Page 1
75580G-M 79580G-B instruction booklet gas hob...
Page 2
Thank you for choosing one of our high-quality products. To ensure optimal and regular performance of your appliance please read thisinstruction manual carefully. It will enable you to navigate all processes perfectlyand most efficiently. To refer to this manual any time you need to, we recommendyou to keep it in a safe place. And please pass it to any future owner of the appliance.
Contents For the User Important Safety Information ......................4 Description of the hob .......................... 6 Operation ..............................7 Maintenance and Cleaning ........................9 Something Not Working ? ........................11 Guarantee/Customer Service ......................26 European Guarantee ..........................28 For the Installer Technical data ............................
English Important safety information You MUST read these warnings carefully before installing or using the hob. If you need assistance, contact our Customer Care Department on 08705 350350. Installation • This appliance must be installed and • Children can also injure themselves by serviced by a competent person as stated pulling pans or pots off the hob.
Page 5
cause an accident by tipping or spillage. • Never leave the hob unattended when The symbol on the product or cooking with oil and fats. on its packaging indicates that this product • Never use plastic or aluminium foil dishes may not be treated as household waste.
Description of the hob 1. Hob Top 2. Semi-rapid Burners 3. Auxiliary Burner 4. Triple Crown Burner 5. Control knob for left burner (triple crown) 6. Control knob for back middle burner (semi-rapid) 7. Control knob for front middle burner (auxiliary) 8.
activated automatically. Operation Do not keep the control knob pressed Hob burner control knobs for more than 15 seconds. The symbols on the knobs mean: If the burner does not light even after 15 seconds, release the control knob, = no gas supply turn it the "off"...
Page 8
Once the hob has been installed, it is important to remove any protective materials, which were put on in the factory. Burner minimum maximum diameter diameter Triple crown 180 mm 280 mm Semi-rapid rear middle 120 mm 240 mm rear right 120 mm 240 mm front right...
Mainteinance and Cleaning Before any maintenance or cleaning can be carried out, you must DISCONNECT the hob from the electricity supply. The hob is best cleaned whilst it is still warm, as spillage can be removed more easily than if it is left to cool. This appliance cannot be cleaned with steam or with a steam cleaning machine.
Page 10
The burners The burner caps and crowns can be removed for cleaning. Wash the burners taps and crowns using hot soapy water, and remove marks with a mild paste cleaner. A well moistened soap impregnated steel wool pad can be used with caution, if the marks are particularly difficult to remove.
Something Not Working? If the hob is not working correctly, please carry out the following checks before contacting your local Service Force Centre. SYMPTOM SOLUTION There is no spark when lighting the Check that the unit is plugged in and gas.
Technical data Engineer technical data OVERALL DIMENSIONS Glass cooktop models: Width: 740 mm Depth: 510 mm Stainless steel models: Width: 745 mm Depth: 515 mm CUT OUT DIMENSIONS Width: 560 mm Depth: 480 mm SUPPLY CONNECTIONS Gas: R 1/2 inch (1/2 inch male) Rear right hand corner Electric: 230 V ~ 50 Hz supply, 3 core flexible cable with non rewireable plug fitted with a 3 amp cartridge...
Gas burners BURNER SEMI-RAPID AUXILIARY TRIPLE CROWN TYPE OF GAS POSITION MAX MIN NOMINAL THERMAL POWER 0.45 0.33 NATURAL GAS NOMINAL FLOW 20 mbar RATE 0.181 0.043 0.095 0.031 0.362 0.114 VALUE = 37.78 MJ/m NOZZLE REFERENCE 9 6 Adjust. 7 0 Adjust.
Important Safety Requirements This hob must be installed in accordance with the Gas Safety (Installation and Use) Regulations (Current Edition) and the IEE Wiring Regulations (Current Edition). For appliances installed in the Republic of Ireland please refer to NSAI- Domestic Gas Installation I.S.
IMPORTANT This hob must be installed by a competent person to the relevant Gas Standards. Any gas installation must be carried out by a registered competent person. Please, ensure that, once the hob is installed, it is easily accessible for the engineer in the event of a breakdown.
Location The hob may be located in a kitchen, a kitchen/diner or bed sitting room, but not in a bathroom, shower room or garage. Ensure that there is a minimum distance of 55 mm between the rear cut out edge and the wall.
Fitting the Hob into the Worktop Carry out the building in of the hob as follows: 1) Remove the pan supports, the burners caps and crowns and turn the hob upside down, taking care the ignition candles are not damaged in this operation.
Building In Building over a cupboard or drawer If the hob is to be installed above a cupboard or drawer it will be necessary to fit a heat resistant board below the base of the hob on the underside of the work surface. It is also recommended to carry out the electrical connection to the hob as shown in diagrams 1 and 2.
Electrical Connections Any electrical work required to install this hob should be carried out by a qualified electrician or competent person, in accordance with the current regulations. THIS HOB MUST BE EARTHED. The manufacturer declines any liability should these safety measures not be observed. This hob is designed to be connected to a 230 V 50 Hz AC electrical supply.
Permanent Connection In the case of a permanent connection, it is necessary that you install a double pole switch between the hob and the electricity supply (mains), with a minimum gap of 3 mm between the switch contacts and of a type suitable for the required load in compliance with the current electric regulations.
Fault Finding Preliminary Electrical Systems Check Blue Brown Green Yellow START Isolate appliance Blue and carry out: A: Earth Continuity Green Brown check. Yellow Carry out: Carry out: D: Resistance to C: Polarity check. Earth check. Has inlet fuse blown? Electricity supply should now be satisfactory.
Page 22
A. EARTH CONTINUITY CHECK Appliance must be electrically disconnected - meter set on W (Ohms) x 1 scale and adjust zero if necessary. — Test leads from any appliance earth point to earth pin on plug. Resistance should be less than 0.1 W (Ohm), check all earth wires for continuity and all contacts clean and tight.
Page 23
Ignition System / Gas Ignition Check gas supply at Ignitor does not spark burner Check plug top fuse and Light burner manually replace if necessary Check by pass simmer Check polarity and earth adjusted continuity of supply point Check fitting of Check position of the Check earth continuity burners...
Commissioning When the hob has been fully installed it will be necessary to check the minimum flame setting. To do this, follow the procedure below. 1) Turn the gas tap to the MAX position and ignite. 2) Set the gas tap to the MIN flame position then turn the control knob from MIN to MAX several times.
Conversion from Natural Gas to Liquid Gas IMPORTANT The replacement/conversion from natural gas to LPG should only be undertaken by a competent person. It is important to note that this model is designed for use with natural gas but can be converted for use with butane or propane gas providing the correct injectors are fitted.
Guarantee/Customer Service Standard guarantee conditions We, AEG-Electrolux, undertake that if within 12 months of the date of the purchase this AEG-Electrolux appliance or any part thereof is proved to be defective by reason only of faulty workmanship or materials, we will, at our option repair or replace the same FREE OF CHARGE for labour, materials or carriage on condition that: •...
Service and Spare Parts In the event of your appliance requiring service, or if you wish to purchase spare parts, please contact your local Service Force Centre by telephoning 0870 5 929 929 Your telephone call will be automatically routed to the Service Force Centre covering your postcode area.
European Guarantee This appliance is guaranteed by Electrolux in each of the countries listed at the back of this user manual, for the period specified in the appliance guarantee or otherwise by law. If you move from one of these countries to another of the countries listed below the appliance guarantee will move with you subject to the following qualifications: •...