Page 1 Windshield wiper/washer control Steering wheel adjustment Power windows Mirrors Speed control Locks and Security Keys Locks Anti-theft system Seating and Safety Restraints Seating Safety restraints Air bags Child restraints 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 2: Table Of Contents
Getting assistance outside the U.S. and Canada Ordering additional owner’s literature Reporting safety defects (U.S. only) Cleaning Maintenance and Specifications Hood Engine compartment Engine oil Battery Fuel information Part numbers Refill capacities Lubricant specifications 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 4: Introduction
State of California to cause cancer and birth defects or other reproductive harm. CONGRATULATIONS Congratulations on acquiring your new Ford. Please take the time to get well acquainted with your vehicle by reading this handbook. The more you know and understand about your vehicle the greater the safety and pleasure you will derive from driving it.
Page 5 (miles) of operation, since these additives may prevent piston ring seating. See Engine oil in the Maintenance and specifications chapter for more information on oil usage. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 6 • Ford Motor Company. • service and repair facilities. • law enforcement or government agencies. • others who may assert a right or obtain your consent to know such information. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 7 Refer to this Owner Guide for all other required information and warnings. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 8 Anti-Lock Brake System Non-Petroleum Based Traction Control AdvanceTrac Master Lighting Switch Hazard Warning Flasher Fog Lamps-Front Fuse Compartment Fuel Pump Reset Windshield Wash/Wipe Windshield Rear Window Defrost/Demist Defrost/Demist 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 9 Sparks Explosive Gas Fan Warning Maintain Correct Fluid Power Steering Fluid Level Emission System Engine Air Filter Passenger Compartment Jack Air Filter Check fuel cap Low tire warning 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 10: Instrument Cluster
Under engine misfire conditions, excessive exhaust temperatures could damage the catalytic converter, the fuel system, interior floor coverings or other vehicle components, possibly causing a fire. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 11 ON, continues to flash or remains on, have the system serviced immediately. A chime will also sound when a malfunction in the supplemental restraint system has been detected. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 12 Four wheel drive high: Illuminates when four-wheel drive high is engaged. Anti-theft system: Flashes when the Securilock Passive Anti-theft System has been activated. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 13: Gauges
GAUGES DOOR AJAR CHECK GAGE RPMx1000 SPEED CHECK CONT ENGINE HIGH CHECK km/h FUEL R N D 2 1 THEFT BRAKE Speedometer: Indicates the current vehicle speed. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 14 To reset, depress the control. Tachometer: Indicates the engine speed in revolutions per minute. Driving with your tachometer pointer continuously at the top of the scale may damage the engine. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 15 Refer to Filling the tank in the Maintenance and Specifications chapter for more information.. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 16: Entertainment Systems
4. CLK: To set the hour, press and hold CLK and press SEEK to decrease or increase hours. To set the minute, press and hold CLK and press TUNE to decrease or increase the minutes. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 17 13. Power/volume: Press to turn ON/OFF; turn to increase or decrease volume levels. 14. CD: Press to enter CD mode or to play a CD already loaded into the system. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 18 Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Ford CD players. Irregular shaped CDs, CDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should not be inserted into the CD player. The label may peel and cause the CD to become jammed.
Page 19 (4.75 in) audio compact discs only. Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Ford CD players. Irregular shaped CDs, CDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should...
Page 20 9. Clock: Press and hold to set the clock. Press the SEEK to decrease hours or SEEK increase hours. Press the TUNE 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 21 Dolby Laboratories Licensing Corporation. Dolby and the double-D symbol are registered trademarks of Dolby Laboratories Licensing Corporation. 15. Side 1–2: Works in tape mode only. Press to play reverse side of the tape. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 22 TUNE frequency down/up. 21. Seek: Press and release SEEK for previous/next strong station, selection or track. SEEK TUNE 22. AM/FM: Press to select AM/FM1/FM2 frequency band. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 23 CD unit are designed to play commercially pressed 12 cm (4.75 in) audio compact discs only. Due to technical incompatibility, certain recordable and re-recordable compact discs may not function 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 24 Entertainment Systems correctly when used in Ford CD players. Irregular shaped CDs, CDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should not be inserted into the CD player. The label may peel and cause the CD to become jammed. It is recommended that homemade CDs be identified with permanent felt tip marker rather than adhesive labels.
Page 25 • SHOW — Displays station name, station type and/or radio text. Press RDS until SHOW is displayed. CLK (Clock): Press RDS until SET HOURS is displayed. Press SEL to decrease or increase the hours. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 26: Rear Seat Controls
6. Volume: Press + to increase and — to decrease volume levels. From the rear seat controls, volume cannot be set higher than the front seat setting. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 27 • Handle discs by their edges only. Never touch the playing surface. • Inspect discs before playing. Clean only with an approved CD cleaner and wipe from the center out. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 28 Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Ford CD players. Irregular shaped CDs, CDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should not be inserted into the CD player.
Page 29: Climate Controls
