Dometic RM2351 Installation & Operating Instructions Manual
Dometic refrigerators installation & operating instructions
Hide thumbs
Also See for RM2351:
- Installation instructions manual (54 pages) ,
- Diagnostic service manual (34 pages) ,
- Operating instructions manual (28 pages)
Table of Contents
Advertisement
RM2351
RM2554
RM2354
DM2652
RM2451
DM2662
RM2454
DM2663
RM2551
DM2852
FOR YOUR SAFETY
If you smell gas:
1. Open windows.
2. Don't touch electrical switches.
3. Extinguish any open fl ame.
4. Immediately call your gas supplier.
FOR YOUR SAFETY
Do not store or use gasoline or other
fl ammable vapors and liquids in the
vicinity of this or any other appliance.
WARNING
WARNING
!
Improper installation, adjustment, altera-
tion, service or maintenance can cause
injury or property damage. Refer to this
manual. For assistance or additional infor-
mation consult a qualifi ed installer, serv-
ice agency or the gas supplier.
825129301-0833
USA
Service Offi ce
Dometic, LLC
2320 Industrial Pkwy.
Elkhart, IN 46516
Phone: 574-294-2511
825129301
(French 825129351)
©2006-2008 Dometic, LLC
LaGrange, IN 46761
DM2862
DM3862
NDM1062
NDR1292
Corporate Offi ce
2320 Industrial Parkway Elkhart, IN 46515
For Service Center Assistance
Call: 800-544-4881
INSTALLATION
OPERATING
INSTRUCTIONS
POUR VOTRE SÉCURITÉ
Si vous sentez une odeur de gaz:
1. Ouvrez les fenêtres.
2. Ne touchez à aucun interrupteur.
3. Éteignez toute fl amme nue.
4. Avertissez immédiatement votre
fournisseur de gaz.
POUR VOTRE SÉCURITÉ
Ne pas entreposer ni utiliser de l'essence
ni d'autres vapeurs ou liquides infl amma-
bles à proximité de cet appareil ou de tout
autre appareil.
AVERTISSEMENT
!
Une installation, un réglage, une modifi -
cation, une réparation ou un entretien non
conforme aux normes peut entraîner des
blessures ou des dommages matériels.
Lisez attentivement le mode d'emploi
fourni avec l'appareil. Pour obtenir de
l'aide ou des renseignements supplémen-
taires, consultez un installateur ou un
service d'entretien qualifi é ou le fournis-
seur de gaz.
CANADA
Dometic, LLC
48 Zatonski, Unit 3
Brantford, ON N3T 5L8
CANADA
Phone: 519-720-9578
&
MO-M 0833
Advertisement
Table of Contents
Related Manuals for Dometic RM2351
Summary of Contents for Dometic RM2351
- Page 1 Dometic, LLC Dometic, LLC 48 Zatonski, Unit 3 2320 Industrial Pkwy. Brantford, ON N3T 5L8 Elkhart, IN 46516 For Service Center Assistance CANADA Phone: 574-294-2511 Call: 800-544-4881 Phone: 519-720-9578 825129301 MO-M 0833 (French 825129351) ©2006-2008 Dometic, LLC LaGrange, IN 46761...
-
Page 2: Table Of Contents
Please, when the refrigerator is not in use as a recreational device, turn the system off and open the door(s). This manual describes how to install, operate and care for the following refrigerator models: RM2351, RM2354, RM2451, RM2454, RM2551, RM2554, DM2652/DM2652 (with optional fan), DM2662, DM2663, DM2852/DM2852 (with optional fan), DM2862/DM2862 (with optional fan), DM3862, NDM1062/NDM1062 (with ice maker) and NDR1292. -
Page 3: Installation Instructions
Components Part no. to separate the combustion system from the living space of the mobile home or recreational vehicle. Openings for air supply RM2351 Roof Base 3103633.XXX* or 3310893.XXX* or for venting of combustion products should have a minimum RM2354 Roof Cover 3103634.XXX* or 3310894.XXX*... - Page 4 Side (K) the refrigerator. Bottom (L) Rear (M 0 / 1 Minimum ventilation heights (RM2351 & RM2354) Roof vent and Upper and lower The distance between the rearmost part of the refrigerator and the wall lower side vent side vent behind it.
