Bad Boy RECOIL iS Owner's Manual page 32

OPERATION
Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.
Do not attempt to pull loads exceeding the manufacturers maximum load rating.
Have all persons and pets leave the area while operating winch. Never allow anyone to remain in the vehicle.
To prevent damage to the wire cable, never hook the cable
to itself.Always use a nylon sling.
Stay clear of the winch, the cable and the cable hook. Place
a heavy cloth, jacket or blanket over the cable to act as a
damper should the cable break when operating the winch.
When operating the winch, keep the entire area in view.
Do Not Hook Cable to Itself
4
Never release the free spool clutch while the cable is under
load.
Never work around the winch drum or the winch cable while
it is under tension.
Unplug the winch switch before working on the winch drum
in order to prevent inadvertent operation.
When operating winch, take up slack slowly. Stop winch
Damper
before cable becomes tight and inspect all winching connec-
Nylon
Sling
tions. Check winch attachment, hook attachment, nylon sling
(if required) and load attachment.
Use a Nylon Sling and Install
Do not pull at an angle. This will cause the wire cable to pile
up on one end of the winch. This may jam the winch causing a Damper when Winching
damage to the cable and/or the winch. Pulling the vehicle at
an angle can cause damage to the front suspension and may cause the vehicle to overturn. When pulling vehicle, pull
straight only.
Incorrect
Correct
Do Not Pull at Angle
If the vehicle is being used as an anchor to winch a load, it should have the parking brake set and chocks installed on
all wheels.
Never use the winch to lift people or other overhead loads.
Do not use the winch to secure loads. Use a tie down designed for the job.
Do not apply shock loads to the winch.
Do not attempt to modify or weld the winch.
Page 4 - 10