• Do not put objects under the front seats that will interfere with the airflow to the back seats. • Remove any snow, ice or leaves from the air intake area at the base of the windshield. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 30 Select for air to flow through the vents located above the rear climate controls. 2. Turn the fan speed control to the desired position. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 31: Lights
Press the foglamp control to activate the foglamps. The foglamp indicator light will illuminate. When the highbeams are activated, the foglamps will not operate. Press the foglamp control again to deactivate the foglamps. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 32 Note: On some models, when the instrument panel dimmer switch is rotated all the way up (past the detent), turning on the interior dome lamp, the exterior rear cargo lamp is also turned on. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 33 The brightest part of the light should be below the horizontal line (4). If it is above the line the headlamp will need to be adjusted. 4. Open the hood. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 34 NOTE: If your vehicle is equipped with the Remote Keyless Entry feature, the courtesy lamp will remain on for 25 seconds after the door is shut or until the ignition is turned to the ON position. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 35 1. Make sure the headlamp switch is in the OFF position and open the hood. 2. Lift the headlamp cover. 3. Remove two retainer pins, then pull headlamp forward. 4. Disconnect the electrical connector. 5. Remove the bulb retaining ring. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 36 2. Remove screw from the lamp assembly. 3. Disengage lamp assembly. 4. Remove the bulb socket. 5. Carefully pull bulb straight out of the socket. Reverse steps to reinstall bulb(s). 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 37 2. Remove the bulb socket from the foglamp by turning it counterclockwise. 3. Disconnect the electrical connector. Reverse steps to reinstall bulb(s). 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 38 1. Remove the two screws and lamp assembly from vehicle. 2. Remove the bulb socket from the lamp assembly by turning counterclockwise and pull the bulb straight out. Reverse steps to reinstall bulb(s). 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 39 To replace all instrument panel lights – see your dealer. Replacing the interior bulbs Check the operation of the bulbs frequently. To replace any of the interior bulbs, see a dealer or qualified technician. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 40: Driver Controls
2. Attach the new wiper to the wiper arm and press it into place until a click is heard. 3. Replace wiper blades every 6 months for optimum performance. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 41 The use of Mobile Communications Equipment has become increasingly important in the conduct of business and personal affairs. However, drivers must not compromise their own or others’ safety when using 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 42 The storage compartment can be used to hold a variety of aftermarket garage door openers. To install your garage door opener: 1. Open the storage compartment door. 2. Remove the storage clip and stow it away. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 43 Improper use of the power outlet can cause damage not covered by your warranty. • With a full console: 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 44 Always keep the power point caps closed when not being used. Truck bed auxiliary power point An additional auxiliary power point is located in the bed of the truck. Lift the cover to access the auxiliary power point. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 45: Power Windows
Power Down Back Window To operate the power down back window, the ignition switch must be in the Run or Accessory position. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 46 The “down” command is the only one allowed after the ignition has been switched to OFF or START while the window is moving. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 47 1. Make sure the headlamp control is in the OFF position. Leaving the headlamp control on will override the autolamp. 2. Turn the ignition to the ON position or start the vehicle. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 48: Mirrors
2. Move the control in the direction you wish to tilt the mirror. 3. Return to the center position to disable the adjust function. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 49: Speed Control
The controls for using your speed control are located on the steering wheel for your convenience. 1. Press the ON control and release 2. Accelerate to the desired speed. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 50 1.6 km/h (1 mph). • Use the accelerator pedal to get to the desired speed. When the vehicle reaches that speed, press and release the SET ACC control. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 51 MOON ROOF (IF EQUIPPED) The moon roof control is located on the overhead console. Do not let children play with the moon roof. They may seriously hurt themselves. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 52 LAMP If the outside temperature drops below 4° C (38° F) the word “ICE” will flash in the display alternately with the outside temperature for approximately one minute. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 53 7 8 9 1011 • Adjusting the calibration of the compass Note: To adjust the calibration find an open area free from steel structures and high voltage lines. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 54 The tailgate lock is designed to prevent theft of the tailgate. • Insert ignition key and turn to the right to lock. • Turn ignition key to the left to unlock. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 55 10 mm rope. CARGO CAGE (IF EQUIPPED) Your vehicle may be equipped with a cargo cage designed to extend the pickup box for larger loads. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 56 2. Turn the screw counterclockwise until you hear an audible click. 3. To deactivate, turn the screw clockwise until the locking clip moves freely. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 57 The panel will automatically lock when lowered onto the pickup box. Do not drive with front panel unlocked or folded on top of the rear panel. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 58 • Pull the release levers on the underside of the tonnneau cover from the pickup box and remove the cover. For installation of the tonneau cover, reverse the removal procedure. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 59 Loaded vehicles, with a higher center of gravity, may handle differently than unloaded vehicles. Extra precautions, such as slower speeds and increased stopping distance, should be taken when driving a heavily loaded vehicle. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 60 Avoid sharp turns, excessive speed and abrupt maneuvers in these vehicles. Failure to drive cautiously could result in an increase risk of loss of vehicle control, vehicle rollover, personal injury and death. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 61: Locks And Security
