Page 1
Motorcycle Operating Manual Model: WY50QT-7A PREFACE Thanks for your purchasing the motorcycle WY50QT-7A, and sincerely welcome you to be our motorcycle user. To enjoy a more safe and pleasurable driving, at first please familiarity with the manual must carry on before driving.
IMPORTANT INFORMATION Ÿ Driver and passenger This motorcycle was only used to one driver. Never exceed to the Max load capacity of the motorcycle. Ÿ For the safety, never drive to the motorcycle in the atrocious weather or the cold weather(under -12℃) Ÿ...
Ⅰ. Motorcycle safety driving Rules for safety driving Only Driver can insure the motorcycle driving safety 1.The motorcycle happen the many accidents, all reasons are that the car drivers didn’t look at the motorcycle drivers. So the motorcycle drivers must: l Put up the coat in bright color l Avoid to the driving at night .you must drive on guard and carefully to the strong light.
Speedometer and indicator (Fig3-1 or FIG3-2) ⑴Fuel Meter ⑵Turning signal light LH ⑶EngineTachometer ⑷Turning signal light RH ⑸Speedometer ⑹Odometer ⑺ main beam indicator ⑻Oil indicator light Note: Machine Meter is available(See fig3-1) Fig 3-1 Fig 3-2 Ignition Switch(Fig4) ⑴On ( when the switch turn to this position, )—...
Page 6
Main beam switch (1)(Fig 7) ”button,is main beam;Press“ ”button isdipped beam。 Press“ Turning signal light switch (2)(Fig 7) When the switches on ( ) ,the left turning signal light turn on. When the switch on ( ) , the right turning signal light turn on, Press it down the light turn off.
Ⅲ. Operation instruction Checking before driving For safety and prevent trouble or accident, Pre-check up is necessary. Fuel When the pointer or fuel meter is close to red section, replenish oil; meanwhile, check the Fuel Tank and Carburetor rack or not. Fuel Tank:6L •...
Page 8
Free Path of Rear Brake( Drum Brake)(Fig 14,Fig15) Measure the distance of rear brake pedal before detent function .the free path should between 10-20mm, take the tail of brake handle as standard. • Adjust Nut: (A)Reduce Free Path。 (B)Increase Free Path When adjust, the Pin 2 and Adjust Nut1 should impinge on Note: Rear Disk brake is available, but can’t adjust Free Path.
Page 9
Tire Check the tire pressure regularly and adjust. • Check before the tire cooled • Check if there any metal trash or gravel in the groove of tires • Inspect whether there is nick, embed nail or other tartness object on the tread or not. Inspect whether there is impress, dent or distortion for rim or not.
Driving motorcycle: WARNING: Wear the trousers to avoid touching with exhaust pipe and was burnt. The entire device must be installed according to requirement of the traffic rule. • Take the license to riding. NOTICE: Control the speed and load during 1000km of running in period. Load should be within 75kg(including driver) If take more weight and speed will reduce life of engine.
slippery road. Must use two-brake system for avoiding accident. Engine power off operation (Fig 20, Fig 21) Turn off Throttle: Revolve to the lowest place according to picture. (Normal situation is loose the throttle grip, and the engine is idling speed) •...
Page 12
Periodic Maintenance Chart(Chart 3) When you will make the Periodic Maintenance, you should inspect before driving.(Ref P9) I:Inspect and adjust when necessary C:Clean R:Replace Chart 3 Cycle Speedometer(×1000km) Item Page Every Month ﹡ Fuel Pipe ﹡ Throttle operation Air filter element ﹡...
Simple trouble solution Chart 4 Complaint Symptom and possible causes solution Damaged spark plug Replace Damaged Ignition Coil Replace Plug not Defective CDI Replace sparking Defective ignition switch Replace Renegade or loosely Ignition system Connect well or tighten Adjust Spark plug gap too small or big Spark Replace plug is...
Cleaning Air Filter(Fig 22) • Take apart the bolt of air filter cover. • Take out filter element • Compress air or use dry brush to clean filter element. 。 • Do the above opposite to reinstall the air filter. NOTICE: Fig 22 •...
Replacing gearbox oil (Fig 26) Suggestion gearbox oil : SAE 80W/90(North Cold Area use anti-freezing oil) Oil container Resolving capacity :0.11L Replacing capacity :0.09L • Make the motorcycle on the Stand • Take apart the immiting bolt (2), and the spilling bolt (1). NOTICE: The engine must be warmer when spilling and the vehicle must be steady by main Fig26...
Ⅴ.Vehicle storage Storage For store up the motorcycle for a long period of time, for example, in wintertime, some steps should be taken to prevent malfunction of and damage to its components, which might be caused by long storage. Besides, before the long storage, proper maintenance has to be carried out for fear that it might be forgotten when vehicle is put back into use after storage.
Page 17
Ⅷ.MAIN PARAMETER Chart 5 Item Parameter Item Parameter Front tyre 120/70-12 L×W×H mm 1983×683×1110 Wheelbase mm 1380 Rear tyre 120/70-12 Ground Clearance mm Air Pressure, Fr tyre 150kPa Dry weight kg Air Pressure, Rr tyre 200kPa Max Load kg Transmission system Turning angle of steering ≤48°...
- 31 - Ⅹ.Emission Control System Warranty Statement Wangye USA Co., LLC is pleased to explain the emission control system warranty on Highway Motorcycle. New Highway Motorcycle must be designed, built and equipped to regulations and standards of the United States Environmental Protection Agency and the California Air Resource Board and free from defects in material and workmanship that may keep it from these requirements in the all applicable regulations.
Page 19
Wangye USA, and the above warranty constitutes your sole remedy and the full liability of Wangye USA. In no event shall Wangye USA be liable for special, incidental or consequential damages howsoever caused, whether by negligence or otherwise resulting directly or indirectly from the use of the Motorcycle, or the Motorcycle’s...