Table of Contents
Advertisement
Quick Links
See also:
Owner's Manual
Owners Manual
Manual del Usuario
Model No.
233000
U.S. Patent Number: 6,6102,031; 6,470,877;
Hong Kong Patent Number: 1108587.1;
All Other Foreign Patents May Apply.
For Outdoor Use Only
(Outside any enclosure)
Solamente Para Uso En
Exteriores
(Fuera de cualquier recinto)
Improper installation,
adjustment, alteration,
service or maintenance
can cause injury or property
damage. Read the installation,
operation and maintenance
instructions thoroughly before
installing or servicing this
equipment.
WARNING
FOR YOUR SAFETY
WARNING
FOR YOUR SAFETY
Advertisement
Table of Contents
Related Manuals for Endless Summer 233000
Summary of Contents for Endless Summer 233000
- Page 1 Owners Manual Manual del Usuario Model No. 233000 U.S. Patent Number: 6,6102,031; 6,470,877; Hong Kong Patent Number: 1108587.1; All Other Foreign Patents May Apply. WARNING FOR YOUR SAFETY For Outdoor Use Only (Outside any enclosure) Solamente Para Uso En Exteriores...
- Page 2 Do not store or use gasoline from areas where flammable or other flammable vapors or liquids, gasoline, vapors, or liquids in the vicinity of this or explosives are stored or used. any other appliance. Owner’s manual: model 233000 outdoor patio heater 7/13/04...
-
Page 3: Table Of Contents
Storage and Handling of Liquid Petroleum Gases, ANSI/NFPA 58 or CSA B149.1, manual to him or her to Natural Gas and Propane Installation Code. save for future reference. Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 4: Safety First
(approximately 45 minutes after use). Notice: This product should not be used with any fuel other than liquid propane. Use of other fuels will detract from heaters performance and will void your warranty. Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 5: For Your Safety
For your nearest Blue Rhino retailer visit • Do not clean heater with combustible or corrosive cleaners. Use warm, www.bluerhino.com. soapy water. • Do not paint engine, engine access panel or dome. Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 6: Component Listing & Hardware
Legs (3) ..56-01-193 Finial 56-01-103 Base ..56-01-196 Allen Wrench Weight Plate . . . 56-01-198 56-01-215 Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 7: Assembly Instructions
Secure Legs to Base using (2) Small Bolts, (2) Small Lock Washers and (2) Small Nuts per leg. Finger tighten only. Do not fully tighten until Step 2. Attach small ‘S’ hook on Tank Restraint Chain to left leg. Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 8: Step 2 Attach Platform To Legs
Insert Carriage Bolt through center holes of Base and Plate. Using 9/16” wrench, secure Plate to Base using (1) Large Lock Washer and (1) Large Nut. Place Base Assembly upright. Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 9: Step 4 Insert Gas Line Through Platform / Attach Shroud Cover
Insert (4) Small Screws enough to hold Engine in place. They will be fully tightened at the end of Step 7. Note: Do not replace Engine Access Panel until Step 13. Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 10: Step 6 Attach Engine/Post To Platform
Gently tug on line to test for proper connection. If Gas Line moves it is not properly connected. Do not proceed until you have a proper connection. Fully tighten the (4) screws from Step 5. Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 11: Step 8 Assemble Dome
Gently lay heater on its side using one styrofoam end to prop up top half. Align holes in Dome with threaded studs in Emitter brackets. Secure Dome to Emitter using (3) Cap Nuts. Leave Heater on its side for next step. Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 12: Step 10 Secure Gas Line
Note: Be careful not to kink flexible hose of Gas Line. for leaks even if your unit was • Secure tank in place by attaching loose end of Tank Restraint Chain to assembled for you at the store. hole in right leg. Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 13: Step 12 Check For Leaks
• Release Gas Line fitting from Tank valve and re-attach making sure connection is secure (see Step 12). • If you continue to see bubbles after several attempts, contact 1-800-762-1142 for assistance. • Turn Tank Valve OFF. Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 14: Step 13 Replace Engine Access Panel
• Install (1) AA battery. Negative end of battery goes in first. • Replace battery cover cap by turning cap clockwise. Note: Once you have successfully completed assembly steps 1-14 you are ready to begin operating your heater. Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 15: Operation
• Release Control Knob after 30 seconds. Pilot Light will remain lit. If not, return to step 1. • Turn Control Knob to ON. Main Burner will light immediately. Flame is HIGH HIGH visible through Viewing Hole. If not, return to step 1. Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 16: Re-Lighting
Handle with extreme care. clockwise to OFF. Turn Tank Valve clockwise to OFF and disconnect Regulator when heater is not in use. Note: After use, some discoloration of the emitter screen is normal. Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 17: Operation Checklist
After Operation q Gas control is in OFF position. q Gas tank valve is OFF q Disconnect Gas line. q Heater is upright in a secure location. Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 18: Troubleshooting
Heater is level Clean burner Dirt or film on reflector and emitter Clean reflector and emitter Carbon build-up Blockage in burner Remove blockage and clean burner Thick black smoke inside and outside Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 19: Maintenance
Frequently check for corroded areas and repair them promptly. TIP: Use high-quality automobile wax to help maintain the appearance of your heater. Apply to exterior surfaces from the pole down. Do not apply to emitter screen or domes. Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 20: Storage
Caution: Use only original equipment replacement parts. Use of unauthorized parts or modification of parts will void warranty and create an unsafe condition. Caution: Always allow heater to cool before attempting service. Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 21: Warranty
Vendor. Blue Rhino Global Sourcing, LLC 104 Cambridge Plaza Drive Winston-Salem, North Carolina 27104 USA (800) 762-1142 24 Hour Fax: (336) 659-6743 CustomerService@BlueRhino.com Owner’s manual: model 233000 outdoor patio heater 7/13/04... -
Page 22: Specifications
Maximum – 150 PSI Minimum – 5 PSI Manifold Pressure: 11.00 in. W.C. Engine: IPP E8 Safety Features: 100% Burner shut-off Tilt Switch Manufacturer: Blue Rhino Global Sourcing, LLC Made In: China Owner’s manual: model 233000 outdoor patio heater 7/13/04...