- Page 5 Dimensions Overall Recess Model Height A Width B Depth C Height H Width W Depth D 30-5/32 21-7/8 22-22/32 29-3/4 20-1/2 21-3/8 inches RM2351 RM2354 37-3/8 24-7/8 24-11/16 39-9/16 23-11/16 inches RM2451 RM2454 43-1/2 24-7/8 24-11/16 42-5/8 23-11/16 inches RM2551...
-
Page 6: Installation Procedure
Make sure the fl oor is solid and level. enclosure with screws (not included). • The refrigerator must be level and installed in a substantial RM2351 & RM2354 enclosure. Install the fi ve screws in the following order: • Do not install the appliance directly on carpeting. Carpet- ing must be removed or protected by a metal or wood panel Four screws installed through the front frame. - Page 7 INSTALLATION PROCEDURE One screw installed in the rear base. RM2451, RM2454, RM2551, RM2554, DM2652, DM2662, DM2663, DM2852, DM2862, DM3862 & NDM1062 Install the screws in the following order: Two screws installed through the front base. (Installation of the lower front strip.) The refrigerator is provided with a lower front strip (shipped as a loose part).
-
Page 8: Drain Water Hose
If not, the water. installer will have to supply the extra length of hose. WARNING RM2351 & RM2354 EXPLOSION HAZARD. Never use an open fl ame to check for gas leaks. Failure to heed this warning could cause an explosion resulting in death or severe personal injury. -
Page 9: Electrical Connection
Allow the burner to operate for a minimum of fi ve system. However, 12V DC must be supplied to operate the minutes. controls. RM2351, RM2451, RM2551, DM2652 & DM2852 RM2354, RM2454, RM2554, DM2662, DM2663, DM2862, DM3862 & NDM1062: These refrigerator models require a... -
Page 10: Door Mounting Instructions
Secure the decoration strip with the PANEL DIMENSIONS screws removed in step 2. max. thickness 5/32" (4 mm) Height Width UPPER 15-27/32 15-25/32 20-3/4 20-5/8 inch LOWER /SINGLE DOOR RM2351 RM2354 26-17/64 26-3/16 19-5/8 19-17/32 inch RM2451 RM2454 DM2652 DM2662 32-9/16 32-1/2 20-3/4 20-5/8... -
Page 11: Refrigerator Removal
DOOR MOUNTING INSTRUCTIONS Snap in To mount the panel, follow these steps: Open the door 90 degrees. On new refrigerators, the decoration strip are taped inside the door; if installed on the door, remove the door decoration strip (2) by gently pushing the four tabs away with a fl... -
Page 12: Operating Instructions
GAS mode needs to be leveled only so it is comfortable to live in (no no- RM2351, RM2451, RM2551, DM2652 & DM2852: ticeable sloping of fl oor or walls). When operating in GAS mode, the AUTO mode Any time the vehicle is parked for several hours with the refrig- indicator lamp will be off. -
Page 13: Control Panel
Turn it off when a charging source is not available. control system will continue to operate the cooling system. LOW AMBIENT CONTROL RM2351, RM2451, RM2551, DM2652 & DM2852 RM2351, RM2451, RM2551, DM2652 & DM2852 If the control can not read the temperature sensor and control DM3862, NDM1062 &... - Page 14 REFRIGERATOR OVERVIEW RM2354, RM2454, RM2554 & DM2663 ON/OFF button (main power) mode selector button AUTO/GAS mode selector button selector button Temperature COLDEST AUTO COLD mode indicator lamp CHECK mode indicator lamp mode indicator lamp mode indicator lamp AUTO CHECK indicator lamp (GAS mode only) Temperature indicator lamps...
