1. Manuals
  2. Brands
  3. Parkinson Cowan Manuals
  4. Cookers
  5. DSIG 320
  6. Operating and installation instructions

Parkinson Cowan DSIG 320 Operating And Installation Instructions

Gas cooker
Hide thumbs Also See for DSIG 320:
Table of Contents

Advertisement

Quick Links

Download this manual
DSIG 320
Operating
and
Installation Instructions

Advertisement

Table of Contents
loading

Related Manuals for Parkinson Cowan DSIG 320

Summary of Contents for Parkinson Cowan DSIG 320

  • Page 1 DSIG 320 Operating Installation Instructions...

  • Page 2: For Your Safety

    D S I G 3 2 0 t i o Introduction This gas appliance has been designed and manufactured to all the necessary British Standards. It also carries the C.E. mark. The appliance complies with European Council Directive 90/396/EEC. It is important that you understand how to use and care for the appliance properly before you use it for the first time.

  • Page 3: Table Of Contents

    D S I G 3 2 0 Contents Page Lighting the appliance The grill The hotplate The oven Oven cooking chart Slow cooking Care and cleaning Installing the appliance General information What is wrong and why? Servicing Installation instructions Technical data Safety requirements/ventilation Location of appliance Testing...

  • Page 4: Lighting The Appliance

    D S I G 3 2 0 Lighting the appliance The ignition system works by means of a battery. Details on how to replace the battery are given on page 27. Hotplate To light 1 Lift up the lid. You cannot use the hotplate when the lid is down. 2 Push in the control knob and turn to the large flame symbol (highest setting), and press the ignition button immediately.
  • Page 5 D S I G 3 2 0 Grill To light: 1 Push in the control knob and turn it to the large flame symbol (highest setting), and press the ignition button. When the burner has lit release the button. 2. Adjust setting as required. For your safety Never cover the grill pan or grid with foil as this can lead to grill fires.

  • Page 6: To Turn Off Any Burner

    D S I G 3 2 0 To turn off any burner 1 Push in the control knob and turn it to the off position. This is shown by a large dot. For your safety When you are lighting any burner check that it has lit before you leave the appliance.

  • Page 7: The Grill

    D S I G 3 2 0 The grill The grill is a high-speed grill. The instructions below tell you how to vary the heat setting and how to change the height of the grid to suit the food you are cooking. You should remember to turn the food regularly. You should not use the grill to keep food warm as it will continue to cook the food.
  • Page 8 D S I G 3 2 0 General When you are not using the grill you should remove the handle and store the pan on the shelf in the grill. Turn the grill burner off before you store the pan. Remember that the pan will get hot when you are using the oven.

  • Page 9: The Grill Pan And Handle

    D S I G 3 2 0 The grill pan and handle The grill pan is supplied with a removable handle. To attach the handle, place the wirework under the cut out in the pan so that the metal plate hooks over the top of the grill pan. Slide the handle to the left and over the central bump on the grill pan.

  • Page 10: The Hotplate

    D S I G 3 2 0 The hotplate You can only use the hotplate when the lid is open. If you have any trouble lighting a hotplate burner turn all hotplate control knobs off and make sure the hotplate burner parts have been replaced correctly. See page 21 for more information.
  • Page 11 D S I G 3 2 0 For your safety Take care to avoid burns and scalds when you are reaching across the hotplate. Use pans with flat bases. They are more stable than pans which are warped. Do not use pans with very heavy handles which cause the pan to tip.

  • Page 12: Helpful Hints

    D S I G 3 2 0 Helpful hints Keep flames under the base of the pans. If the flames lick round the sides of the pans you are wasting gas. Only heat the amount of liquid you need. Do not overfill pans.

  • Page 13: The Oven

    D S I G 3 2 0 The oven Before you use the oven you should wipe it out with a damp cloth to remove any dust. Heat zones There are zones of heat within the oven. The temperature in the middle is the gas mark you have chosen.
  • Page 14 D S I G 3 2 0 Baking trays and dishes For your safety Never place cooking dishes, trays and so on over the oven burners. This will damage the appliance as well as the cookware and possibly the floor covering underneath the appliance.

  • Page 15: Oven Cooking Chart

    D S I G 3 2 0...
  • Page 16 D S I G 3 2 0...
  • Page 17 D S I G 3 2 0...

  • Page 18: Slow Cooking

    D S I G 3 2 0 Slow cooking The slow cook setting gives a very low heat in the oven. It is particularly useful when cooking soups, stews and casseroles because the long slow cooking will make cheaper, tougher cuts of meat more tender.

  • Page 19: Frozen Foods

    D S I G 3 2 0 Soups, casseroles and stews Do not cook casseroles over 2.7kg (6lb). Bring to the boil on the hotplate then cook on slow cook. Cook in the middle of the oven or above. Cover food with a tight fitting lid or tin foil. Vegetables Cut into small pieces.

  • Page 20: Care And Cleaning

    D S I G 3 2 0 For your safety For hygiene and safety reasons you must keep this gas appliance clean. A build up of fat or other foodstuff could cause a fire. Try to mop up spills and splashes as soon as they happen. But be careful as parts of the appliance will be hot.

  • Page 21: When Replacing Hotplate Burner Parts

    D S I G 3 2 0 You can wash the removable parts in very hot soapy water. You may use mild abrasives. Make sure that the electrode and the hole and slots in the crown are not blocked with food or cleaning materials. Clean the burner crowns by soaking them in very hot soapy water.
  • Page 22 D S I G 3 2 0 The oven The top, sides and back of your oven are coated in a special material which helps to keep itself clean. Follow these simple rules to maintain the appearance of the special finish.

