Starting Generator - Honeywell HW7000EH Owner's Manual

Starting Generator

Starting Generator
Thoroughly read and understand all information
provided in this Owner's Manual before operating
generator.
NOTICE
It is very important to maintain proper level of engine oil to
keep engine in good running condition.
• Check engine oil level prior to each use.
Starting generator with appliances connected can cause
permanent damage to appliances.
• NEVER start generator with electrical appliances
plugged in and turned on.
Electric Start
1. Place generator outside in a well-ventilated area.
NOTICE
Keep the generator at a minimum of 6 feet (2 meters) from
any building, object, or wall.
Confirm the circuit breakers are set.
2.
FIGURE 19: Circuit Breaker Position
Turn fuel shut-off valve to the ON position.
3.
FIGURE 20: Fuel Shut-off Valve — ON/OFF Position
Pull choke control to the ON position.
4.
ON
FIGURE 21: Choke Control
16 www.honeywellgenerators.com
OFF
5. Press and hold engine control switch in START posi-
tion until engine starts.
FIGURE 22: Engine Control Switch
NOTICE
If engine will not start, move the choke to the OFF posi-
tion to reduce fuel to the engine.
NOTICE
• Holding engine control switch for more than 5 seconds
can damage starter motor. If engine fails to start after 5
seconds, release engine control switch and wait 10
seconds before attempting to start engine again.
• If you notice engine cranking speed drop after a period
of time, it may be an indication the battery should be
recharged.
6. When the engine starts, release the engine control
switch allowing it to settle to the RUN (center) posi-
tion.
To avoid generator damage, NEVER press the engine con-
trol switch to the START position while generator is running.
7. As the engine warms up, and RPM stabilizes, gradu-
ally push choke control to the OFF position.
NOTE:
While engine is running, a small "trickle" charge is applied
to starting battery.This keeps an adequate battery charge.
HW7000EH Portable Electrical Generator Owner's Manual