Trademarks XPower is a trademark of Xantrex International. Xantrex is a registered trademark of Xantrex International. Other trademarks, registered trademarks, and product names are the property of their respective owners and are used herein for identification purposes only.
Xantrex, the leader in high frequency inverter design. Connected to the 12 volt outlet in your vehicle, the XPower 150 efficiently and reliably powers a wide variety of AC loads, such as compact TVs and VCRs, laptops, camcorder and cell phone chargers, compact fluorescent lights, and soldering irons.
AC outlet or any other openings in the inverter. Do not open the inverter. Have a qualified individual complete any service work. WARNING: Shock hazard Do not expose the XPower 150 to water, rain, snow, or spray.
Page 7
WARNING: Fire hazard To reduce the risk of fire, do not cover or obstruct the ventilation openings. Do not install the XPower 150 in a zero-clearance compartment. Overheating may result. CAUTION: Risk of damage to equipment The XPower 150 is designed to be directly connected to standard electrical and electronic equipment in the manner described in this guide.
Page 8
Certain battery chargers for battery packs used in hand power tools. These chargers will have a warning label stating that dangerous voltages are present at the battery terminals. Do not use the XPower 150 with the types of appliances just described.
¨ AC Outlet An AC outlet is located on one end of the XPower 150. It allows you to plug in a 230 volt AC load with a power consumption of 150 watts or less. The AC outlet on your inverter may be different from the one shown here.
Audible Alarm An audible alarm warns you of a high- temperature shutdown or of an impending low battery voltage shutdown. AC Outlets Depending on your geographic location, your XPower 150 will have one of the following AC outlets. Figure 2 European AC Figure 3 British AC...
4 Connecting the XPower 150 Choosing a Location For best performance, choose a location that is: • Dry Do not expose the inverter to water drip or spray. • Cool Operate the inverter in ambient temperatures between 0° C and 40° C (32° F and 100° F). Keep it away from heating vents and direct sunlight.
• Possible shutdown when the vehicle’s engine is started The XPower 150 will operate while your vehicle’s engine is running, but the normal voltage drop...
Page 13
• AC Overload Shutdown If you connect an AC load that is rated higher than 150 watts or 0.65 amps or that draws excessive surge power, the XPower 150 shuts down. The light stays on, and the light comes on to indicate that the inverter is overloaded.
Interference With Electronic Equipment Most AC loads operate with the XPower 150 as they would with household AC power with the following exceptions. Buzzing Sound Some inexpensive stereo systems and “boom boxes” have inadequate internal power supply filtering and buzz slightly when powered by the XPower 150.
• Do not leave the XPower 150 on for extended periods if an AC load is not connected. The inverter draws less than 0.18 amps with the On/ Standby switch on and no AC load connected, but that will eventually discharge the battery.
7 Troubleshooting WARNING: Shock hazard Do not open the inverter or attempt to service it yourself. Refer all service to qualified personnel. This section describes problems you could encounter as well as possible causes and various remedies. The AC load will not operate; the light is on.
Page 17
Symptom The AC load runs for more than one minute, the alarm sounds, and the light comes on. The inverter is warm or hot to touch. Possible cause Suggested remedy Poor ventilation or a high- Ensure that ventilation is not temperature environment has restricted around the inverter.
Page 18
Symptom The AC voltmeter reading is 5 to 15 volts too low. Possible cause Suggested remedy A standard “average reading” For accuracy, the XPower 150 AC voltmeter has been used to modified sine wave output measure the output voltage. needs to be measured with a “true RMS”...
8 Specifications Specifications may change without notice. Electrical AC receptacles AC output voltage 230 volts AC ± 5% AC output frequency 50 Hz ± 3 Hz AC output waveform Modified Sine Wave Maximum continuous AC output 150 watts power Maximum AC output surge power 300 watts DC input voltage range 10–15 volts DC Battery drain with no AC load (at...
Physical Dimensions (L x W x H) 156mm x 103mm x 62mm (6.2 in. x 4.1 in. x 2.5 in.) Weight 0.65 Kg (1.5 lb.) Regulatory CE Mark Low Voltage Directive e Mark Automotive EMC Directive TUV/GS Certified to EN60950 Environmental Complies with the EU’s “Restriction of Hazardous Substances”...
What does this warranty cover? This Limited Warranty is provided by Xantrex Technology, Inc. ("Xantrex") and covers defects in workmanship and materials in your XPower Inverter 150. This warranty period lasts for twenty-four (24) months from the date of purchase at the point of sale to you, the original end user customer.
Page 22
How do you get service? If your product requires troubleshooting or warranty service, contact your merchant. If you are unable to contact your merchant, or the merchant is unable to provide service, contact Xantrex directly at: Telephone: 1 360 925 5097 (direct) Fax: 1 360 925 5143 (direct) Email:...
Page 23
What does this warranty not cover? This Limited Warranty does not cover normal wear and tear of the product or costs related to the removal, installation, or troubleshooting of the customer's electrical systems. This warranty does not apply to and Xantrex will not be responsible for any defect in or damage to: the product if it has been misused, neglected, improperly installed, physically damaged or altered, either internally or...
Page 24
RESTRICTION ANY IMPLIED WARRANTY OR CONDITION OF QUALITY, MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE TO THE EXTENT REQUIRED UNDER APPLICABLE LAW TO APPLY TO THE PRODUCT SHALL BE LIMITED IN DURATION TO THE PERIOD STIPULATED UNDER THIS LIMITED WARRANTY.
IN CONNECTION WITH LIFE SUPPORT SYSTEMS OR OTHER MEDICAL EQUIPMENT OR DEVICES. Please note that the XPower Inverter 150 is not intended for use as an uninterruptible power supply and Xantrex makes no warranty or representation in connection with any use of the product for such purposes.
Return Procedure Package the unit safely, preferably using the original box and packing materials. Please ensure that your product is shipped fully insured in the original packaging or equivalent. This warranty will not apply where the product is damaged due to improper packaging.
Out of Warranty Service If the warranty period for your XPower Inverter 150 has expired, if the unit was damaged by misuse or incorrect installation, if other conditions of the warranty have not been met, or if no dated proof of purchase is available, your inverter may be serviced or replaced for a flat fee.