Industry Canada. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) This device must accept any interference received, including interference that may cause undesired operation. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 62 Note: the interior lamps will turn off (unless the dome lamp control is in the full-up position), and the headlamps and parking lamps will flash. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 63 4. Snap the two halves back together. Note: Replacement of the battery will not cause the remote transmitter to become deprogrammed from your vehicle. The remote transmitter should operate normally after battery replacement. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 64 Note: After 20 seconds have passed, you will automatically exit the programming mode. 10. The doors will lock, then unlock, to confirm that the programming mode has been exited. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 65 If the wrong code has been entered 36 times, the keypad will go into an anti-scan mode. This mode disables the keypad for one minute and the keypad lamp will flash during this time. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 66 To deactivate/reactivate the autolock feature using the keypad Your vehicle comes with the autolock feature activated. To deactivate/reactivate this feature: 1. Turn the ignition to the OFF position. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 67 12. Exit the vehicle and ensure that the horn chirps once to indicate that a feature has been changed and that the autolock feature has been toggled. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 68 Note: The SecuriLock passive anti-theft system is not compatible with non-Ford aftermarket remote start systems. Use of these systems may result in vehicle starting problems and a loss of security protection. Note: Large metallic objects, electronic devices that are used to purchase gasoline or similar items, or a second coded key on the same key chain may cause vehicle starting issues.
Page 69 • Only use Securilock keys. • You must have two previously programmed coded keys (keys that already operate your vehicle’s engine) and the new unprogrammed key(s) readily accessible. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 70 If failure repeats, bring your vehicle to your dealer to have the new key(s) programmed. To program additional new unprogrammed key(s), repeat this procedure from step 1 for each additional key. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 71: Seating And Safety Restraints
To adjust the head restraint: • Raise the head restraint by pulling it upward. To lower the head restraint: • Push the release control. • Push down on the head restraint. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 72 Press to raise or lower the rear portion of the seat cushion. Press the control to move the seat forward, backward, up or down. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 73 Heated seats (if equipped) To operate the heated seats: • Push control to activate. • Push again to deactivate. The indicator light on the control will illuminate when activated. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 74 Folding down rear 60/40 seats 1. Raise the rear seat head restraint. 2. Flip the bottom of the head restraint up, toward the front seat. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 75 40 percent rear seat (behind the driver) does not fold due to the subwoofer location. See Attaching child safety seats with tether straps in this chapter for tether access behind this seat. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 76: Safety Restraints
Never let a passenger hold a child on his or her lap while the vehicle is moving. The passenger cannot protect the child from injury in a collision. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 77 • The front outboard safety belt system has a retractor assembly that is designed to extend the seat belt webbing in a controlled manner. This helps reduce the belt force acting on the user’s chest. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 78 8 km/h (5 mph) or more, the combination safety belts will lock to help reduce forward movement of the driver and passengers. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 79 In addition, all seat belts should be checked for proper function. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 80 Safety belt pretensioner Your vehicle is equipped with safety belt pretensioners at the driver and right front passenger seating positions. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 81 The driver’s safety belt is The safety belt warning light and buckled before the ignition indicator chime remain off. switch is turned to the ON position... 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 82 ON position... The following are reasons most often given for not wearing safety belts: (All statistics based on U.S. data) 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 83 “The people I’m with don’t Set the example, teen deaths occur 4 wear belts” times more often in vehicles with TWO or MORE people. Children and younger brothers/sisters imitate behavior they see. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 84 1. Turn the ignition switch to the RUN (or ON) position. (DO NOT START THE ENGINE) 2. Wait until the safety belt warning light turns off. (Approximately 1 minute) 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 85 (if equipped), child safety seat tether bracket assemblies (if equipped), LATCH child seat tether anchors and lower anchors (if equipped), and attaching hardware, should be inspected after 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 86: Air Bags
Seating and Safety Restraints a collision. Ford Motor Company recommends that all safety belt assemblies used in vehicles involved in a collision be replaced. However, if the collision was minor and a qualified technician finds that the belts do not show damage and continue to operate properly, they do not need to be replaced.
