^QTRwck====`=`efm=====HUMBJOMB=NMs====QKT oSNQT=======bogOdbgOTPu=====jdc=`efm============NLNSt==OTh `TNR========b`rsN^QTRwck====`=`efm=====HUMBJOMB=NMs====QKT oSNQU=======bogOdbgUOOu=====jdc=`efm============NLNSt=UKOh `NNMN=======s`rpn_^OORh_====`=`efm==============NMs====OKO oSNQV=======bogOdbgPPOu=====jdc=`efm============NLNSt=PKPh `NNMO=======b`rbNeNMOh_n====`=`efm==============RMs==NMMMm oSNRM=======bogOdbgPPOu=====jdc=`efm============NLNSt=PKPh `NNMP=======b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN oSNRN=======bogOdbgSUQu=====jdc=`efm============NLNSt=SUMh `NOMN=======b`rsN`NMQh_s====`=`efm==============NSs====MKN oSNRQ=======bogOdbgQTQu=====jdc=`efm============NLNSt=QTMh `NOMO=======b`rsN`NMQh_s====`=`efm==============NSs====MKN oSNRR=======bogOdbgNMNu=====jdc=`efm============NLNSt==NMM `NOMP=======b`rsN`NMQh_s====`=`efm==============NSs====MKN oSNRS=======bogOdbgNMNu=====jdc=`efm============NLNSt==NMM `OMMO=======b`rsNbNMQh_k====`=`efm==============ORs====MKN oSNRT=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh `OMMP=======b`rbNeNMOh_n====`=`efm==============RMs==NMMMm oSNSM=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh `OMMR=======b`rsNbNMQh_k====`=`efm==============ORs====MKN oSNSN=======bogOdbgQTPu=====jdc=`efm============NLNSt==QTh `OMMS=======b`rbNeNMOh_n====`=`efm==============RMs==NMMMm oSNSQ=======bogOdbgOOOu=====jdc=`efm============NLNSt=OKOh `OMMT=======b`rbNeOONh_n====`=`efm==============RMs===OOMm oSNSR=======bogOdbgNOOu=====jdc=`efm============NLNSt=NKOh...
Page 168 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks `PNVV=======b`b^NehhMNM=====bib`qolivqf`========RMs======N `QPMT=======b`pqMguQTSwo====q^kq^irj=`efm=======SKPs====QT `POMO=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN `QPMU=======j`rsNbNMQh_k====`=`efm==============ORs====MKN `POMP=======b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `QPMV=======b`rsNbOOPh_s====`=`efm==============ORs==MKMOO `POMQ=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN `QPNM=======b`rsNbOOPh_s====`=`efm==============ORs==MKMOO `POMR=======b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `QPNN=======j`rsNbNMQh_k====`=`efm==============ORs====MKN `POMV=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN `QPNO=======b`rsN^NMRh_k====`=`efm==============NMs======N `PONM=======b`rbNeMRM``n====`=`efm=====HJMKORm==RMs=====Rm `QPNP=======b`rbNeNMPwcn====`=`efm=====HUMBJOMB=RMs===MKMN `PONN=======b`rbNeMRM``n====`=`efm=====HJMKORm==RMs=====Rm `QPNQ=======b`rsN`OOQh_k====`=`efm==============NSs===MKOO `PONO=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN `SMMN=======b`rbNeOTMg`n====`=`efm=====HJRB=====RMs====OTm `PONP=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN `SMMO=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN `PONQ=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN `SMMP=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN `PONR=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN `SMMQ=======b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `PONS=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN `SMMR=======b`rbNeNRMg`n====`=`efm=====HJRB=====RMs====NRm `PONT=======b`pqMgvNMS======q^kq^irj=`efm=======SKPs====NM `SMMS=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN `PONV=======b`pqMdvOOS======q^kq^irj=`efm=======Qs======OO...
