A Guide To Safe And Lasting Batteries; Maintenance - TGA Vita Operating Instructions And Owner's Handbook

12. For the best results and to prolong battery life, try to run the battery down by at least 50% before recharging
and in addition it is always best to go through a complete charge cycle each time.
13. Depending on the depth of the discharge, the minimum time taken to recharge serviceable batteries fully will
vary up to 12 hours. Please note that this time may increase as batteries get older. During periods without use
(perhaps during the winter) it is wise to charge the batteries every 4 to 6 weeks.
14. For the best results your batteries must be cycled for their first 10-15 charges. This means run them down as
much as you safely can in use and then give them a full charge. They will not work at their best until this process
has been carried out. It can also prolong battery life.
You will find that the distance that your Vita can travel will gradually increase over the first few weeks of use as
the batteries reach their optimum efficiency after approximately 12 cycles of discharge and recharge. NB When
the charger is plugged into Vita an automatic inhibit device will shut down the scooter stopping anything being
used whilst plugged into the charger.
Care! Warning
* Do not smoke or use a naked flame while your batteries are being charged.
* Do not use the charger if it has received a sharp blow, been dropped or otherwise misused in any way. Take it to
a qualified technician.
* Do not dismantle the charger. This will void the warranty.
* Do not leave charger plugged into your Vita with charger switched off as this may discharge your batteries.
* For a complete charge – Do not switch off, unplug or interrupt the recharge cycle until the charging cycle has
completed.

11. A GUIDE TO SAFE AND LASTING BATTERIES

* For longest life, your batteries should be recharged after reasonable use.
* If your Vita is not used for a period of time, a refreshing charge should be given every 4-6 weeks. Never leave
your batteries in a discharged condition. This is particularity important to sealed batteries such as the type in your
Vita.
* If your Vita is to be stored away for some time, make sure the batteries are fully charged before storing. Fully
charge the batteries before re-using it.
* Every six months, check the connections on the batteries, making sure they are tight and clean.
Batteries carry a limited warranty from the original manufacturer, which is subject to a stringent
wear and tear clause. Any battery faults due to a defect by the original manufacturer will normally
become obvious within the first two months. Any gradual deterioration in performance after this
period is normally associated with fair wear and tear; misuse or accidental damage is not covered by
the manufacturer's warranty.

12. MAINTENANCE

We recommend that the Vita has an annual service and maintenance check by your Vita Dealer or TGA Ltd. This is
very important and can help to avoid breakdowns. The following are weekly/monthly checks that will keep the
machine in good running order.
• Do not apply oil or grease to any components. Sealed bearings and nylon bushes eliminate the need for
lubrication.
• Keep all components clean and dry.
• Keep tyres inflated to 32 psi. Low tyre pressure will degrade performance so it is very important to check
pressure frequently.
• Check tyres for wear. Replace as soon as there is any sign of excessive wear.
• The Vita uses maintenance free batteries, they are leak-proof regardless of position. Charging the battery is the
only maintenance required (refer to charging instructions). DO NOT leave the batteries flat, charge every 4-6
weeks if the Vita is being stored and not used.
• Check the electrical cable connectors are fully home and secure.
• Battery Replacement is dependent upon use, the batteries generally last up to 3 years. When batteries lose
power too quickly, it is likely they are due for replacement. If there is no dealer in your area, you may want to
10