Related Manuals for Jenn-Air 38”
Summary of Contents for Jenn-Air 38”
- Page 1 Jenn-Air Stainless Steel Grill: 38” Model USE AND CARE MANUAL FOR OUTDOOR USE ONLY MADE IN THE USA Jenn-Air is a registered trademark of the Maytag Corporation and is used under license to Lowe’s Companies Inc.
-
Page 2: Table Of Contents
TABLE OF CONTENTS GENERAL SAFETY INSTRUCTIONS.............2 GRILL FEATURES....................3 GRILL COMPONENTS LIST................4 INSTALLATION / ASSEMBLY................5-7 GAS REQUIREMENTS..................8-9 LEAK TESTING....................10 USING THE GRILL...................11-14 Lighting the Grill...................12 Rotisserie Usage..................13-14 CARE & MAINTENANCE................15 TROUBLE SHOOTING..................16-17 WARRANTY......................18 Please record Grill information for future reference and service work: Model #: Serial #: Date of Purchase:... -
Page 3: General Safety Instructions
GENERAL SAFETY INSTRUCTIONS IMPORTANT SAFETY INFORMATION - Read this manual carefully before using your grill to reduce the risk of fire, burn hazard or other injury. - Extreme care should be used because of the high temperatures produced by this appliance. CHILDREN SHOULD NOT BE LEFT UNATTENDED IN AN AREA WHERE THE GRILL IS BEING OPERATED. -
Page 4: Grill Features
GRILL FEATURES: JA38 Roll top grill hood Handle Grilling/Cooking surface Warming shelf Side Shelf Infrared back burner Control knob: back infrared burner Electronic ignitor: main & rear infrared burners Control knobs: main burners Cart w/door Convection vents Ignitor access opening... -
Page 5: Grill Components List
GRILL COMPONENTS LIST Cart Parts L-shaped side pieces U-shaped back side piece Base Wheel channels Cart Door Parts Door with handle Magnetic door catch Nylon bushing Nylon shoulder washer Hex head screws Grill Parts Stainless steel grill head Stainless steel side shelves Electronic ignitor (pre-installed on grill) Flavor grids Porcelain cooking grates... -
Page 6: Installation / Assembly
INSTALLATION / ASSEMBLY Note: Prior to assembly remove protective film from stainless steel parts Cart Assembly Attach the two L-shaped sides to the U- shaped back portion of the cart, making sure Screws the four holes face up & the key holes are on the bottom, using the (8) self taping hex Fig. - Page 7 INSTALLATION / ASSEMBLY Attaching Grill Head to Cart w/door (cont.) Have someone help you pick up the grill and set it on the top of the cart, with the front of the grill above the door opening. Make Fig. 5 back sure the 4 bolt heads fall through the large set of...
- Page 8 INSTALLATION / ASSEMBLY Side Shelves Attachment Attach the shelves to each side of grill by inserting the shelf hooks into the slots on the Fig. 7 side of the grill and pushing down on the shelf assembly until level with grill. (See Fig. 7) Lock the shelves in place by inserting (2) self taping screws into each shelf.
-
Page 9: Gas Requirements
GAS REQUIREMENTS General Information Verify the type of gas supply to be used, either Natural Gas (NG) or Liquid Propane (L.P)., and make sure the marking plate (located on the back of the unit) agrees with that of the supply. Note: Never attach an unregulated gas line to the appliance. - Page 10 GAS REQUIREMENTS L.P. Gas Installation Jenn-Air Gas Grills that are set to operate with L.P. gas come with a high capacity hose and regulator assembly. This assembly is designed to connect directly to a standard 20 lb. L.P. cylinder. Attach the gas hose assembly to the brass 3/8 flared fitting on the under side of the grill. Tighten securely and attach other end to the propane tank.
-
Page 11: Leak Testing
LEAK TESTING General Information Although all gas connections on the grill are leaked tested at the factory prior to shipment, a complete gas tightness check must be performed at the installation site due to possible mishandling in shipment, or excessive pressure unknowingly being applied to the unit. Periodically check the whole system for leaks, or immediately check if the smell of gas is detected. -
Page 12: Using The Grill
USING THE GRILL Grill Location Do not use the grill in garages, breezeway, sheds or any enclosed area. Never operate the grill in enclosed areas as this could lead to a carbon monoxide buildup, which could result in injury or death. Place the grill on a level surface. -
Page 13: Lighting The Grill
LIGHTING THE GRILL Before Lighting Warning: Important! Before Lighting... Check the gas supply line for cuts, wear or abrasion. Always keep your face and body as far away from the Do not attempt to grill as possible when lighting. “Light” the grill if the odor of gas is present!! Grill Burner Lighting Lighting the Grill with electronic ignitor... -
Page 14: Rotisserie Usage
USING THE ROTISSERIE BURNER (Optional ROTISSERIE KIT for use with Back Infrared Burner must be purchased separately) The grill rotisserie system is designed to cook items from the back using infrared heat. The rotisserie burner is an infrared type which provides intense searing radiant heat. Preferred by chefs over other cooking methods, this intense heat is magnificent for searing in the natural juices and nutrients found in quality cuts of meats. - Page 15 USING THE ROTISSERIE BURNER Rotisserie Lighting Open the lid. Push and turn the control knob counter clockwise to the “HIGH” position. Wait 5 seconds. Then press and hold the electronic ignitor button. You’ll hear a snapping sound. If the burner does not light in 4 seconds, turn the control knob to OFF and wait 5 minutes before trying again.
-
Page 16: Care & Maintenance
CARE and MAINTENANCE Drip Tray The drip tray located below the grill, inside the cart, should be cleaned periodically to prevent heavy buildup of debris. Note: Allow the drip tray to cool before attempting to clean. Cooking Grates The cooking grates can be cleaned immediately after cooking is completed and after turning off the flame. Wear a barbecue mitt and scrub the cooking grates with a damp cloth. -
Page 17: Trouble Shooting
TROUBLE SHOOTING General Trouble Shooting You should inspect the burners at least once a year or immediately if any of the following conditions occur: The smell of gas in conjunction with the burner flames appearing yellow. The Grill does not reach temperature. The burners make a popping noise. - Page 18 TROUBLE SHOOTING Problem Solution Check gas connection. Flame is erratic Fuel level may be low. Grill may be in need of cleaning. Check flavor grids and cooking grates for excess build-up. Flare-Ups Ensure Grill is not placed directly in path of wind.
-
Page 19: Warranty
If you have other questions about your Jenn-Air grill, please contact: Sure Heat Customer Service Hotline (800) 229-5647 Because of continuing product improvement these specifications are subject to change without notice. 11/2002 Jenn-Air is a registered trademark of the Maytag Corporation and is used under license to Lowe’s Companies Inc.