Page 169 (E21) Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks f`QMMP======q`QtSSc=========f`I=ifkb^o=ptfq`efkd CRYSTAL OSCILLATOR ============E=a=F uPMN========ippuMMOO f`QPMN======kgjONRN^sqbN====f`I=ifkb^o=^rafl=^jm uPOMN=======spupMUNM ============lo=kgjONRNsJqbN=f`I=ifkb^o=^rafl=^jm uSMMN=======ippuMMOP f`SMMN======jkNMPMMQh_^N====f`I=PO_fq=jf`ol`lkqoliibo=sqo=====bKpKaK uSMMO=======ippuMMPS f`SMMO======kgjONORcJqbO====f`I=ifkb^o=lmK^jmK f`SMMP======kgjONORcJqbO====f`I=ifkb^o=lmK^jmK f`SMMQ======kgjOQMToJqbN====f`I=ifkb^o=`ljm^o^qlo PIN HEADERS f`SMMR======pPRNQ^bcpq_=====f`I=ildf`=qfjbo===================bKpKaK _N==========ipgmMN^cNMM_====`lkkb`qlo=NMMm f`SMMS======_^SOUVcJbO======f`I=ifkb^o=il^afkd=jlqlo=aofsb _P==========sgpt_PsQQM_P====`lkkb`qlo=QMm f`SMMT======jSOPSSdm========f`I=ifkb^o=a^` f`SMMU======rmaSQSOdpSPO====f`I=ildf`=lpa=====================bKpKaK f`SMMV======pVP`SS^jckq_====f`I=Qh=bbm=olj====================bKpKaK=====*NOTE FPC CONNECTOR f`SMNM======mpqVPOUro=======f`I=ifkb^o=obpbq cmN=========ipgpMR^^MMU=====`lkkb`qlo=Um f`SMNN======pUNPPPedhcqN====f`I=ifkb^o=HPKPs=obdri^qlo...
Page 170 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks nPMMV=======OpaNPOU=========`efm oPPM========bogOdbgNMOu=====jdc=`efm============NLNSt===Nh ============E=a=F oPPN========bogOdbMoMMu=====jdc=`efm============NLNSt====M= nPMNO=======Op^NRTS^NMSo====`efm oPPO========bogOdbgQTPu=====jdc=`efm============NLNSt==QTh ============lo=Op_NONU^=====`efm oPPP========bogOdbgPPOu=====jdc=`efm============NLNSt=PKPh ============E=a=F oPPQ========bogOdbgQTPu=====jdc=`efm============NLNSt==QTh nQMMN=======OpaNPOU=========`efm oPPR========bogOdbMoMMu=====jdc=`efm============NLNSt====M= nQMMO=======OpaNPOU=========`efm oPPS========bogOdbMoMMu=====jdc=`efm============NLNSt====M= nQMMQ=======Op^NRTS^NMSo====`efm oPPT========bogOdbMoMMu=====jdc=`efm============NLNSt====M= ============lo=Op_NONU^=====`efm oPPU========bogOdbgQTNu=====jdc=`efm============NLNSt==QTM nSMMN=======aq^NNQqr========`efm oPPV========bogOdbgQTNu=====jdc=`efm============NLNSt==QTM ============lo=rkRNNR=======`efm oPQM========bogOdbgPPNu=====jdc=`efm============NLNSt==PPM nSMMO=======aq^NNQqr========`efm oPQN========bogOdbgPPNu=====jdc=`efm============NLNSt==PPM ============lo=rkRNNR=======`efm oPQO========bogOdbgQTPu=====jdc=`efm============NLNSt==QTh nSMMP=======Op^NRTS^NMSo====`efm oPQP========bogOdbgPPNu=====jdc=`efm============NLNSt==PPM ============lo=Op_NONU^=====`efm...
Page 171 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks oQOO========bogOdbgNMNu=====jdc=`efm============NLNSt==NMM oTSS========bogOdbgPVPu=====jdc=`efm============NLNSt==PVh oQOR========bogOdbMoMMu=====jdc=`efm============NLNSt====M= oTST========bogOdbgOTPu=====jdc=`efm============NLNSt==OTh oQOS========bogOdbgNMRu=====jdc=`efm============NLNSt===Nj oTSU========bogOdbgNMPu=====jdc=`efm============NLNSt==NMh oQOT========bogPdbvMoMMs====jdc=`efm============NLNSt====M= oTSV========bogPdbvgOTMs====jdc=`efm============NLNSt===OT oQPN========bogOdbgQTOu=====jdc=`efm============NLNSt=QKTh ============E=`Ia=F oQTQ========bogOdbgQTPu=====jdc=`efm============NLNSt==QTh oTTM========bogOdbgPPNu=====jdc=`efm============NLNSt==PPM oQTR========bogOdbMoMMu=====jdc=`efm============NLNSt====M= ============E=`Ia=F oQTS========bogOdbMoMMu=====jdc=`efm============NLNSt====M= oTTN========bogOdbgPPPu=====jdc=`efm============NLNSt==PPh oQTT========bogOdbMoMMu=====jdc=`efm============NLNSt====M= ============E=`Ia=F oQTU========bogOdbgNMPu=====jdc=`efm============NLNSt==NMh oTTO========bogOdbgOTOu=====jdc=`efm============NLNSt=OKTh oQTV========bogOdbgNMPu=====jdc=`efm============NLNSt==NMh ============E=`Ia=F oQUM========bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oTTP========bogOdbgNMPu=====jdc=`efm============NLNSt==NMh oQUN========bogOdbgNMPu=====jdc=`efm============NLNSt==NMh ============E=`Ia=F oQUO========bogOdbgPPNu=====jdc=`efm============NLNSt==PPM oTTQ========bogSdbvMoMMs====jdc=`efm============NLNMt====M= oQUP========bogOdbgNMNu=====jdc=`efm============NLNSt==NMM...
