UAZ -31512 Instruction Manual
  1. Manuals
  2. Brands
  3. UAZ Manuals
  4. Automobile
  5. UAZ-31512
  6. Instruction manual

UAZ -31512 Instruction Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Open Joint-Stock Company
"Ulyanovsky Avtomobilny Zavod"
AUTOMOBILES
ÓÀÇ-31512,
ÓÀÇ-31514,
ÓÀÇ-31519,
ÓÀÇ-3153
AND THEIR MODI.ICATIONS

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the UAZ-31512 and is the answer not in the manual?

Questions and answers

Related Manuals for UAZ UAZ-31512

Summary of Contents for UAZ UAZ-31512

  • Page 1 Open Joint-Stock Company "Ulyanovsky Avtomobilny Zavod" AUTOMOBILES ÓÀÇ-31512, ÓÀÇ-31514, ÓÀÇ-31519, ÓÀÇ-3153 AND THEIR MODI.ICATIONS...
  • Page 3 IMPORTANT! To ensure trouble-free operation of the automobiles, we recommended that You should attentively familiarize yourself with the present publication and follow all the operating and mainte- nance instructions laid down therein. You can trust the maintenance of your automobile to one of the service stations recommended by the Sellers.
  • Page 4 and when riding under hard service conditions (at heavy loads and a high crankshaft speed) independing on ambient temperature. 3. Shift the gearbox in the reverse gear and shift the transfer case to low range only when the automobile is stationary 4.
  • Page 5 INTRODUCTION AUTOMOBILE MARKING The identity number of the automobile The nameplate "Identification Data" The body number The chassis number The engine number...
  • Page 6 Note.
  • Page 7 Note.
  • Page 11 SPECI.ICATIONS GENERAL DATA...
  • Page 12 ENGINE...
  • Page 13 POWER TRAIN CHASSIS...
  • Page 14 CONTROL SYSTEMS ELECTRICAL EQUIPMENT...
  • Page 15 ADJUSTMENT DATA Tyre Inflation Pressure, kPA (kgf/cm...
  • Page 16 .ILLING CAPACITIES, l CONTROLS AND INSTRUMENTS...
  • Page 21 It is not allowed to switch the ignition and remove the key out of the ignition switch during motion. The engine stop furthers the loss of the braking effect, and when the ignition key is removed out, the steering gear shaft is locked by means of the antithief device, and the automobile could be not steered.
  • Page 24 Safety Belts...
  • Page 26 PRESTARTING PROCEDURE AUTOMOBILE RUNNING-IN During the running-in period, observe the following rules: STARTING AND SHUTTING DOWN THE ENGINE Starting the Engine...
  • Page 27 Starting from Cold at 0 °Ñ and Above. Starting from Cold at Temperature Below - 20 °Ñ. Starting from Cold at Temperature Below - 20 °Ñ. Starting from Hot.
  • Page 28 Shutting down the engine .EATURES O. DRIVING UNDER DI..ERENT ROAD, METEOROLOGICAL AND CLIMATIC SERVICE CONDITIONS We recommend to shift in the second gear for starting the automobile away from rest on level sections of roads or on down- grades. In other cases, shift in the first gear for starting away from rest.
  • Page 29 Overcoming Steep Up-Grades and Down-Grades. Overcoming Gutters, Roadside Cuvettes and Ditches. Moving Along Muddy Country Roads and Graded Clay and Gumbo Roads.
  • Page 30 Marsh-Ridden Sections of Roads. Sandy Soils. .ording.
  • Page 31 Snowy Surfaces MAINTENANCE O. THE AUTOMOBILE...
  • Page 32 Before the Summer Season of Operation Before the Winter Season of Operation...
  • Page 34 Valve gear.
  • Page 35 Maintenance of the Lubrication System...
  • Page 37 Immediately stop running the engine if some faults in the engine lubrication system are detected. Maintenance of the Crankcase Ventilation System...
  • Page 38 Maintenance of the .uel System .uel tanks. .uel filter-settler. .uel pump. .ine fuel filter Carburettor...
  • Page 39 Maintenance of the carburettor...
  • Page 40 Air cleaner. Inlet manifold.
  • Page 41 Accelerator pedal.
  • Page 42 Maintenance of the Engine Cooling System...
  • Page 45 Drain coolant from the cooling system Notes. Maintenance of the Ignition System...
  • Page 46 .or setting the ignition timing, proceed as follows:...
  • Page 48 Note .orbided Maintenance of the Clutch...
  • Page 50 Maintenance of the Gearbox...
  • Page 51 Maintenance of the Transfer Box Maintenance of the Propeller Shafts...
  • Page 52 Maintenance of the Rear Axle Maintenance of the .ront Axle...
  • Page 53 Never engage the front axle when the front wheels are disengaged. Towing Hook...
  • Page 56 Suspension...
  • Page 60 Never operate the automobile provided with the spring suspen- sion when the shock absorber is faulty or when there is no shock absorber on the automobile.
  • Page 61 Wheels, Tyres...
  • Page 63 Wheel Hubs...
  • Page 65 Steering gear...
  • Page 67 à -steering column with antitheft device and with switches located under steering wheel; á -steering column modification (double-coupling) 1 -steering mechanism; 2 -bushing; 3 -joint; 4, 21 -spring washers; 5 -bolt; 6, 24 -nuts; 7 -steering column shaft; 8 -circlip; 9 -protective ring;...
  • Page 68 A prolonged operation of the automobile with the non- operating hydraulic steering booster would cause preliminary wear of the steering mechanism Belt tension of the hydraulic steering booster pump drive. Checking oil level and changing oil in hydraulic steering booster.
  • Page 69 µ Note. Maintenance of the by-pass and safety valves.
  • Page 70 Brake System...
  • Page 72 .ig. 68. Pressure Regulator: .ig. 69. Pressure Governor Control Linkage: 1 -pressure governor; 2 -bracket(base); 3 -control linkage lever; 4 -adjusting bolt; 5 -toggle; 6 -lever strut...
  • Page 73 the brake pedal free trave .ill the brake hydraulic system in the following sequence:...
  • Page 76 Maintenance of the Parking Brake...
  • Page 77 Do not allowed ELECTRICAL EQUIPMENT Maintenance of the Alternator...
  • Page 79 Maintenance of the Storage Battery...
  • Page 80 Specific gravity of electrolyte reduced to 25 °C, g/cm Maintenance of the Starter...
  • Page 81 Warnings: Lighting System, Light .lashers and Horn Maintenance of the headlamps Adjust the fog lamps...
  • Page 82 .ront headlamps, rear lamps, backing lamp, side turn indica- tor repeaters, rear fog lamp. License plate lamp.

