Spa Maintenance - Freeflow Spas Tropic Owner's Manual

FILTER CARTRIDGE MAINTENANCE
Fusion Hot Tubs uses a screw in filter cartridge that is easily removed. When the filter cartridge is removed, make
sure no objects fall into the filter cavity. They can cause obstructions to the water movement.
Every two weeks, the filter cartridge must be cleaned to remove the objects and particles that have lodged in the
cartridge pleats. Using household water pressure and a garden hose with a pressurized nozzle, push water from
inside to outside of the pleats, forcing all the trapped particles out.
NOTE: Never run your hot tub without a filter cartridge!!! This will invalidate your warranty.
NOTE: Filter cartridges should be replaced every six to eight months or earlier when needed.
Dirty filters can cause your hot tub pump to burn out and will invalidate your warranty.
FILTER CARTRIDGE REMOVAL AND CLEANING INSTRUCTIONS
Turn off the power to the spa, and then follow directions below:
Push down slightly and turn filter basket counter clockwise to unlock, then pull the basket and
weir out.
Unscrew the filter cartridge counter clockwise and bring it out of the spa. (requires many turns)
Rinse cartridge using a garden hose. Rotate and separate filter pleats while spraying water to
remove all dirt and debris possible. Let filter dry and look for calcium deposits (scaling) or an oil
film. If you find these, you will need to deep clean your filter cartridge with a "spa filter cleaner"
solution to break down and remove unwanted deposits and oils. (For longer filter life you should
soak filter regularly.)
CAUTION! Always use proper eye protection when using chemicals, or
high-pressure water. Read instructions on cleaning products and follow
applicable safety and warning instructions listed on label.
Replace filter cartridge, then return basket and weir, insert and rotate clockwise to lock into
position. DO NOT OVERTIGHTEN! Then, turn spa's power back on.
CAUTION! Never scrub the filter cartridge with a brush, as this will cause the
filter to wear out and come apart. Never let the spa pump run without a filter cartridge
in the skimmer compartment. Running the spa without a filter cartridge may permit
debris to enter the spa plumbing and void the warranty!
SURFACE CARE
Do not use solvents or abrasive cleaners to clean the hot tub. Typically, a mild detergent and water will
resolve cleaning issues.
CAUTION! Never spray cabinet with a garden hose for any reason since this
action may induce an electrical short in the hot tubs electrical equipment.

Spa Maintenance

15