Parking Brake Adjustment; Powertrain - Bad Boy RECOIL iS Owner's Manual

Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.

Parking Brake Adjustment

The floor mounted parking brake has an adjustment knob on the end of the han-
dle. If the vehicle starts to roll when the parking brake is engaged on a hill, place
one foot on the service brake pedal, turn the adjustment knob clockwise to
increase tension on the brake, release the service brake and check to see if the
parking brake is holding, repeat the process if necessary.

POWERTRAIN

To reduce the possibility of severe injury or death from improper servicing techniques:
DO NOT attempt any type of servicing operations before reading all notes, cautions and warn-
ings in this manual.
Never depress the accelerator pedal with drive wheels off the ground.
Any servicing requiring adjustments to be made to the powertrain while the motor is running
must be made with all four drive wheels raised and vehicle properly supported on jack stands.
To reduce the possibility of motor damage, never operate vehicle at full throttle for more than 4
- 5 seconds while vehicle is in a 'no load' condition.
Reduce the possibility of accidental starting by disconnecting battery at negative terminal
before servicing.
Wear eye protection when working on the vehicle. Use extra care when work-
ing around batteries, or using solvents or compressed air.
To reduce the possibility of causing an electrical arc, which could result in a
battery explosion, turn off all electrical loads from the battery before removing
battery wires.
Wrap wrenches with vinyl tape to reduce the possibility of a dropped wrench
'shorting out' a battery, which could result in an explosion.
The electrolyte in a battery is an acid solution which can cause severe burns to
the skin and eyes. Treat all electrolyte spills to the body and eyes with extended
flushing with clear water. Contact a physician immediately.
Any electrolyte spills should be neutralized with a solution of 2 teaspoons (10 ml) sodium bicar-
bonate (baking soda) dissolved in 1 quart (1 liters) of water and flushed with water.
Aerosol containers of battery terminal protectant must be used with extreme care. Insulate metal
container to reduce the possibility of can contacting battery terminals which could result in an
explosion.
It is in the best interest of both vehicle owner and service technician to carefully follow the procedures recommended in
this manual. Preventative maintenance, applied at recommended intervals, is the best guarantee for keeping the vehicle
both dependable and economical.
This vehicle will give years of satisfactory service, providing it receives regular maintenance. Refer to the Periodic Ser-
vice Schedule for appropriate service intervals.
To prolong vehicle life, some maintenance items must be serviced more frequently on vehicles used under severe
driving conditions such as extreme temperatures, extreme dust/debris conditions, or frequent use with maximum
MAINTENANCE
load.
5
Page 5 - 9