  • Page 23: Oven Cleaning Cycle

    D S I G 3 2 0 Oven cleaning cycle You need to follow the cycle to keep the inside of the oven in good condition. The type of cooking you do will affect how often you need to follow the cycle. If you do a lot of roasting and very little other baking you should follow the cleaning cycle once a week.

  • Page 24: Cleaning Between The Outer And Inner Door Glass

    D S I G 3 2 0 Cleaning between the outer and inner door glass You can remove the glass from the oven door if you need to. To remove the outer glass 1 Open the oven door so you can get at the two cross head screws on the top of the oven door.

  • Page 25: Installing The Appliance

    D S I G 3 2 0 Cleaning The Door Glass To prevent damaging or weakening the door glass panels avoid the use of the following: Household detergents and bleaches Impregnated pads unsuitable for non-stick saucepans Brillo/Ajax pads or steel wool pads Chemical oven pads or aerosols Rust removers Bath/Sink stain removers...
  • Page 26 D S I G 3 2 0 Positioning The diagram shows how close to the appliance cupboards, shelves, curtains and so on can be fitted. Check the diagram and carefully read the instructions to make sure your appliance is fitted safely. If you are in doubt your installer will give you advice.

  • Page 27: General Information

    D S I G 3 2 0 General information For your safety Do not block any of the appliance vents. Never line any part of the appliance with aluminium foil. Do not let items which can catch fire or electric mains leads such as kettle flexes trail over any part of the appliance.
  • Page 28 D S I G 3 2 0 For your safety Do not try to disconnect the appliance from the gas supply if the supply pipe does not have a bayonet connection, as described in the installation instruction. If this is the case contact the person who installed the appliance.

  • Page 29: What Is Wrong And Why

    D S I G 3 2 0 What is wrong and why? We strongly recommend that you carry out the following checks on your appliance before calling a Service Engineer. Problem The oven, grill or hotplate will not light. Check If only the hotplate burners will not light make sure that the burner parts have been placed correctly.

  • Page 30: Servicing

    D S I G 3 2 0 Service and spare parts In the event of your appliance requiring service or if you wish to purchase spare parts please contact your local Service Force Centre by telephoning 0 8 7 0 5 9 2 9 9 2 9 Your call will be routed to the Service Force Centre covering your postcode area.
  • Page 31 We recommend that your appliance has an annual gas safety check carried out by our approved service organisation. Customer Care Department For general enquiries concerning your Parkinson Cowan appliance or further information on products, you are invited to contact our Customer Care Department by letter or telephone as follows:...

  • Page 32: Installation Instructions

    INSTALLATION INSTRUCTIONS Serial number at front. Data badge on top rear of panel. Please note that the handle may differ in type and shape from that shown in the diagram. For your safety Where applicable Natural Gas and L.P. Gas versions of this appliance are available.

  • Page 33: Technical Data

    TECHNICAL DATA DIMENSIONS Height Width Depth Height to hotplate 900mm (nominal) 500mm (nominal) 600mm (to front of door panel) Space for fixing at hotplate level 2mm minimum clearance Space for fixing above hotplate level See important note 'Location of Appliance' page 35. Minimum space above hotplate 787mm (If a cooker hood is fitted refer to the cooker hood installation instructions).

  • Page 34: Safety Requirements/Ventilation

    IMPORTANT - SAFETY REQUIREMENTS This appliance must be installed in accordance with the Gas Safety (Installation and Use) Regulations Current Editions and the I.E.E. Wiring Regulations. Detailed recommendations are contained in the following British Standard Codes of Practice - BS.6172, BS.5440: Part 2 and B.S.6891. All British Standards must be 'Current Editions'.

  • Page 35: Location Of Appliance

    LOCATION OF APPLIANCE This appliance must not be installed in a bed-sitting room of volume less than 20m³ or in a bathroom, shower room or garage. It is essential that the appliance is positioned as stated below (see Fig. 1a) i.e. shelves, wall cabinets and cooker hoods must be fitted a minimum of 787mm directly above the top of hotplate and 400mm above the hotplate when fitted in line with the outside of the appliance.

  • Page 36: Levelling The Appliance

    INSTALLATION 1. PARTS REQUIRED The loose hotplate parts and battery are packed in the polystyrene fitment on top of the hotplate. 2. LEVELLING THE APPLIANCE Adjustable levelling feet at the front and the rear are provided on the base of the appliance. Adjustment to suit floor conditions is obtained by rotating in or out the hexagonal feet from the underside of the appliance.

  • Page 37: Testing

    4. CONNECTING TO GAS This appliance is designed to be installed with an appliance flexible connection only. Supply piping should not be less than R³/8. Connection is made to the Rc ½ (½" B.S.P.) female threaded entry pipe located just below the hotplate level on the rear left hand side of the appliance.

  • Page 38: Checking The Hotplate

    8. CHECKING THE HOTPLATE Lift the lid. Fit the burner crowns and caps ensuring that they are correctly seated. Fit the pan supports. Check each of the hotplate burners in turn by turning the hotplate tap to it's full on position and pressing the ignition button.

  • Page 39: Contents Check List

    Contents Check List Note: If you require replacements of the item listed below please contact your local Service Force Centre quoting the relevant part number. No. OFF DESCRIPTION Oven shelves P.C. Guarantee card Hotplate operation card Grill pan (311409401) Grill pan grid (311419801) Grill pan handle (311468100) Grill shelf Burner crowns...
  • Page 40 Burner Crown - Simmer 337000502 Pan Support 359033202 NOTE : Failure to use manufacturers original spares could negate normal BSI approval of the product PARKINSON COWAN 55 - 77 HIGH STREET, SLOUGH, BERKSHIRE, SL1 1DZ TELEPHONE 0870 5 950950 Part Number:311594900...

Table of Contents