Download  Print this page

AEG Powertools AGN5000DEB Original Instructions Manual

Diesel portable generator
Hide thumbs


Original Instructions



  Related Manuals for AEG Powertools AGN5000DEB

  Summary of Contents for AEG Powertools AGN5000DEB

  • Page 1 AGN5000DEB DIESEL PORTABLE GENERATOR Original Instructions...
  • Page 2: Recoil Starter

    Fig. 1 FUel cap FUel leVel gaUge FUel tank recoil starter recoil starter grip grip Drainage bolt Fig. 2 oil cap / Dipstick FUel leVel gaUge oil cap/ Dipstick FUel tank FUel cap FUel cap Fig. 3 Fig. 4 oil Fill hole...
  • Page 3 air Filter FUel cock Fig. 5 Fig. 6 air Filter coVer Filter elements air Filter coVer Fig. 7 alternator enD coVer ignition keY Fig. 8...
  • Page 4 FUel cock Filter o-ring seDiment Fig. 9 FUel FUel line cock Fig. 10 petcock...
  • Page 5: Important Safety Instructions

    English Wear sturdy and dry shoes or boots. Do not operate while INTRODUCTION barefoot. This product has many features for making its use more pleasant Do not operate generator when you are tired or under the and enjoyable. Safety, performance, and dependability have influence of drugs, alcohol, or medication.
  • Page 6: Specific Safety Rules

    English Do not touch the muffler or cylinder during or spECIfIC sAfETy RULEs immediately after use; they are HOT and will cause burn injury. WARNING: When this generator is used to supply a building Do not connect to a building’s electrical system unless a wiring system: generator must be installed by transfer switch has been properly installed by a qualified a qualified electrician and connected to a...
  • Page 7 English Some of the following symbols may be used on this tool. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to operate the tool better and safer. SYMBOL NAME DESIGNATION/EXPLANATION Volts Voltage Amperes Current Hertz Frequency (cycles per second)
  • Page 8 English SYMBOLS The following signal words and meanings are intended to explain the levels of risk associated with this product. SYMBOL SIGNAL MEANING Indicates an imminently hazardous situation, which, if not avoided, will result in death DANGER: or serious injury. Indicates a potentially hazardous situation, which, if not avoided, could result in death WARNING: or serious injury.
  • Page 9: Extension Cord Cable Size

    English ELECTRICAL EXTENSION CORD CABLE SIzE Refer to the table below to ensure the cable size of the extension cords you use are capable of carrying the required load. Inadequate size cables can cause a voltage drop, which can burn out the appliance and overheat the cord. Load in Watts Maximum Allowable Cord Length Current in...
  • Page 10 English ELECTRICAL CAUTION: Do not overload the generator’s capacity. Exceeding the generator’s wattage/amperage capacity can damage the GENERATOR CAPACITY generator and/or electrical devices connected to it. Make sure the generator can supply enough continuous (running) and surge (starting) watts for the items you will power Typical at the same time. Follow these simple steps. Continu- Typical Surge 1.
  • Page 11 English fEATUREs AC CIRCUIT BREAKER Model AGN5000DEB The circuit breaker is provided to protect the generator against AC Output electrical overload and can be used to turn the generator’s electrical power on or off. AC Frequency (Hz) AIR FILTER AC Output voltage (V)
  • Page 12: Operation

    English FEATURES PACKING LIST Generator Supply kit RECEPTACLES Operator’s Manual Your generator has the following single phase, 50 Hz outlets: two 230 Volt AC, 16 Amp receptacle. These can be used for operating appropriate appliances, electrical lighting, tools, WARNING: and motor loads. If any parts are damaged or missing do not operate this product until the parts are replaced. Failure to RECOIL STARTER GRIP...
  • Page 13 English OpERATION contaminated diesel, and do not use an oil/diesel mixture. Do not allow dirt or water into the fuel tank. WARNING: Do not allow familiarity with tools to make you CAUTION: careless. Remember that a careless fraction of a On a level surface with the engine off, check the oil second is sufficient to inflict serious injury. level before each use of the generator. WARNING: AC OPERATION Do not use any attachments or accessories not Unplug all loads from the generator.
  • Page 14: Maintenance

    English OpERATION mAINTENANCE An overloaded DC circuit, excessive current draw by the battery, WARNING: or a wiring problem will trip the DC circuit protector (PUSH When servicing, use only identical RYOBI button extends out). If this happens, wait a few minutes before replacement parts. Use of any other parts may pushing in the circuit protector to resume operation.
  • Page 15 English DRAINING FUEL TANK mAINTENANCE When not using a fuel stabiliser, draining the fuel from the NOTE: Used oil should be disposed of at an approved tank before storage may help prevent gum deposits in the disposal site. See your local oil retailer for more information. fuel system.
  • Page 16: Maintenance Schedule

    English mAINTENANCE MAINTENANCE SCHEDULE Daily First month or Every 3 months Every 6 months Every year or Item check 20 Hrs or 100Hrs or 300Hrs 1000 Hrs Check and refill fuel Check and refill lube oil Check for oil leakage Tighten head Check and tighten each engine part bolts (2nd and Change lube oil (1st time) thereafter) Clean oil filter (Clean) (Replace) (Service more frequently Replace air cleaner element (Replace) when used in dusty areas) Clean fuel filter (Clean) (Replace) Check fuel injection nozzle (Replace if Check fuel pipe necessary) Adjust valve clearance for intake and (1st time) exhaust valves Check the level of battery electrolyte Monthly...
  • Page 17: Troubleshooting

    English TROUBLE shOOTING TROUBLE SHOOTING Possible Cause Actions Fuel oil is not enough. Add oil. Fuel nozzle can not inject fuel or there is Remove the fuel injector and get it repaired. no enough fuel. The speed control lever is not in «RUN» position. Turn the speed control lever to "RUN" position. The specified of oil level should be between upper level "H" and lower Inappropriate amount of lubricant. level "L". The speed and force to pull the recoil starter is Start the diesel engine according to the requirements of operating not enough. procedure of start. The fuel nozzle is dirty. Clean the fuel nozzle. Circuit breaker is not closed. Put the circuit breaker to "ON" position. The connection of socket is not good. Adjust the feet of socket. The rated speed of generator can not be Adjust it according to the requirements. reached. Carbon brush worn. Change the carbon brush. AVR worn. Change the AVR. Check all the connections: Check the diode and terminals which should be fastened; Low current while welding. Test output open circuit voltage of flywheel generator, it should be 105V Check all the terminals of connectors; Current is unadjustable while welding. Check the mutual induction appliance;...
  • Page 18: Wiring Diagram

    English WIRING DIAGRAm AGN5000DEB...
  • Page 20: Limited Warranty

    LIMITED WARRANTY TTI warrants this outdoor product to be free of defects in material and workmanship for 24 months from the date of purchase by the original purchaser, subject to the limitations below. Please keep your invoice as proof of date of purchase. This warranty is only applicable where the product is used for personal and non-commercial purposes.
  • Page 21 Tsuen Wan, Hong Kong. Tel.: (+45) 43 56 55 55 Tel : + 852 2402 6888 Fax: (+45) 43 56 55 56 Machine: Diesel Portable Generator Type: AGN5000DEB Name of company: Homelite Far East Co., Ltd. Name / title: Sven Eschrich Address:...