-
Page 15: Instructions For Use
The DC lamp will then be turned off. illuminate. If necessary, adjust the thermostat by pressing the Temperature selector button. AUTO COLD 5 COLDEST (RM2351, RM2451, RM2551, DM2652 & CHECK DM2852 The temperature is controlled by a factory preset temperature setting.) - 15 -... -
Page 16: Using The Ice Maker
INSTRUCTIONS FOR USE The following information, “ ”, is only USING THE ICE MAKER Adjusting the size of cubes NDM1062 NDM1062 valid for refrigerator model equipped with ice maker. The fi rst container of ice cubes should be dumped if the water system has been winterized or not used for several weeks. -
Page 17: Storage Compartments
RM2351, RM2454, RM2554, DM2662, DM2663, DM2862, RM2351, RM2454, RM2554, DM2662, DM2663, DM2862, DM3862, NDM1062 & NDR1292 DM3862, NDM1062 & NDR1292... - Page 18 STORAGE COMPARTMENTS REMOVING AND REPLACING THE SHELVES Slide the wire shelf to the left. Put a screwdriver into the slot of the shelf The right-hand side of the shelf will come lock. Turn the screwdriver counter clockwise. loose. Remove the shelf locks from the wire shelf. Lower the right-hand side of the wire shelf Insert the ends of the wire shelf on the and let the left-hand side slide out of the holes...
-
Page 19: Product Care
PRODUCT CARE DEFROSTING Draining the ice maker Shut off the refrigerator by pressing the main power If the RV is in storage and the refrigerator or the DC power is ON/OFF button (OFF position). turned “OFF” there will be no 12V DC present to operate the heat tape;... -
Page 20: Airing Position Card
PRODUCT CARE Turn the gear counterclockwise, when the hold REPLACING THE HALOGEN LAMP switch closes, the mold assembly will continue to operate through the harvest cycle. During the DM3862 & NDM1062 DM3862 & NDM1062 water fi ll sequence of the harvest cycle the com- pressed air will blow out the water trapped in the CAUTION solenoid valve. -
Page 21: Maintenance & Service
If your refrigerator stops cooling, immediately once a year, inspect the connections, the control turn the refrigerator off and see a Dometic system, the LP gas pressure and fl ue baffl e. The service and maintenance described in this dealer. -
Page 22: Periodic Maintenance
MAINTENANCE & SERVICE Remove the wire and fl ue baffl e from the top of the PERIODIC MAINTENANCE fl ue tube. Checking the control system Using a fl ue brush, clean the fl ue from the top. Blow- ing compressed air into the fl ue will not properly Check the control system by connecting/disconnecting the clean soot and scale out of the fl... -
Page 23: Troubleshooting
If you run into a problem, refer to the troubleshooting table below. Symptom Check/Remedial action • Immediately turn the refrigerator off and see a Dometic dealer. The refrigerator has stopped cooling. • Is the plug fi rmly connected to the socket? Is the socket switched on? Refrigerator or freezer is not Check the socket by plugging in another appliance. -
Page 24: Appendix A - Spare Parts
APPENDIX A - SPARE PARTS The following table displays commonly used parts which should be available from your Dometic Service Center. MODEL RM2351 RM2354 RM2451 RM2454 RM2551 RM2554 DM2652 SPARE PARTS Airing position card 3850781-01 N.A. N.A. N.A. N.A. N.A. - Page 25 APPENDIX A - SPARE PARTS MODEL DM2662 DM2663 DM2852 DM2862 DM3862 NDM1062 NDR1292 SPARE PARTS Airing position card 3850781-01 3850781-01 3850781-01 3850781-01 N.A. N.A. N.A. Baffl e 2932667-03/9 2932667-03/9 2932667-04/7 2932667-04/7 2932667-04/7 2932667-04/7 2932667-05/4 Bottle holder, 2 pieces N.A. N.A. N.A.
-
Page 26: Appendix B - Consumer Support
Service and spare parts For service, please contact the Service Center Assistance, see the front page of this manual - or - visit the Dometic website to fi nd the location of the nearest Dometic Service Center. -
Page 27: Appendix C - Dometic Warranty & Maintenance Schedule
RV Refrigerator. Enclosed you will fi nd important warranty and maintenance information on Dometic’s exclusive three (3) year warranty. Please take a few moments and familiarize yourself with the program. We at Dometic appreciate your business and are confi dent that you will have many years of trouble-free RV enjoyment. - Page 28 In order to obtain the benefi ts of this warranty, the original purchaser must return the product which is found defective to the Seller named below or to a Dometic Authorized Service Center during the period that this warranty is in effect. The original purchaser is responsible for all charges incurred in delivery of the product to the Seller or Dometic Authorized Service Center, and in pick up after the warranty service has been completed.