Page 172 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks oPMOV=======bogOdbMoMMu=====jdc=`efm============NLNSt====M= oPOQP=======bogOdbgNMPu=====jdc=`efm============NLNSt==NMh oPMPM=======bogOdbgPVOu=====jdc=`efm============NLNSt=PKVh oPORN=======bogOoeaPPOu=====jdc=`efm===HJMKRB===NLNSt=PKPh oPMPN=======bogOdbMoMMu=====jdc=`efm============NLNSt====M= oPORO=======bogOdbgNMNu=====jdc=`efm============NLNSt==NMM ============E=_I`=F oPORP=======bogOdbgRSOu=====jdc=`efm============NLNSt=RKSh ============bogOdbgQTOu=====jdc=`efm============NLNSt=QKTh oPORQ=======bogOdbgOOPu=====jdc=`efm============NLNSt==OOh ============E=a=F oPORR=======bogOdbgNRPu=====jdc=`efm============NLNSt==NRh oPMPO=======bogOdbMoMMu=====jdc=`efm============NLNSt====M= oPORS=======bogOdbgPVNu=====jdc=`efm============NLNSt==PVM ============E=_I`=F oPORT=======bogOdbgPVNu=====jdc=`efm============NLNSt==PVM ============bogOdbgQTOu=====jdc=`efm============NLNSt=QKTh oPORU=======bogOdbgPVOu=====jdc=`efm============NLNSt=PKVh ============E=a=F oPORV=======bogOdbgNOOu=====jdc=`efm============NLNSt=NKOh oPMPP=======bogOdbMoMMu=====jdc=`efm============NLNSt====M= oPOSM=======bogOdbgNSOu=====jdc=`efm============NLNSt=NKSh ============E=_I`=F oPOSO=======bogOdbgNONu=====jdc=`efm============NLNSt==NOM oPMPQ=======bogOdbMoMMu=====jdc=`efm============NLNSt====M= oPOSP=======bogOdbgNONu=====jdc=`efm============NLNSt==NOM ============E=_I`=F oPOST=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oPMPV=======bogOdbgNMNu=====jdc=`efm============NLNSt==NMM...
Page 173 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks oSMMV=======bogOdbgNMPu=====jdc=`efm============NLNSt==NMh oSMVP=======bogOdbgOTOu=====jdc=`efm============NLNSt=OKTh oSMNM=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oSMVQ=======bogOdbgPVOu=====jdc=`efm============NLNSt=PKVh oSMNO=======bogOdbgRSOu=====jdc=`efm============NLNSt=RKSh oSMVR=======bogOdbgPVOu=====jdc=`efm============NLNSt=PKVh oSMNP=======bogOoeaRSPu=====jdc=`efm===HJMKRB===NLNSt==RSh oSMVS=======bogOdbgPVOu=====jdc=`efm============NLNSt=PKVh oSMNQ=======bogOoeaOOPu=====jdc=`efm===HJMKRB===NLNSt==OOh oSMVT=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oSMNR=======bogOdbgRSOu=====jdc=`efm============NLNSt=RKSh oSMVU=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oSMNS=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oSMVV=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oSMNT=======bogOdbgRSOu=====jdc=`efm============NLNSt=RKSh oSNMM=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh oSMNU=======bogOdbgRSOu=====jdc=`efm============NLNSt=RKSh oSNMO=======bogOdbgOTOu=====jdc=`efm============NLNSt=OKTh oSMNV=======bogOdbgPPNu=====jdc=`efm============NLNSt==PPM oSNMP=======bogOdbgQTPu=====jdc=`efm============NLNSt==QTh oSMON=======bogOdbgQTPu=====jdc=`efm============NLNSt==QTh oSNMS=======bogOdbgQTPu=====jdc=`efm============NLNSt==QTh oSMOO=======bogOdbgNMPu=====jdc=`efm============NLNSt==NMh oSNMT=======bogOdbgQTOu=====jdc=`efm============NLNSt=QKTh oSMOP=======bogOdbgPVOu=====jdc=`efm============NLNSt=PKVh oSNMU=======bogOdbgQTPu=====jdc=`efm============NLNSt==QTh oSMOQ=======bogOdbgPVOu=====jdc=`efm============NLNSt=PKVh oSNNN=======bogOdbgRSOu=====jdc=`efm============NLNSt=RKSh oSMOR=======bogOdbgPVOu=====jdc=`efm============NLNSt=PKVh...
Page 174 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks oSNVO=======bogOdbMoMMu=====jdc=`efm============NLNSt====M= `TNQ========b`rsN^QTRwck====`=`efm=====HUMBJOMB=NMs====QKT ============E=`Ia=F `TNR========b`rsN^QTRwck====`=`efm=====HUMBJOMB=NMs====QKT oVMMN=======bogOdbMoMMu=====jdc=`efm============NLNSt====M= `NNMN=======b`rsMgOORh_k====`=`efm==============SKPs===OKO oVMMO=======bogOdbMoMMu=====jdc=`efm============NLNSt====M= `NNMO=======b`rbNeNMOh_n====`=`efm==============RMs==NMMMm `NNMP=======b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `NOMN=======b`rsN`NMQh_s====`=`efm==============NSs====MKN CAPACITORS `NOMO=======b`rsN`NMQh_s====`=`efm==============NSs====MKN `PMN========b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `NOMP=======b`rsN`NMQh_s====`=`efm==============NSs====MKN `PMO========b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `OMMO=======b`rsNbNMQh_k====`=`efm==============ORs====MKN `PMP========b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `OMMP=======b`rbNeNMOh_n====`=`efm==============RMs==NMMMm `PMQ========b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `OMMR=======b`rsNbNMQh_k====`=`efm==============ORs====MKN `PMR========b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `OMMS=======b`rbNeNMOh_n====`=`efm==============RMs==NMMMm `PMS========b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `OMMT=======b`rbNeOONh_n====`=`efm==============RMs===OOMm `PMT========b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `OMMU=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN `PMU========b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `OMMV=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN `PMV========b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN...
Page 175 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks `PMRR=======b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `POVS=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN `PMRS=======b`rbNeNRMg`n====`=`efm=====HJRB=====RMs====NRm `QMMN=======b`pqMgvNMS======q^kq^irj=`efm=======SKPs====NM `PMRT=======b`rbNeNMMa`n====`=`efm=====HJMKRB===RMs====NMm `QMMO=======b`pqMgvQTR======q^kq^irj=`efm=======SKPs===QKT `PMRU=======b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `QMMP=======b`pqMgvQTR======q^kq^irj=`efm=======SKPs===QKT `PMRV=======b`rsN^NMRh_k====`=`efm==============NMs======N `QMMQ=======b`pqMgvQTR======q^kq^irj=`efm=======SKPs===QKT `PMSM=======b`rbNeNMNg`n====`=`efm=====HJRB=====RMs===NMMm `QMMS=======b`rbN^NMQh_n====`=`efm==============NMs====MKN `PMSN=======b`rbNeNMNg`n====`=`efm=====HJRB=====RMs===NMMm `QMMT=======b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `PMSO=======b`rsN^NMRh_k====`=`efm==============NMs======N `QMMU=======b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `PMSP=======b`rsN^NMRh_k====`=`efm==============NMs======N `QMMV=======b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `PMSQ=======b`rbN`NMQwcn====`=`efm=====HUMBJOMB=NSs====MKN `QMNM=======b`rsN^NMRh_k====`=`efm==============NMs======N `PMUN=======b`pqMgvNMS======q^kq^irj=`efm=======SKPs====NM `QMNN=======b`rbNeNROh_n====`=`efm==============RMs==NRMMm `PMUO=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN `QMNO=======b`rbNeNONg`n====`=`efm=====HJRB=====RMs===NOMm `PMUP=======b`pqMgvNMS======q^kq^irj=`efm=======SKPs====NM `QMNR=======b`pqMgvNMS======q^kq^irj=`efm=======SKPs====NM `PMUQ=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN `QMNS=======b`rsN^NMRh_k====`=`efm==============NMs======N `PMUS=======b`rbN`NMPh_n====`=`efm==============NSs===MKMN...
Page 176 (E21) Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks COILS RESISTORS iPMN========sigtkviNMMhq====`efm========================NM oRMMN=======bogOdbMoMMu=====jdc=`efm============NLNSt====M= iPMO========simMPNV^QTNq====cboofqb=_b^a=`efm oRMMR=======bogOdbgOTNu=====jdc=`efm============NLNSt==OTM iPMP========ipigce_NMMkc====`efm========================NM oRMMS=======bogOdbgSUOu=====jdc=`efm============NLNSt=SKUh iPMQ========ipigce_OOMkc====`efm========================OO oRMMT=======bogOdbgNUOu=====jdc=`efm============NLNSt=NKUh iPMR========simMPNV^QTNq====cboofqb=_b^a=`efm oRMMU=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh iPMS========simMPNV^QTNq====cboofqb=_b^a=`efm oRMMV=======bogOdbgNMPu=====jdc=`efm============NLNSt==NMh iPMT========ipigag^NMMhc====`efm========================NM oRMNM=======bogOdbgNMPu=====jdc=`efm============NLNSt==NMh iPMU========ipigce_NMMkc====`efm========================NM oRMNN=======bogOdbgNMPu=====jdc=`efm============NLNSt==NMh iPMV========ipigce_OOMkc====`efm========================OO oRMNO=======bogOdbgNMPu=====jdc=`efm============NLNSt==NMh iTMO========sigtkviNMMhq====`efm========================NM oRMNP=======bogOdbMoMMu=====jdc=`efm============NLNSt====M= iPMMN=======simMPSP^NMOq====cboofqb=_b^a=`efm oRMNQ=======bogOdbMoMMu=====jdc=`efm============NLNSt====M= iPMMO=======simMPSP^NMOq====cboofqb=_b^a=`efm iPMMP=======sigtkviNMMhq====`efm========================NM CAPACITORS iPMMR=======ipigce_NMMkc====`efm========================NM...
