Toner Cartridge - Brother HL-1230 Service Manual

CHAPTER 5 PERIODIC MAINTENANCE
(4) Install the toner cartridge into the new
(5) Install the new drum unit into the printer.
(6) Press the control panel button until all the LEDs are on. (The LED turns on in sequence
(7) Close the front cover, and check that the Drum LED is now off.
!
• For best performance, use only genuine Brother toner. The product should only be used in
a clean, dust-free environment with adequate ventilation..
• Only unpack a drum unit immediately before you need to install it into the printer. If an
unpacked drum unit is subjected to excessive direct sunlight or room light, the unit may be
damaged.
• Handle the drum unit and toner cartridge carefully. If toner scatters on your hands or
clothes, wipe or wash it off with cold water immediately.
• Do not reset the page counter when replacing the toner cartridge only.
1.2

Toner Cartridge

Toner low:
Toner empty:
Life expectancy:
NOTE:
There are many factors that determine the actual toner life, such as temperature, humidity,
type of paper that you use, the number of pages per print job, etc.
<Replacement Procedure>
(1) Open the front cover, and pull out the
(2) Place the drum unit containing the old
(3) Unpack the new toner cartridge, and
Download Free Service Manual and Resetter Printer at http://printer1.blogspot.com
drum unit until it locks into place,
indicated by a click. When the toner
cartridge is installed correctly, the lock
lever is lifted automatically. (Fig. 5-2)
Check that the printer is turned on, the
front cover is open and the Drum and
Alarm LEDs illuminate.
from top to bottom.) The drum page counter is
CAUTION:
The Data and Alarm LEDs blink once every five seconds.
The Data and Alarm LEDs blink once every second.
3,000 pages/standard toner cartridge
6,000 pages/high-capacity toner cartridge
(When printing A4- or Letter-size paper at 5% print coverage)
drum unit from the printer.
toner cartridge on a flat, horizontal
surface, and remove the toner cartridge
from the drum unit while pushing the
lock lever down with your right hand.
gently rock it from side to side 5 or 6
times keeping it horizontal. (Fig. 5-3)
reset.
5-2
Fig. 5-2
Fig. 5-3