- Page 29 REFRIGERATOR OWNER MAINTENANCE YEARLY RECORD Date: Date: Dealership: Dealership: Address: Address: City: City: State: Zip: State: Zip: Phone: Phone: Technician: Technician: Cleaned Burner Assembly: Yes / No Cleaned Burner Assembly: Yes / No Cleaned/Check All Terminals Connections: Yes / No Cleaned/Check All Terminals Connections: Yes / No Cleaned/Inspect All Ground Connections:...
-
Page 30: Appendix D - Rearview Equipment
APPENDIX D - REARVIEW EQUIPMENT RM2351 Heater Flue baffle Drain water hose Power module cover Protection cover Screw for protection cover Burner jet 12 V DC Manual gas shutoff valve Terminal block Inlet fitting Flexible cord RM2354 Heaters Relay Flue baffle... - Page 31 APPENDIX D - REARVIEW EQUIPMENT RM2451, RM2454, RM2551 & RM2554 Heater Relay, 3-way only Flue baffle Power module cover Protection cover 12V DC Screw for protection cover Burner jet 12 volt Terminal block Manual gas shutoff valve Inlet fitting Flexible cord Drain water hose DM2652, DM2662, DM2663, DM2852, DM2862, DM3862 &...
- Page 32 APPENDIX D - REARVIEW EQUIPMENT NDM1062 (WITH ICE MAKER) Heater Relay Thermofuse Power Flue baffl e module cover Protection cover 12V DC Flexible cord Manual gas shutoff valve Burner jet Thermostat Flexible cord Inlet fi tting 12V DC (Ice maker) Terminal block Drain water hose NDR1292...
-
Page 33: Appendix E - Wiring Diagrams
APPENDIX E - WIRING DIAGRAMS RM2351, RM2451 & RM2551 RM2354, RM2454 & RM2554 - 33 -... - Page 34 APPENDIX E - WIRING DIAGRAMS DM2652, DM2662, DM2852 & DM2862 3 8 5 1 3 9 8 G R E E N P 1 1 P 3 4 O R A N G E P 1 4 P 3 3 B L U E P 1 2 R E D...
- Page 35 APPENDIX E - WIRING DIAGRAMS DM2663 3 8 5 1 3 9 9 G R E E N P 1 1 P 3 4 O R A N G E P 1 4 P 3 3 B L U E P 1 2 R E D P 3 2...
- Page 36 APPENDIX E - WIRING DIAGRAMS NDM1062 MODEL EQUIPPED WITH STAINLESS STEEL DOORS 3 8 5 1 4 0 4 G R E E N P 1 1 O R A N G E P 3 4 P 1 4 P 3 3 B L U E P 1 2 R E D...
- Page 37 APPENDIX E - WIRING DIAGRAMS NDM1062 MODEL EQUIPPED WITH DOOR INSERT PANELS 3 8 5 1 4 0 5 G R E E N P 1 1 O R A N G E P 3 4 P 1 4 P 3 3 B L U E P 1 2 P 3 2...
- Page 38 APPENDIX E - WIRING DIAGRAMS NDR1292 MODEL EQUIPPED WITH STAINLESS STEEL DOORS 3 8 5 1 3 3 0 G R E E N P 1 1 P 3 4 O R A N G E P 1 4 P 3 3 B L U E P 1 2 P 3 2...
- Page 39 PROTECTION FOR YOUR NEW INVESTMENT We truly appreciate that you have chosen to purchase a Dometic product for your recreational vehicle and we want to help you protect this wise investment. We at Dometic back our products with one of the most comprehensive warranties in the industry.
- Page 40 Registering your product is an essential step to ensure that you receive all the benefi ts you are Registering y your produ entitled to as a DOMETIC customer. Complete the information below and mail to us or register entitled to as a DOME on-line at www.edometic.com.