Page 177 (E22) Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks nPRNO=======Op^NRTS^NMSo====`efm S-JACK C.B.A. ============lo=Op_NONU^=====`efm nPSMM=======Op`QMUNqNMSo====`efm ============lo=OpaNUNV^=====`efm DIODES nPSMN=======Op`PVPU=========`efm aPTRN=======oaSKOp==========wbkbo=`efm================SKOs nPSRN=======Op_NMTP=========`efm aPTRO=======acP^SKUcb=======wbkbo=`efm================SKUs ============lo=Op_NPUSqNMMn=`efm ============lo=j^wqMSUeMi===wbkbo=`efm================SKUs ============lo=Op_NPUSqNMMo=`efm aPTRR=======oaSKOp==========wbkbo=`efm================SKOs nPSRO=======aq`NQQbr========`efm ============E=a=F ============lo=rkRONP=======`efm aPTRS=======oaSKOp==========wbkbo=`efm================SKOs DIODES RESISTORS aPSMM=======j^NNN===========`efm oPTRN=======bogPdbvgRSNs====jdc=`efm============NLNSt==RSM ============lo=NppPRRqbJNT==`efm oPTRO=======bogPdbvgPPNs====jdc=`efm============NLNSt==PPM ============E=a=F RESISTORS oPTRP=======bogPdbvMoMMs====jdc=`efm============NLNSt====M=...
Page 178 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks CAPACITORS COILS `PRMM=======b`pqMguOOS======q^kq^irj=`efm=======SKPs====OO iPRMN=======ipigag^NMMhc====`efm========================NM `PRMN=======b`rsNeNMPwcs====`=`efm=====HUMBJOMB=RMs===MKMN iPRMO=======sinMQOSgPPM=====`efm========================PP `PRMP=======b`rsN^NMRh_k====`=`efm==============NMs======N iPRMP=======ipigag^NMMhc====`efm========================NM `PRMQ=======b`rsNeRSNg`s====`=`efm=====HJRB=====RMs===RSMm iPRMQ=======ipigag^NMMhc====`efm========================NM `PRMR=======b`rsNePVNg`s====`=`efm=====HJRB=====RMs===PVMm iPRMS=======ipigag^NMMhc====`efm========================NM `PRMS=======b`rsNeQTMg`s====`=`efm=====HJRB=====RMs====QTm iPRMT=======sinMQOSgPPM=====`efm========================PP `PRMT=======b`rsNeNMPwcs====`=`efm=====HUMBJOMB=RMs===MKMN iPRMU=======sinMQOSgPPM=====`efm========================PP `PRMU=======b`pqMgvQTR======q^kq^irj=`efm=======SKPs===QKT iPRMV=======sinMQOSgNMM=====`efm========================NM `PRMV=======b`rsNeNMPwcs====`=`efm=====HUMBJOMB=RMs===MKMN iPRNM=======sinMQOSgPPM=====`efm========================PP `PRNM=======b`rsNeSUMg`s====`=`efm=====HJRB=====RMs====SUm iPRNO=======sinMQOSgPPM=====`efm========================PP `PRNN=======b`pqN`vOOR======q^kq^irj=`efm=======NSs====OKO iPSMM=======ipigag^NMMhc====`efm========================NM `PRNO=======b`pqMguOOS======q^kq^irj=`efm=======SKPs====OO iPSMN=======ipigag^NMMhc====`efm========================NM `PRNP=======b`rsNeNMPwcs====`=`efm=====HUMBJOMB=RMs===MKMN `PRNQ=======b`rsNeNMPwcs====`=`efm=====HUMBJOMB=RMs===MKMN CRYSTAL OSCILLATOR...
Page 179 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks oNMNQ=======bogOdbgQTOu=====jdc=`efm============NLNSt=QKTh `NMQM=======b`rsNbNMRh_j====`=`efm==============ORs======N oNMNR=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh `NMQN=======s`rpn_`NMRh_====`=`efm==============NSs======N oNMNS=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh `NMQO=======s`rpn_`NMRh_====`=`efm==============NSs======N oNMNT=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh `NMQP=======b`rbNeNMOh_n====`=`efm==============RMs==NMMMm oNMNU=======bogOdbgNRNu=====jdc=`efm============NLNSt==NRM `NMQS=======b`rbNeNROh_n====`=`efm==============RMs==NRMMm oNMNV=======bogOdbgNMOu=====jdc=`efm============NLNSt===Nh `NMQU=======b`rbNeNMOh_n====`=`efm==============RMs==NMMMm oNMOM=======bogOdbgSUOu=====jdc=`efm============NLNSt=SKUh `NMRM=======b`rbNeNMOh_n====`=`efm==============RMs==NMMMm