  • Page 83: Turn Indicators

    Maintenance of the horn Turn indicators. Overload Breakers Automobiles ÓÀÇ-31512, ÓÀÇ-31514, ÓÀÇ-31519: ¹1 - turn indicators, backing lamp; ¹2 - driving controls, light flashers ¹3 - turn indicators in emergency warning mode, horn; Automobile ÓÀÇ-3153: ¹1 - heater motor, backing lamp; ¹2 - turn indicators, driving controls, light flashers, upper and lower beam lamp relay ¹3 - turn indicators in emergency warning mode, horn...
  • Page 84 Instrumentation and Warning .lashers Maintenance of the devices...
  • Page 85 SPECIAL TOOLS AND APPLIANCES .ill the gun with grease in the following sequence:...
  • Page 86 The Jack .or jacking up the wheel, proceed as follows:...
  • Page 87 Maintenance of the jack BODY The locks locked up from inside by means of the handles 2 are not unlocked from outside.
  • Page 88 To disassemble the tarpaulin, proceed as follows:...
  • Page 90 Body Heating and Ventilation...
  • Page 91 Windshield Wiper and Water Pump (Windshield Washer) Windshield wiper.
  • Page 92 Washer...
  • Page 93 Maintenance of the Body LUBRICATION O. AUTOMOBILE...
  • Page 94 In the process of lubrication, adhere to the following rules: PRESERVATION...
  • Page 95 Maintenance of Automobile Placed in Storage...
  • Page 96 Depreservation TRANSPORTATION...
  • Page 98 LUBRICATING MATERIALS AND SPECIAL .LUIDS Motor Oils Transmission Oils Lubricant Grease .luids...
  • Page 100 LUBRICATION TABLE Motor Oils...
  • Page 101 Transmission Oils Lubricant Grease...
  • Page 104 .luids Note.
  • Page 105 LAMPS EMPLOYED ON AUTOMOBILES...
  • Page 106 TORQUES .OR MAIN THREADED CONNECTIONS, kgfƒm Note.
  • Page 107 MAIN METERING JETS O. CARBURETTORS Ê-151Â AND Ê-151Å Notes.
  • Page 108 CONTENTS...
  • Page 110 .OR NOTES...
  • Page 111 .ig. 1. Wiring Diagram of Automobile ÓÀÇ-31512: 1 -front lamp; 2 -headlamp; 3 -fog lamp; 4 -horn; 6-fog lamp; 7-headlamp; 8-alternator; 9-oil emergency pressure transmitter; 10-oil pressure transmitter; 11-coolant temperature transmitter; 12-coolant emergency temperature transmitter; 13-16-spark plug; 17-pickup-distributor; 18-starter; 19-electric washer; 20-storage battery; 22-ground switch; 22-microswitch; 23-solenoid valve; 24-carburettor solenoid valve;...
  • Page 112 .ig. 2. Wiring Diagram of Automobiles ÓÀÇ-31514, ÓÀÇ-31519: 1 -front lamp; 2-headlamp; 3-fog lamp; 4-horn; 6-fog lamp; 7-headlamp; 8-alternator; 9-oil emergency pressure transmitter; 10-oil pressure transmitter; 11- coolant temperature transmitter; 12-coolant emergency temperature transmitter; 13, 14-headlamp switch relay; 15-18-spark plug; 19-pickup-distributor; 20-starter; 21-electric washer; 22-storage battery; 23-ground switch; 24-microswitch; 25-solenoid valve;...
  • Page 113 .ig. 3. Wiring Diagram of Automobile ÓÀÇ-3153: 1-front lamp; 2-headlamp; 3-fog lamp; 4-horn; 6-fog lamp; 7-headlamp; 8-alternator; 9-oil emergency pressure transmitter; 10-oil pressure transmitter; 11-coolant temperature transmitter; 12-coolant emergency temperature transmitter; 13-16-spark plug; 17-pickup-distributor; 18-starter; 19-electric washer; 20-storage battery; 21-ground switch; 22-microswitch; 23-solenoid valve;...

This manual is also suitable for:

Uaz-31514Uaz-31519Uaz-3153

Table of Contents

Save PDF