Page 87 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 88 Seating and Safety Restraints Do not attempt to service, repair, or modify the air bag supplemental restraint systems or its fuses. See your Ford or Lincoln Mercury dealer. Modifying or adding equipment to the front end of the vehicle (including frame, bumper, front end body structure and tow hooks) may affect the performance of the air bag system, increasing the risk of injury.
Page 89 The SRS consists of: • driver and passenger air bag modules (which include the inflators and air bags) • one or more impact and safing sensors 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 90 If any of these things happen, even intermittently, have the SRS serviced at your dealership or by a qualified technician immediately. Unless serviced, the system may not function properly in the event of a collision. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 91 Do not attempt to service, repair, or modify the Safety Canopy system, its fuses, the A, B, or C pillar trim, or the headliner on a vehicle containing a Safety Canopy . See your Ford or Lincoln Mercury dealer. All occupants of the vehicle including the driver should always...
Page 92 The Safety Canopy is mounted to roof side-rail sheet metal, behind the headliner, above the first and second row seats. In certain lateral 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 93 The SRS uses a readiness light in the instrument cluster or a tone to indicate the condition of the system. Refer to the Air bag readiness section in the Instrument Cluster chapter. Routine maintenance of the air bag is not required. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 94: Child Restraints
The passenger cannot protect the child from injury in a collision. Always follow the instructions and warnings that come with any infant or child restraint you might use. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 95 To improve the fit of lap and shoulder belts on children who have outgrown child safety seats, Ford recommends use of a belt-positioning booster seat that is labeled as conforming to all applicable Federal motor vehicle safety standards. Belt-positioning booster seats raise the child and provide a shorter, firmer seating cushion that encourages safer seating posture and better fit of lap and shoulder belts on the child.
Page 96 Both can be used in any vehicle in a seating position equipped with lap/shoulder belts if your child is over 40 lbs. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 97 Child and infant or child safety seats Use a safety seat that is recommended for the size and weight of the child. Carefully follow all of the manufacturer’s instructions with the 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 98 (passenger side front and outboard rear seating positions) (if equipped) section in this chapter. Ford recommends the use of a child safety seat having a top tether strap. Install the child safety seat in a seating position which is capable of providing a tether anchorage.
Page 99 1. Position the child safety seat in a seat with a combination lap and shoulder belt. 2. Pull down on the shoulder belt and then grasp the shoulder belt and lap belt together. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 100 6. Allow the belt to retract. The belt will click as it retracts to indicate it is in the automatic locking mode. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 101 4. Insert the tongue into the correct buckle for that seating position until you hear and feel the buckle engage. Make sure the buckle is latched securely by pulling on the webbing. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 102 For vehicles with adjustable head restraints, route the tether strap under the head restraint and between the head restraint posts, otherwise route the tether strap over the top of the seatback. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 103 Refer to the Folding Down The Rear Seats section in this chapter for information on how to operate the rear seats. 4. Slide open the tether anchor cover. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 104 For forward-facing child seats, the tether strap must also be attached to the proper tether anchor. See Attaching safety seats with tether straps in this chapter. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 105 Follow the child seat manufacturer’s instructions to properly install a child seat with LATCH attachments. Attach LATCH lower attachments of the child seat only to the anchors shown. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 106 Also try to tug the seat forward. Check to see if the anchors hold the seat in place. If the safety seat is not anchored properly, the risk of a child being injured in a crash greatly increases. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 107: Driving
Starting the engine in this chapter. Extended idling at high engine speeds can produce very high temperatures in the engine and exhaust system, creating the risk of fire or other damage. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 108 2. Make sure the headlamps and electrical accessories are off. If starting a vehicle with an automatic transmission: • Make sure the parking brake is set. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 109 Make sure the corresponding lights illuminate or illuminate briefly. If a light fails to illuminate, have the vehicle serviced. • If the driver’s safety belt is fastened, the light may not illuminate. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 110 If the engine is idling while the vehicle is stopped for a long period of time, open the windows at least 2.5 cm (one inch) or adjust the heating or air conditioning to bring in fresh air. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 111: Brakes
The ABS will be activated immediately, allowing you to retain full steering control during hard braking and on slippery surfaces. However, the ABS does not decrease stopping distance. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 112 If the steering wanders or pulls, check for: • an improperly inflated tire • uneven tire wear • loose or worn suspension components • loose or worn steering components • improper steering alignment 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 113: Transmission Operation