oNMON=======bogOdbgRSOu=====jdc=`efm============NLNSt=RKSh `NMRN=======b`rsN`NMRwck====`=`efm=====HUMBJOMB=NSs======N oNMOO=======bogOdbgSUOu=====jdc=`efm============NLNSt=SKUh `NMRO=======b`pqMgvNMS======q^kq^irj=`efm=======SKPs====NM oNMOP=======bogOdbgSUOu=====jdc=`efm============NLNSt=SKUh `NMRP=======b`rsN`NMRwck====`=`efm=====HUMBJOMB=NSs======N oNMOQ=======sogpnSaSUOw=====jdc=`efm===HJMKRB===NLNSt=SKUh `NMRQ=======b`rsN^NMRh_k====`=`efm==============NMs======N oNMOR=======sogpnSaUOMw=====jdc=`efm===HJMKRB===NLNSt===UO ============E=a=F oNMOS=======sogpnSaUOMw=====jdc=`efm===HJMKRB===NLNSt===UO `NMRR=======b`rsN^NMRh_k====`=`efm==============NMs======N oNMOT=======sogpnSaPPNw=====jdc=`efm===HJMKRB===NLNSt==PPM `NMRS=======b`rsN^NMRh_k====`=`efm==============NMs======N oNMOU=======sogpnSaOTOw=====jdc=`efm===HJMKRB===NLNSt=OKTh...
Page 180 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks iNMOQ=======ipicMMOR========bjf=cfiqbo=`efm DIODES iNMOR=======sigtkviNMMhq====`efm========================NM ============E=_I`Ia=F aQUMP=======a^OMQr==========`efm iNMOS=======sigtkviNMMhq====`efm========================NM ============lo=j^NQP========`efm iSRMN=======_hNSMUejNMO=====cboofqb=`lob aSRMN=======ikNORN`^iJqo====q^iiv=iba=`efm iSRMO=======_hNSMUejNMO=====cboofqb=`lob ============lo=pjiMNMiqJjkm=q^iiv=iba=`efm iSRMP=======_hNSMUejNMO=====cboofqb=`lob aSRMO=======pioTNOP^RM^_====fo=iba ============E=`Ia=F aSRMP=======pioTNOP^RM^_====fo=iba PIN HEADERS ============E=`Ia=F _NMMN=======ipgpMN^dNMM_====`lkkb`qlo=NMMm RESISTORS FUSE & PROTECTOR oQUMN=======sogpaPaPVMN=====jdc=`efm===HJMKRB===NLNSt=PKVh cNMMN=======ippcMMP`OMq=====crpb================POs=====O^=! oQUMO=======sogpaPaPVMN=====jdc=`efm===HJMKRB===NLNSt=PKVh ============lo=ippcMMT`OMq==crpb================POs=====O^=! oQUMP=======bogPdbvgPPPs====jdc=`efm============NLNSt==PPh cNMMO=======ippcMMP`NMq=====crpb================POs=====N^=!
Page 181 (E31, E32, E33, E34, E35, E36, E37, E38) (E24, E25) Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks CAPACITORS TRANSISTORS `QUMN=======b`rsNeNMOh_s====`=`efm==============RMs==NMMMm nSMN========umQSMN==========`ljmiu=`jm=pf=kmkLmkm=`efm `QUMO=======b`rsNeNMOh_s====`=`efm==============RMs==NMMMm nSMO========Op`PVPN=========`efm `QUMP=======b`rsN`QTPh_s====`=`efm==============NSs==MKMQT nSMP========Op`QSNTEoF======`efm `QUMQ=======b`rsN`NRPh_s====`=`efm==============NSs==MKMNR ============lo=OpaOONSg=====`efm `QUMR=======b`rsN`PPPh_s====`=`efm==============NSs==MKMPP `QUMS=======b`rsN^NRQh_s====`=`efm==============NMs===MKNR RESISTORS `QUMT=======b`rsNePPNh_s====`=`efm==============RMs===PPMm `QUMU=======b`rsNeQTOh_s====`=`efm==============RMs==QTMMm oSMN========bogOdbMoMMu=====jdc=`efm============NLNSt====M= `QUMV=======b`rsN`NRPh_s====`=`efm==============NSs==MKMNR oSMO========bogOdbgRSOu=====jdc=`efm============NLNSt=RKSh `QUNM=======b`rsN`QTPh_s====`=`efm==============NSs==MKMQT...
Page 182 (E41, E42, E43, E44) Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks RESISTORS MISCELLANEOUS oVMN========bogPdbvgOTMs====jdc=`efm============NLNSt===OT oVMO========bogPdbvgNMOs====jdc=`efm============NLNSt===Nh bQN=========bivMQsRTUc======abcib`qflk=vlhb================! oVMQ========bogPdbvMoMMs====jdc=`efm============NLNSt====M= bQO=========jMNipuMTt_MN====`oq============================! oVMR========bogPdbvMoMMs====jdc=`efm============NLNSt====M= bQP=========ipg_UMOM========bsc=`^_ib=tLlrq=mird oVMS========sogpaPaNPMOs====jdc=`efm===HJMKRB===NLNSt==NPh bQQ=========ipbhMPTO========`oq=pl`hbq=rkfq oVMT========sogpaPaNOMPs====jdc=`efm===HJMKRB===NLNSt=NOMh oVMU========bogPdbvgRNQs====jdc=`efm============NLNSt=RNMh COLOR ELECTRONIC oVMV========bogPdbvgOQOs====jdc=`efm============NLNSt=OKQh VIEWFINDER A C.B.A. oVNM========bogPdbvgOONs====jdc=`efm============NLNSt==OOM ( C,D ) oVNN========bogPdbvMoMMs====jdc=`efm============NLNSt====M= oVNQ========bogPdbvgPoVs====jdc=`efm============NLNSt==PKV oVNR========bogPdbvgOOOs====jdc=`efm============NLNSt=OKOh...
