Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Cal Flame FRP-1000
Summary of Contents for Cal Flame FRP-1000
- Page 1 LTR20081006, Rev. A 3/10/08...
-
Page 2: Table Of Contents
Copyright 2008 Lloyds Material Supply, Inc. All rights reserved. or assistance, contact: Duplication without written consent is strictly prohibited. L.M.S. Customer Service Department Cal Spas™ and Cal Flame™ are registered trademarks. 1462 East Ninth Street Pomona, CA 91766. Due to continuous improvement programs, all models, operation, and/or specifications are subject to change without prior notice. -
Page 3: Safety Instructions
Safety Instructions Safety Instructions Read this before installing or operating your new Cal Flame firepit or fireplace. WARNING: Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Read the installation, operating and maintenance instructions thoroughly before installing or servicing this equipment. Unless specifically recommended in this manual, do not repair or replace any part of your firepit or fireplace. - Page 4 Safety Instructions Do not use your firepit or fireplace for cooking. The appliance should be inspected before use and • • at least annually by a qualified service person. In the event that a burner goes out, turn burner • knobs to the full OFF position and let it air out.
-
Page 5: Installation
Your Cal Flame firepit or fireplace is designed and On LP systems, remove the cylinder from the intended for OUTDOOR USE ONLY in a well ventilated fireplace or firepit. -
Page 6: Liquid Propane (Lp)
Installation and Assembly Liquid Propane (LP) Requirements The 20 lb LP gas supply cylinder used with LP models must be constructed and marked in accordance with the specifications for LP-gas cylinders as required by the U.S. Department of Transportation (DOT) or the CAN/CSA B339, Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods. -
Page 7: Connection
Installation and Assembly Check the rating plate to make sure the gas supply you Connection are hooking up to is the gas type the firepit or fireplace Inspect the hose shipped with the unit for damage. is manufactured for. Never attempt to use damaged or plugged equipment. See your local LP gas dealer for repairs. -
Page 8: Natural Gas
Your Cal Flame firepit or fireplace for use with natural gas comes equipped with its own regulator which MUST NOT be removed. If this regulator needs to be replaced, use only the type specified by Cal Flame for this appliance. -
Page 9: Fireplace Log Set Placement
FRP-4300. Ensure the logs are place securely to avoid flow of the flame. any movement. Log Placement for FRP-4300 Log placement for FRP-1000, 1500, 2000, 3000, 3100 2008 Fireplace and Firepit Owner’s Manual Page 7 LTR20081006, Rev. A... -
Page 10: Fire Pit Burner Installation
Installation and Assembly Fire Pit Burner Installation Applies to all fire pits. The log set, log grate and crushed lava rock are shipped together on applicable models. Remove the log set and un-pack all components. The logs are fragile -- use care when handling. Turn the fire pit on its side. -
Page 11: Natural Gas Conversion
Installation and Assembly Natural Gas Conversion Applies to the following fireplaces and fire pits: For Both Fireplaces or Fire Pits FRP-1000 FPT-50 FPT-650 CAUTION: This service is to be completed only by an FRP-1100 FPT-80 FPT-800 authorized gas appliance installer. Do not attempt this... -
Page 12: Operation
Operation Operation If you do not follow these instructions exactly, a fire or explosion may result, WARNING: DO NOT use solid fuel, such as causing property damage, personal wood or charcoal, in gas fueled fireplaces injury, or loss of life. or fire pits. -
Page 13: Lighting Instructions For Automatic Starter
Operation Lighting Instructions for Automatic Starter For THIS kind of starter: Applies to the following fireplaces: FRP-1000 FRP-3100 FRP-1100 FRP-3200 FRP-1500 FRP-4300 FRP-2000 FRP-4400 FRP-3000 Applies to all fire pits: Remove protective storage cover and locate the To Turn Off Gas... -
Page 14: Lighting Instructions For Fireplaces With Manual Control
Operation Lighting Instructions for Fireplaces with Manual Control For THIS kind of fireplace: Applies to the following fireplaces: FRP-2600 FRP-3300 FRP-4000 FRP-4100 FRP-4200 FRP-5000 This appliance has a pilot which must be manually lit. When the appliance is being operated for the first time, allow for a supervised burn of 30 minutes. -
Page 15: Lighting Your Wood Burning Fireplace
Operation Lighting Your Wood Burning Fireplace Applies to the FRP-4200 Your wood burning fireplace is designed to use a grate to hold the wood to be fireplace with the wood burned approximately 2”-3” off the base. This allows air to get to the bottom of burning option the wood and gives room for ash to accumulate. -
Page 16: Maintenance
To clean the logs, be sure the fire is out, the gas supply effects of weather and environmental pollutants (see your local Cal Flame dealer for details). is turned off and the logs are cool to the touch. The soot can then be brushed of with a dry bristle brush or cloth. -
Page 17: Appendix
Appendix Appendix Replacement Parts Call 1-800-CAL-SPAS for any replacement parts not listed below. Be sure to have model name and number available. Fireplace Parts BBQ04103080 1/40 HP Submersible Recirculating Pump PLU21500290 3/8” Clear Flex Tubing BBQ04100621 Gas Log Burner Assembly (NG) 24” BBQ04100751 Gas Log Burner Assembly (LP) 24”... -
Page 18: Specifications
Fireplace Fuel Max . Input Firepit Model Fuel Max . Input Model BTU/Hr BTU/Hr Natural gas orifice 55,000 Natural Gas FRP-1000, (Celtic/Milan/ 77,000 1500, 2000, Campfire/ size: .125 3000, 3100 Russo/Sahara) 10” Dia. Burner Propane orifice 55,000 FRP-1000, 1500, 2000, size: #43 (0 .089) -
Page 19: Fireplace And Fire Pit Warranty
Appendix 2008 Fireplace and Fire Pit Warranty See your Cal Flame dealer for a copy of the applicable • The use of components not supplied with the warranty, details and any questions you may have appliance regarding the warranty coverage on your fire pit or The use of fuel other than those specified •... - Page 20 Locating the product serial number The serial number of your Cal Flame fireplace or firepit is located on a metal plate on the back of the unit. You will need this number to properly register your product and activate coverage. Write this information in the space provided below.
Need help?
Do you have a question about the FRP-1000 and is the answer not in the manual?
Questions and answers