This vehicle is equipped with a brake-shift interlock feature that prevents the gearshift lever from being moved from P (Park) when the ignition is in the ON position unless brake pedal is depressed. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 114 If the parking brake is fully released, but the brake warning lamp remains illuminated, the brakes may not be working properly. See your dealer or a qualified service technician. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 115 N (Neutral) With the gearshift lever in N (Neutral), the vehicle can be started and is free to roll. Hold the brake pedal down while in this position. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 116 If your vehicle gets stuck in mud or snow, it may be rocked out by shifting from forward and reverse gears, stopping between shifts in a steady pattern. Press lightly on the accelerator in each gear. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 117 Do not drive with your foot resting on the clutch pedal or use the clutch pedal to hold your vehicle at a standstill while waiting on a hill. These actions will reduce the life of the clutch. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 118 Use 1 (First) gear and set the parking brake fully. Removing the key Turn the ignition off, push the release lever (located above the ignition), then turn the key toward you and remove the key. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 119 4x4 HIGH is selected. • 4WD LOW– illuminates when 4x4 LOW is selected. If these lights illuminate when driving in 2WD, contact your Ford dealer as soon as possible. Electronic shift on the fly 4WD system 2WD - Power to the rear wheels only; used for street and highway driving.
Page 120 Do not grip the spokes. Drive cautiously to avoid vehicle damage from concealed objects such as rocks and stumps. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 121 Do not rock the vehicle for more than a few minutes or damage to the transmission and tires may occur or the engine may overheat. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 122 • If the vehicle goes from one type of surface to another (i.e., from concrete to gravel) there will be a change in the way the vehicle responds to a maneuver (steering, acceleration or braking). Again, avoid these abrupt inputs. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 123 After driving through mud, clean off residue stuck to rotating driveshafts and tires. Excess mud stuck on tires and rotating driveshafts could damage driveline components. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 124 When you brake hard, the front wheels can’t turn. Rapid pumping of the brake pedal will help you slow the vehicle and still maintain steering control. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 125 Maintenance and Modifications Ford strongly recommends that you do not add or remove steering or suspension parts (such as lift kits or stabilizer bars) or by using replacement parts not equivalent to the original factory equipment. Do not use aftermarket “lift kits”...
Page 126 GCWR for the towing vehicle. • Trailer Weight Range: Specified range of trailer weight from zero to the maximum trailer weight rating. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 127 2. Weigh your vehicle without cargo. To obtain correct weights, take your vehicle to a shipping company or an inspection station for trucks. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 128 Certification label. For load specification terms found on the label, refer to Vehicle loading in this chapter. Remember to figure in the tongue load of your loaded vehicle when figuring the total weight. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 129 Vehicle loading in this chapter. Maximum trailer weights shown. The combined weight of the completed towing vehicle and the loaded trailer must not exceed the GCWR. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 130 Maximum trailer weights shown. The combined weight of the completed towing vehicle and the loaded trailer must not exceed the GCWR. Do not exceed the GVWR or the GAWR specified on the certification label. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 131 Make sure your trailer lamps conform to local and Federal regulations. See your dealer or trailer rental agency for proper instructions and equipment for hooking up trailer lamps. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 132 Driving Never connect any trailer lighting to the vehicle’s taillamp circuits, because it may damage the electrical system resulting in fire. Contact your local Ford dealership for assistance in proper trailer tow wiring installation. Additional electrical equipment may be required.
Page 133 • Turn the key in the ignition to the OFF/UNLOCKED position. • The maximum recommended speed is 88 km/h (55 mph). • The maximum recommended distance is unlimited. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 134 If a distance of 80 km (50 miles) or a speed of 56 km/h (35 mph) must be exceeded, you must disconnect the front (on 4x4 vehicles) and rear driveshafts. Ford recommends the driveshaft(s) be removed/installed only by a qualified technician. See your local dealer for driveshaft removal/installation.
Page 135: Roadside Emergencies
Roadside Emergencies Roadside Emergencies GETTING ROADSIDE ASSISTANCE To fully assist you should you have a vehicle concern, Ford Motor Company offers a complimentary roadside assistance program. This program is separate from the New Vehicle Limited Warranty. The service is available: •...
Page 136: Fuel Pump Shut-Off Switch
Roadside coverage beyond basic warranty In the United States, you may purchase additional roadside assistance coverage beyond this period through the Ford Auto Club by contacting your Ford or Lincoln Mercury dealer. Similarly in Canada, for uninterrupted Roadside Assistance coverage, you may purchase extended coverage prior to your Basic Warranty’s Roadside...
Page 137: Fuses And Relays
Replacing a blown fuse with a fuse that has a higher amperage can cause severe wire damage and could start a fire. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 138 Pull the cover outward to access the fuses. To remove a fuse, use the tool on the panel cover. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 139 Trailer tow right-hand stop/turn lamps 7.5A Starter Park lamps, Autolamps, I/P dimming, Trailer tow 7.5A Air bags, Cluster 7.5A Trailer tow left-hand stop/turn lamps 7.5A Cluster, Audio, GEM 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 140 I/P power point 7.5A Front washers Front wiper 7.5A Cluster, GEM Interior illumination, Battery saver 7.5A Audio, Windows, GEM, Moonroof, Rear window – Not used Audio, Rear audio 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 141 Note: Always replace the cover to the power distribution box before reconnecting the battery or refilling fluid reservoirs. If the battery has been disconnected and reconnected, refer to the Battery section. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 142: High-Current Fuses