Page 183 Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks `VOT========b`rsMgQTQh_s====`=`efm==============SKPs==MKQT nUNMQ=======OpaNNNV=========`efm `VOU========b`rsMgQTQh_s====`=`efm==============SKPs==MKQT ============lo=OpaONRMqNMMo=`efm nUNMR=======OpaNNNV=========`efm ============lo=OpaONRMqNMMo=`efm COILS iVMN========sinMQOSgNRM=====`efm=======HJRB=============NR iVMO========sinMQOSgNRM=====`efm=======HJRB=============NR DIODES iVMP========sinMQOSgNRM=====`efm=======HJRB=============NR aUMMN=======j^UMSUJj========wbkbo=`efm================SKUs iVMQ========sinMQOSgNRM=====`efm=======HJRB=============NR aUNMO=======bmNMnvMPqbUi====`efm iVMR========sinMQOSgNRM=====`efm=======HJRB=============NR RESISTORS PIN HEADERS oUMMN=======bogPdbvgNMOs====jdc=`efm============NLNSt===Nh mVMN========sgmtMOQQ========`lkkb`qlo=Om oUMMO=======bogPdbvgNMOs====jdc=`efm============NLNSt===Nh oUMMP=======bogPdbvgNMOs====jdc=`efm============NLNSt===Nh oUMMQ=======bogPdbvgOOPs====jdc=`efm============NLNSt==OOh FPC CONNECTOR oUMMR=======bogPdbvgOOOs====jdc=`efm============NLNSt=OKOh cmVMN=======ipgpMP^_MOO=====`lkkb`qlo=OOm oUMMS=======bogPdbvgQTPs====jdc=`efm============NLNSt==QTh cmVMO=======ipgpMP^_MNS=====`lkkb`qlo=NSm...
Page 184 (E28) Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks `UMNV=======kj^MgOOSjqo=====bib`qolivqf`=`efm===SKPs====OO SUMMARY OF “E” ITEM NUMBERS `UMOM=======b`rsNbNMQh_k====`=`efm==============ORs====MKN REFER TO ELECTRICAL PARTS LIST `UMON=======s`rpg_gOORh_====`=`efm==============SKPs===OKO FOR MODEL INFORMATION `UMOO=======b`rsN`NMQh_s====`=`efm==============NSs====MKN `UMOQ=======b`rsMgOORh_k====`=`efm==============SKPs===OKO `UMOT=======b`pqN`uNMS======q^kq^irj=`efm=======NSs=====NM `UMOU=======b`rsMgOORh_k====`=`efm==============SKPs===OKO bN==========ipbmUMMN_N======j^fk=`K_K^K `UMOV=======b`rsMgOORh_k====`=`efm==============SKPs===OKO bN==========ipbmUMMU^N======j^fk=`K_K^K `UMPM=======b`pqNauNMSo=====q^kq^irj=`efm=======OMs=====NM bN==========ipbmUMMU_N======j^fk=`K_K^K `UMPO=======b`rsMgOORh_k====`=`efm==============SKPs===OKO bN==========ipbmUMMU`N======j^fk=`K_K^K `UMPP=======b`rsNeNRNg`s====`=`efm=====HJRB=====RMs===NRMm...
Page 185: Ac Adaptor Section
AC ADAPTOR SECTION DISASSEMBLY/ASSEMBLY PROCEDURES Disassembly Flowchart Disassembly Method This flow chart indicates the disassembly steps of the cabinet parts and the P.C. Boards in order to gain access to item (s) to be serviced. When reassembling, perform the step (s) in the STEP Fig.
Page 186: Electrical Adjustment
ELECTRICAL ADJUSTMENT TEST EQUIPMENT To do Reference voltage adjustments, the following equip- ments are required. 1. DVM (Digital Volt Metet) 2. Plastic Tip Driver or Non-metal Driver Reference Voltage Adjustment Purpose: To set the proper reference voltage output. Symptom of Msadjustment: All circuits will not operate properly.
Page 187: Schematic Diagram Ac Adaptor Schematic Diagram
SCHEMATIC DIAGRAM AC ADAPTOR SCHEMATIC DIAGRAM CAUTION: FOR CONTINUED PROTECTION AGAINST FIRE HAZARD, IMPORTANT SAFETY NOTICE: NOTE: FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, REPLACE ONLY WITH THE SAME TYPE 1.6A 250V FUSE. COMPONENTS IDENTIFIED BY THE SIGN HAVE SPECIAL CHARACTERISTICS IMPORTANT FOR SAFETY.
Page 188: Circuit Board Layout
CIRCUIT BOARD LAYOUT AC ADAPTOR C.B.A. LSEP1030A1 NOTE: NOTE: FOR SCHEMATIC DIAGRAM AND CIRCUIT BOARD LAYOUT NOTES, CIRCUIT BOARD LAYOUT SHOWS COMPONENTS INSTALLED FOR VARIOUS MODELS. AC ADAPTOR AC ADAPTOR REFER TO BEGINNING OF SCHEMATIC SECTION. FOR PROPER PARTS CONTENT FOR THE MODEL YOU ARE SERVICING, PLEASE REFER TO THE SCHEMATIC DIAGRAM AND PARTS LIST.
Page 189: Block Diagram Ac Adaptor Block Diagram
