Model:HWD1000 Automatic Drum Washing Machine Automatic Drum Washing Machine Service Manual Suited model: HWD1000 Features wd-8888-99 Sense the temperature in drum while drying, stop when clothes dry Adjustable washing time LED display Memory the habit washing process in CUSTOM program Serial Number: SMHWD1000-1 Version:00.00...
Model:HWD1000 Automatic Drum Washing Machine PRODUCT CODE ILLUMINATION AND SERIES INTRODUCTION Model code rule description Model identification 1000 A Serial code B Max spin speed Page 2...
Model:HWD1000 Automatic Drum Washing Machine FEATURES Selling Point Dry clothes intelligently and stop automatically when clothes are dry. Benefits Intelligent drying Automatic washing program Washing load selecting automatically Technical Supports Automatic moisture sensing for the clothes and stop of operation when the laundry is dried, saving energy and trouble.
Model:HWD1000 Automatic Drum Washing Machine SPECIFICATION Proposal 2006 New Sensor HWD1000 Automatic Drum Washer and Dryer Product identification Washer and Dryer Description of appliance Type of appliance (FS = standing, BI = built-in) Supplier own brand Supplier bar code 688057394381...
Model:HWD1000 Automatic Drum Washing Machine Delay timer (from - to) Self cleaning suds pump Water inlet hose Water drain hose Adjustable feet n° Safety systems Auto door lock Motor overheating protection No heating without water Auto water cool-down (before drain 80°C boiled water)
Page 7
Automatic Drum Washing Machine Model:HWD1000 The appliance must be positioned so that the plug is accessible. Used new hose-sets and that old-sets should not be reused. Page 6...
Model:HWD1000 Automatic Drum Washing Machine Error Display and Troubleshooting HWD1000 Error message:The required water level is not reached within 8 min Troubleshooting: Check if water is leaking from washer Readjust or replace the broken parts bottom. inlet pipe. drain pipe or other...
Model:HWD1000 Automatic Drum Washing Machine Error message:Drainage error, water not emptied within 5 min. Troubleshooting: Check if water is emptied Check if water level pressure switch is undamaged. Check if drain pump acts by touching Check if drain pump or...
Page 22
Model:HWD1000 Automatic Drum Washing Machine Error message. Motor overheat protection or is damaged. Troubleshooting: Cut off power and check if motor wires Reconnect well are connected well Pull out the wire connection of motor Then check if circuit is open by multimeter...
Page 23
Model:HWD1000 Automatic Drum Washing Machine Error message: The water level sensor circuit short cut or open Troubleshooting: Check if the wire of water levle sensor Connect well is connected properly Check if the water levle sensor Replace it is damaged...
Model:HWD1000 Automatic Drum Washing Machine The dry temperature sensor short cut or open. Error message: Troubleshooting: Check if the dry temperature sensor Connect well is connected properly Check if the dry temperature sensor Replace it is short cut or open Replace display board Error message:Door is not properly shut 20s after program is started.
Page 25
Model:HWD1000 Automatic Drum Washing Machine Error message:Spin losidedly Troubleshooting: You can disperse the clothings evently in the tub and restart the SPIN program. Error message: Unclose the door before start program Troubleshooting: Close the door properly Error message: The memory function is failure...
Model:HWD1000 Automatic Drum Washing Machine HWD1000 Examination & Troubleshooting Failure:Display nothing Troubleshooting: Repair power supply Measure the power supply ,is it exists 120V AC voltage Press the power switch Is power switch on? Press power switch and check the voltage Make sure power supply cable assembly is between two pins of power switch.
Page 27
Model:HWD1000 Automatic Drum Washing Machine Failure:no draining Troubleshooting: Adjust the height of drain pipe to Is the height of drain pipe too high? 80-100 cm Turn filter anticlockwise open and check if Clean and tighten filter clockwise. filter is jammed...
Model:HWD1000 Automatic Drum Washing Machine Failure:water leaking Troubleshooting: Check if water is leaking from the inlet pipe Readjust it. or the tap Replace drain pipe Is drain pipe broken Remove clothes Check if there is foreign material nipped between cushion of sight window and...