Rating Fuse panel Cartridge fuse Ultimate Audio System Cartridge fuse Power down back window, Moonroof Cartridge fuse – Not used – Not used ABS pump motor Cartridge fuse 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 143 – Not used 10A Mini PCM memory fuse 15A Mini Horn fuse 20A Mini Fuel pump motor fuse 25A Mini Headlamps fuse 10A Mini A/C clutch solenoid fuse 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 144 10A Mini Right low beam fuse – Not used 2A Mini Speed control fuse – Wiper hi/low relay – Wiper run/park relay – Not used – Not used 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 145: Changing A Flat Tire
The use of tire sealants is not recommended and may compromise the integrity of your tires. Spare tire information The spare tire can be used as a spare or a regular tire. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 146: Removing The Spare Tire
(6) and the top of the lug wrench (3). Removing the spare tire 1. Assemble the jack handle with the spade end to the lug wrench as shown in the illustration. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 147: Stowing The Spare Tire
The jack handle ratchets when the tire is raised to the stowed position. It will not allow you to overtighten. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 148: To Change A Flat Tire
Pull far enough off the road to avoid the danger of being hit when operating the jack or changing the wheel. Before changing the tire: 1. Park on a level surface. 2. Activate the hazard flashers. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 149 Do not start the engine when your vehicle is on the jack. The jack is only meant for changing the tire. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 150 Roadside Emergencies • Front • Rear 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 151: Stowing The Flat/Spare Tire
The effort to turn the jack handle increases significantly and the spare tire carrier ratchets or slips when the tire is raised to the maximum tightness. Tighten to the best of your 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 152: Jump Starting
3. Park the booster vehicle close to the hood of the disabled vehicle making sure the two vehicles do not touch. Set the parking brake on both vehicles and stay clear of the engine cooling fan and other moving parts. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 153 Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2. Connect the other end of the positive (+) cable to the positive (+) terminal of the assisting battery. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 154 5. Ensure that the cables are clear of fan blades, belts, moving parts of both engines, or any fuel delivery system parts. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 155 Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2. Remove the jumper cable on the negative (-) connection of the booster vehicle’s battery. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 156 After the disabled vehicle has been started and the jumper cables removed, allow it to idle for several minutes so the engine computer can relearn its idle conditions. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 157: Wrecker Towing
Ford recommends your vehicle be towed with a wheel lift or flatbed. Do not tow with a slingbelt. Ford Motor Company has not approved a slingbelt towing procedure.
Page 158: Customer Assistance
Ford Customer Relationship Center. Away from home If you own a Ford or Mercury vehicle and are away from home when your vehicle needs service, or if you need more help than the dealership could provide, after following the steps described above, contact the Ford Customer Relationship Center to find an authorized dealership to help you.
Page 159 P.O. Box 2000 Oakville, Ontario L6J 5E4 1-800-565-3673 (FORD) www.ford.ca In order to help you service your Ford or Lincoln Mercury vehicle, please have the following information available when contacting a Customer Relationship Center: • Your telephone number (home and business).
Page 160 5,000 participating Ford or Lincoln Mercury and Ford of Canada dealers. If you did not take advantage of the Ford Extended Service Plan at the time of purchasing your vehicle, you may still be eligible. Please contact your dealer for further information. Since this information is subject to...
Page 161: The Dispute Settlement Board
THE DISPUTE SETTLEMENT BOARD (U.S. ONLY) The Dispute Settlement Board is: • an independent, third-party arbitration program for warranty disputes • available free to owners and lessees of qualifying Ford Motor Company vehicles The Dispute Settlement Board may not be available in all states. Ford...
Page 162 • The name of the dealer(s) who sold or serviced the vehicle. • A brief description of your unresolved concern. • A brief summary of the action taken by the dealer(s) and Ford Motor Company. • The names (if known) of all the people you contacted at the dealership(s).
Page 163 After a case is reviewed, the Board mails you a decision letter and a form on which to accept or reject the Board’s decision. The decisions of the Board are binding on Ford (and, in some cases, on the dealer) but not on consumers who are free to pursue other remedies available to them under state or federal law.
Page 164: Utilizing The Mediation/Arbitration
UTILIZING THE MEDIATION/ARBITRATION PROGRAM (CANADA ONLY) In those cases where you continue to feel that the efforts by Ford and the dealer to resolve a factory-related vehicle service concern have been unsatisfactory, Ford of Canada participates in an impartial third party mediation/arbitration program administered by the Canadian Motor Vehicle Arbitration Plan (CAMVAP).
Page 165: Ordering Additional Owner's Literature
If your vehicle must be serviced while you are traveling or living in Central or South America, the Caribbean, or the Middle East, contact the nearest Ford dealership. If the dealership cannot help you, write or call: FORD MOTOR COMPANY...
Page 166 In the case of 1 or 2 above, the consumer must also notify the manufacturer of the need for the repair of the nonconformity at the following address: Ford Motor Company 16800 Executive Plaza Drive Mail Drop 3NE-B Dearborn, MI 48126 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 167: Reporting Safety Defects (U.s. Only)
However, NHTSA cannot become involved in individual problems between you, your dealer, or Ford Motor Company. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1–800–424–9393 (or 366–0123 in the Washington D.C.