BLOCK DIAGRAM AC ADAPTOR BLOCK DIAGRAM AC ADAPTOR C.B.A. F1001 T1001 L1001 D1002 1.6A/250V P1001 D1102 C1105 LINE FULL-WAVE AC IN RECTIFIER SMOOTHING FILTER RECTIFIER P1001 P1101 DC JACK L1101, D1101 C1102, C1121 RECTIFIER SMOOTHING Q1103 D1103 P1102 Q1001 OVER VOLTAGE BATTERY PROTECTOR TERMINAL...
Page 190: Exploded Views
EXPLODED VIEWS AC ADAPTOR SECTION Note: Parts with no Ref. No. in "EXPLODED VIEW" are not supplied. And some Ref. No. will be skipped. Be sure to make your orders of replacement parts according to the parts list. IMPORTANT SAFETY NOTICE: COMPONENTS IDENTIFIED BY THE SIGN HAVE SPECIAL CHARACTERISTICS IMPORTANT FOR SAFETY.
Page 191: Packing Parts And Accessories Section
PACKING PARTS AND IMPORTANT SAFETY NOTICE: COMPONENTS IDENTIFIED BY THE SIGN HAVE ACCESSORIES SECTION SPECIAL CHARACTERISTICS IMPORTANT FOR SAFETY. WHEN REPLACING ANY OF THESE COMPONENTS, USE ONLY THE SPECIFIED PARTS. not supplied...
Page 192: Replacement Parts Lists
REPLACEMENT PARTS LISTS BEFORE REPLACING PARTS, READ THE FOLLOWING: MECHANICAL REPLACEMENT Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks PARTS LIST REPLACEMENT NOTES <The complete Exploded Views are shown in this manual.> General Notes EXPLODED VIEWS AC ADAPTOR SECTION 1.
Page 193: Electrical Replacement Parts List
ELECTRICAL REPLACEMENT Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks PARTS LIST oNMNP=======bogSdbvMoMMs====jdc=`efm============NLNMt====M= oNMNQ=======bouOpgoPSb======jbq^i=cfij==========Ot====MKPS (E51) oNMNR=======bodOpgOOMb======jbq^i=lufab=========Ot======OO oNMNS=======bogPdbvgQTMs====jdc=`efm============NLNSt===QT Ref. No. Part No. Part Name Remarks oNMNT=======bogUdbvgOOMs====jdc=`efm============NLUt====OO oNNMN=======bogUdbvgPoPs====jdc=`efm============NLUt===PKP PRINTED CIRCUIT BOARD ASSEMBLY oNNMO=======bogSdbvgTRNs====jdc=`efm============NLNMt==TRM bRN=========ipbmNMPM^N======^`=^a^mqlo=`K_K^K============== =bKpKaK=oqi oNNMP=======bogPdbvgNMOs====jdc=`efm============NLNSt===Nh oNNMQ=======bogPdbvgNMOs====jdc=`efm============NLNSt===Nh oNNMR=======bogUdbvgOOMs====jdc=`efm============NLUt====OO AC ADAPTOR C.B.A.
Page 194 (E61, E62, E63) Ref. No. Part No. Part Name Remarks Ref. No. Part No. Part Name Remarks SUMMARY OF “E” ITEM NUMBERS CAPACITORS REFER TO ELECTRICAL PARTS LIST `NMMN=======b`nrO^NMQjd=====mlivbpqbo==HJOMB====ORMs===MKN=! FOR MODEL INFORMATION ============lo=b`nrO^NMQjd^=mlivbpqbo==HJOMB====ORMs===MKN=! `NMMO=======b`^OddPPMw======bib`qolivqf`========QMMs====PP=! ============lo=ip`bMMSP=====bib`qolivqf`========QMMs====PP=! bRN=========ipbmNMPM^N======^`=^a^mqlo=`K_K^K========================oqi `NMMP=======ip`bMMTV========bib`qolivqf`========RMs=====OO bSN=========ipp`MPPQ========eb^q=pfkh=_ `NMMQ=======b`rsNeNMOh_s====`=`efm==============RMs==NMMMm bSO=========ipp`MPPP========eb^q=pfkh=^ `NMMR=======b`rsNeRSNg`s====`=`efm=====HJRB=====RMs===RSMm bSP=========uvkPHgU=========p`obt=tLt^peboIpqbbi `NMMS=======ip`bMMUN========bib`qolivqf`========RMs=====NM...
Page 195 ® Printed in Japan...

This manual is also suitable for:

Digital palmcorder palmsight pv-dv200 Digital palmcorder palmsight pv-dv400 Digital palmcorder palmsight pv-dv600 Palmsight pv-dac10

Panasonic Digital Palmcorder PalmSight PV-DV100 Service Manual

Safety Precautions

Prevention of Esd to es Devices

X-Radiation (Model: A, B)

Service Notes

Disassembly/Assembly Procedures

Adjustment Procedures

Schematic Diagrams

Circuit Board Layout

BLOCK DIAGRAMS CCD Drive Block Diagram

Exploded Views

Replacement Parts Lists

Ac Adaptor Section

Disassembly/Assembly Procedures

Electrical Adjustment

SCHEMATIC DIAGRAM AC Adaptor Schematic Diagram

Circuit Board Layout

BLOCK DIAGRAM AC Adaptor Block Diagram

Exploded Views

Replacement Parts Lists

Quick Links

Related Manuals for Panasonic Digital Palmcorder PalmSight PV-DV100

Summary of Contents for Panasonic Digital Palmcorder PalmSight PV-DV100

This manual is also suitable for:

Table of Contents