Table of Contents
Advertisement
Quick Links
PLEASE READ THIS MANUAL CAREFULLY BEFORE INSTALLING AND OPERATING THE FIREPLACE
THE DELRAY MODEL 36 DRG INSERT IS C.G.A. APPROVED FOR NATURAL GAS AND PROPANE
ALWAYS RETAIN THE MANUAL WITH THE UNIT IN THE EVENT OF A CHANGE OF OWNERSHIP
IF YOU SMELL GAS:
1.) OPEN WINDOWS
2.) DO NOT TOUCH ELECTRICAL SWITCHES
3.) EXTINGUISH ANY OPEN FLAME
4.) IMMEDIATELY CALL YOUR GAS SUPPLIER
FOR INSTALLATION IN ACCORDANCE WITH CANADIAN REQUIREMENTS
CERTIFIED TO STANDARD: CAN/CGA 2.22 - M86 VENTED DECORATIVE APPLIANCE
CANADIAN HEATING PRODUCTS INC
13120 - 76TH AVENUE, SURREY B.C. V3W 2V6
PHONE (604) 597-3115
09/96
INSTALLATION, OPERATION AND MAINTENANCE MANUAL
MODEL 36DRG
APPROVED AS A GRAVITY VENTED ROOM HEATER
FOR YOUR SAFETY:
CAN/CGA 2.17 - M91 HIGH ALTITUDE
CAN/CGA 2.1 - M86 ROOM HEATER
FAX: (604) 597-3096
DO NOT STORE OR USE ANY
FLAMMABLE VAPOURS OR LIQUIDS
NEAR THIS OR ANY OTHER GAS-
BURNING APPLIANCE.
Page 1 of 11
36DRG
Advertisement
Table of Contents
Related Manuals for DelRay 36DRG
Summary of Contents for DelRay 36DRG
-
Page 1: For Your Safety
INSTALLATION, OPERATION AND MAINTENANCE MANUAL MODEL 36DRG PLEASE READ THIS MANUAL CAREFULLY BEFORE INSTALLING AND OPERATING THE FIREPLACE THE DELRAY MODEL 36 DRG INSERT IS C.G.A. APPROVED FOR NATURAL GAS AND PROPANE ALWAYS RETAIN THE MANUAL WITH THE UNIT IN THE EVENT OF A CHANGE OF OWNERSHIP... -
Page 2: General Instructions
The fireplace is not intended to be used as a substitute for a furnace to heat an entire home. Use for supplemental heating only. The DelRay Gasfire 36DRG is rated at 28,000 BTUH for Natural Gas and 27,000 BTUH for Propane. 1./ COMBUSTION AIR A.) In open rooms of normal construction (without... - Page 3 36DRG Offset Box. Installation For proper installation, the use of a 4 inch (100 mm) instructions for this offset box are included with the diameter gas approved chimney liner is needed.
-
Page 4: Insert Installation
Secure the flex liner to the flue Decorative Hood collar with a minimum of 2 sheet metal screws. Flex Liner Remove to pull out heat exchanger. DRAWING #3a Flue Collar DRAWING #4 Page 4 of 11 09/96 36DRG... -
Page 5: Fan Bracket
Plug: 18 Ga (CSA), moulded plug direct wire to grounded 120V supply. Fuse: 2 Amp; buss type or equivalent Pilot Burner & Ignitor: Robertshaw 5SHL2 Page 5 of 11 09/96 36DRG... - Page 6 Mount the front piece of glass on the brackets Provided underneath the decorative hood piece. Glowing Embers 16.) Ember Placement: Distribute evenly alongside the front burner only. Do not pile material directly on top of burner DRAWING #9c ports. Page 6 of 11 09/96 36DRG...
-
Page 7: Operation
On/Off Switch Pilot Adjustment be kept clean. Any safety guards removed for on Backplate servicing this appliance must be replaced prior to operating the appliance. DRAWING #10 PILOT BURNER ADJUSTMENT 3/8" to 1/2" Page 7 of 11 DRAWING #11 09/96 36DRG... -
Page 8: Troubleshooting
Severe Downdraft Check combustion air supply source of energy causing a the appliance. negative condition within the home. Page 8 of 11 09/96 36DRG... - Page 9 NOTE: THIS GUIDE IS MERELY A MEANS OF IDENTIFYING THE PROBLEM AND ITS PROBABLE CAUSE. REPAIRS SHOULD BE DONE BY A QUALIFIED SERVICE PERSON. ALL PARTS ARE AVAILABLE FROM CANADIAN HEATING PRODUCTS INC. OR YOUR LOCAL DEALER/DISTRIBUTOR. Page 9 of 11 09/96 36DRG...
-
Page 10: Parts Description
5. Compression Nut 13. CHP-005 Bulk Head Union 6. 1621410 3500125C CH-1 Compression Spring 14. Flexible Metal Connector 7. 3/4" ID Flat Washer 15. 81-4N Pilot Nut 8. Silicon Sponge Seal 16. Robertshaw 5SHL2 Page 10 of 11 09/96 36DRG... - Page 11 The Companies warrants the Montigo Gas Appliance to be free from defects in materials and workmanship at the time of manufacture. On the Montigo, there is a ten-year warranty on the firebox and its components, a five-year warranty on the main burner, pilot burner and a one-year warranty on the gas control valve and glass doors.
Need help?
Do you have a question about the 36DRG and is the answer not in the manual?
Questions and answers