Page 168: Cleaning
Your dealer has touch-up paint and sprays to match your vehicle’s color. Take your color code (printed on a sticker in the driver’s door jam) to your dealer to ensure you get the correct color. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 169 • Do not use hydrofluoric acid-based or high caustic-based wheel cleaners, steel wool, fuels or strong household detergent. • To remove tar and grease, use Ford Extra Strength Tar and Road Oil Removal (B7A-19520–AA), available from your dealer. ENGINE Engines are more efficient when they are clean because grease and dirt buildup keep the engine warmer than normal.
Page 170 Use only approved products to clean plastic parts. These products are available from your dealer. • For routine cleaning, use Motorcraft Detail Wash (ZC-3–A). • If tar or grease spots are present, use Ford Extra Strength Tar and Road Oil Removal (B7A-19520–AA). WINDOWS AND WIPER BLADES The windshield, rear window and wiper blades should be cleaned regularly.
Page 171 For fabric, carpets, cloth seats and safety belts: • Remove dust and loose dirt with a vacuum cleaner. • Remove light stains and soil with Ford Extra Strength Upholstery Cleaner (E8AZ-19523–AA). • If grease or tar is present on the material, spot-clean the area first with Motorcraft Spot and Stain Remover (ZC-14).
Page 172 FORD, LINCOLN AND MERCURY CAR CARE PRODUCTS Your Ford, Lincoln or Mercury dealer has many quality products available to clean your vehicle and protect its finishes. These quality products have been specifically engineered to fulfill your automotive needs; they are custom designed to complement the style and appearance of your vehicle.
Page 173 Motorcraft Triple Clean (ZC-13) Motorcraft Ultra-Clear Spray Glass Cleaner (not available in Canada) (ZC-23) Motorcraft Engine Shampoo and Degreaser (ZC-20) * May be sold with the Motorcraft name 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 174: Maintenance And Specifications
1. Set the parking brake and shift to P (Park). 2. Block the wheels. Do not start your engine with the air cleaner removed and do not remove it while the engine is running. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 175: Hood
2. Go to the front of the vehicle and release the latch located in the center between the hood and the grille. 3. Lift the hood. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 176 4. Engine oil dipstick 5. Brake fluid reservoir 6. Power distribution box 7. Clutch fluid reservoir 8. Battery 9. Power steering fluid reservoir 10. Air filter assembly 11. Engine coolant reservoir 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 177: Engine Oil
1. Make sure the vehicle is on level ground. 2. Turn the engine off and wait a few minutes. 3. Set the parking brake and place the gearshift in P (Park). 4. Open the hood. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 178 4. Install the dipstick and engine oil filler cap. Note: Do not operate the vehicle with the dipstick and/or the engine oil filler cap removed. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 179: Battery
WSS-M2C205–A. It is also recommended that you use the appropriate Motorcraft oil filter or an equivalent filter meeting the Ford Motor Company specification for your engine. Change your engine oil and filter according to the Scheduled Maintenance Guide. BATTERY Your vehicle is equipped with a...
Page 180 2. Put the gearshift in P (Park), turn off all accessories and start the engine. 3. Run the engine until it reaches normal operating temperature. 4. Allow the engine to idle for at least one minute. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 181 Adding engine coolant section. Your vehicle was factory-filled with a 50/50 engine coolant and water concentration. If the concentration of coolant falls below 40% or above 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 182 When adding coolant, make sure it is a 50/50 mixture of engine coolant and distilled water. Add the mixture to the coolant reservoir, when the engine is cool, until the appropriate fill level is obtained. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 183 If sprayed on the windshield, engine coolant could make it difficult to see through the windshield. • Add Motorcraft Premium Gold Engine Coolant (yellow-colored), VC-7–A (VC-7–B in Oregon), meeting Ford Specification WSS-M97B51–A1. Note: Use of Motorcraft Cooling System Stop Leak Pellets, VC-6, may darken the color of Motorcraft Premium Gold Engine Coolant from yellow to golden tan.
Page 184 Recycled engine coolant Ford Motor Company does NOT recommend the use of recycled engine coolant in vehicles originally equipped with Motorcraft Premium Gold Engine Coolant since a Ford-approved recycling process is not yet available.
Page 185 Vehicles driven year-round in non-extreme climates should use a 50/50 mixture of engine coolant and distilled water for optimum cooling system and engine protection. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 186 • Be particularly careful if you are taking “Antabuse” or other forms of disulfiram. Breathing fuel vapors or skin contact could cause sickness or serious personal injury. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 187 Aftermarket products could cause damage to the fuel system and invalidate your warranty. Cleaner air Ford endorses the use of reformulated “cleaner-burning” gasolines to improve air quality. Running out of fuel Running out of fuel may have an adverse affect on powertrain components.
Page 188 The advertised fuel capacity of the fuel tank on your vehicle is equal to the rated refill capacity of the fuel tank as listed in the Refill capacities section of this chapter. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 189 Keep a record for at least one month and record the type of driving (city or highway). You can also keep records in summer and winter to determine how temperature impacts fuel economy. Note that ethanol decrease fuel economy. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 190 • Avoid running out of fuel. • Do not turn off your ignition while the vehicle is moving. • Follow your Scheduled Maintenance Guide. • Use Ford Motor Company authorized parts for maintenance replacements or for service. Consult your Warranty Guide for emission warranty information.
Page 191 To ready the system, allow the vehicle to sit for at least eight hours without starting. Then, start the engine and complete the following driving cycle: 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 192 If the fluid levels are outside of the normal operating range, the performance of your brake system could be compromised, seek service from your dealer immediately. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 193 10. Fluid can be checked at ambient temperatures between 10–30°C (50–95°F). DO NOT ADD fluid until the transmission is at normal operating temperatures or the transmission will be overfilled. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 194 Checking and adding manual transmission fluid (if equipped) 1. Clean the filler plug. 2. Remove the filler plug and inspect the fluid level. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 195 5. Install and tighten the fill plug securely. Use only fluid that meets Ford specifications. Refer to Lubricant Specifications in this chapter. TRANSFER CASE FLUID (IF EQUIPPED) To check and add transfer case fluid 1.
Page 196 10 to 12 inches or limited production tires as defined in Title 49 Code of Federal Regulations Part 575.104(c)(2). U.S. Department of Transportation-Tire quality grades: The U.S. Department of Transportation requires Ford to give you the following information about tire grades exactly as the government has written it. Treadwear...
Page 197 Improperly inflated tires can affect vehicle handling and can fail suddenly, possibly resulting in loss of vehicle control, vehicle rollover and/or personal injury. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 198 • Five tire rotation To make sure your tires wear evenly, rotate them as indicated in the Scheduled Maintenance Guide. If your tires wear unevenly, have them checked. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 199 Tires that are larger or smaller than your vehicle’s original tires may affect the accuracy of your speedometer. 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 200: Part Numbers
Your tires have all-weather treads to provide traction in the rain and snow. In some climate, using snow tires or traction devices may be necessary. For Motor Company offers tire cables as a Ford approved accessory and recommends use of these or SAE class “S” cables. See your dealer for more information.
Page 201: Refill Capacities
Motorcraft SAE Refer to 2.9-3.1L lubricant 80W-90 Premium Footnote 6 (5.5-5.8 pints) Rear Axle Lubricant Motorcraft SAE Refer to 75W-140 High Footnote 7 Performance Synthetic Rear Axle Lubricant 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 202 Add 118 ml (4 oz.) of Additive Friction Modifier XL-3 or equivalent meeting Ford specification EST-M2C118–A for complete refill of Traction-Lok axles. Service refill capacity for the manual transmission is determined by filling the transmission to the bottom of the filler hole with the vehicle on a level surface.
Page 203: Lubricant Specifications
CXO-5W20–LSP12 Certification 5W-20 Super (Canada) Mark Premium Motor Oil (Canada) Automatic Motorcraft transmission XT-5-QM MERCON V MERCON V ATF (5R55E) Motorcraft 4–speed manual MERCON XT-2-QDX MERCON transmission Multi-Purpose 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 204 MERCON and MERCON V. Refer to your scheduled maintenance guide to determine the correct service interval. Conventional rear axles are filled with Motorcraft SAE 80W-90 Premium Rear Axle Lubricant, part number XY-80W90-QL, Ford specification WSP-M2C197-A. Traction-Lok rear axles are filled with Motorcraft SAE 75W-140 High Performance Synthetic Rear Axle Lubricant, part number XY-75W140–QL, Ford specification WSL-M2C192-A.
Page 205 1823 (71.8) (3) Vehicle height/ Maximum 1776 (69.9)/1794 (70.6)* height* (4) Wheelbase 3198 (125.9) (5) Front track /Rear track 1486 (58.5)/1480 (58.3) *Denotes a 4x4 vehicle with 16” tires 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 206 Maintenance and Specifications 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 207 Engine number The engine number (the last eight numbers of the vehicle identification number) is stamped on the engine block, transmission, frame and transfer case (if equipped). 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 208: Accessories
Not all accessories are available for all models. Following is a list of several Ford Genuine Accessory products. Not all accessories are available for all models. To find out what accessories are available for your vehicle, please contact your dealer or visit our online store at: www.fordaccessories.com.
Page 209 Trailgate table (hitch installed) Protection and appearance equipment Cargo liners— soft, interior Cargo organizer Carpeted cargo mat Cargo tray — hard, interior Cover — front end (full, sport) Door edge guards 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 210 • Ford cannot assume responsibility for any adverse effects or damage that may result from the use of such equipment. 2003 P207 Explorer Sport Trac (p27)
Page 211: Engine Compartment
..152 washing ........168 maintenance-free ....179 waxing ........168 replacement, specifications ...200 wheels ........169 servicing ........179 wiper blades ......170 BeltMinder ........82 Clock adjust Single CD ........16 Brakes ........111 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 212 ....200 conditions ....116, 121, 124 fuel pump shut-off switch ..136 sand .........123 octane rating ......205 snow and ice ......125 Fuel pump shut-off switch ..136 through water ......125 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 213 Instrument panel automatic dimming rearview cleaning ........171 mirror ........48 cluster ........10 fold away ........49 side view mirrors (power) ..48 Moon roof ........51 Motorcraft parts ......200 Jump-starting your vehicle ..152 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 214 ....201 lubricant specifications ..203, 205 Seats ..........71 manual operation ....117 child safety seats ......97 Trunk ...........59 Spare tire (see Changing the Tire) ....145 Turn signal ........34 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)
Page 215: Table Of Contents
(VIN) ..........207 power .........45 power down back window ..45 Vehicle loading ......126 Windshield washer fluid and camper bodies ......133 wipers ..........40 Ventilating your vehicle ...110 replacing wiper blades .....40 2003 P207 Explorer Sport Trac (p27) Owners Guide (post-2002-fmt) USA English (fus)

This manual is also suitable for:

2003 p207 explorer sport trac

Ford P207 Explorer Sport Trac Owner's Manual

Introduction

Instrument Cluster

Entertainment Systems

Climate Controls

Lights

Driver Controls

Locks and Security

Seating and Safety Restraints

Driving

Roadside Emergencies

Quick Links

Table of Contents

Related Manuals for Ford P207 Explorer Sport Trac

Summary of Contents for Ford P207 Explorer Sport Trac

This manual is also suitable for:

Table of Contents