Summary of Contents for Cub Cadet Fire & Rescue 642
Page 1
Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized service dealer or contact the service department, P.O. Box 368023 Cleveland, Ohio 44136-9722. CUB CADET LLC P.O. BOX 361131 CLEVELAND, OHIO 44136-0019 769-00863B.fm PRINTED IN U.S.A.
Customer Dealer Referral Line or an authorized service dealer. Copy the model number here: Copy the serial number here: CUB CADET LLC P. O. BOX 361131 www.cubcadet.com CLEVELAND, OH 44136...
SECTION 1: IMPORTANT SAFE OPERATION PRACTICES WARNING: This symbol points out important safety instructions which, if not followed, could endanger the personal safety and/or property of yourself and others. Read and follow all instructions in this manual before attempting to operate or service this vehicle. When you see this symbol - heed its warning.
Children 25. Do not start or operate vehicle in an inside area, unless it is adequately ventilated. Engine exhaust 1. Tragic accidents can occur if the operator is not contains carbon monoxide fumes, which are very alert to the presence of children. Children are often poisonous and can be deadly.
Page 5
3. When using electric lift: d. Keep the nozzle in contact with the rim of the • Stay in driver’s seat. fuel tank or container opening at all times • Keep body parts away from cargo box and keep all until fueling is complete.
Page 6
WARNING WARNING • This is an off-road utility vehicle. Do not operate AVOID INJURY WHEN USING CARGO BOX LIFT on public highways. It handles and maneuvers differently than a normal passenger car. Sharp, Read and understand operator's manual for lifting, loading and unloading high speed turns or abrupt maneuvers can instructions.
SECTION 2: KNOW YOUR UTILITY VEHICLE NOTE: Reference to right or left hand side of the utility vehicle is observed from the operating position. Figure 1 Brake Pedal Read this operator’s manual, safety labels, and operating instructions on the vehicle before operating. The brake pedal is located on the left side of the floor Compare the illustrations in this manual with your unit beneath the dash panel.
12V Power Outlet • To engage the parking brake, push brake pedal down firmly, pull out on the parking brake latch, and The 12V power outlet is located on the right side of the release foot from brake pedal. Brake pedal will stay dash panel.
Hour Meter Fuel Shut Off Valve The hour meter is located in the center of the warning The fuel shut off valve is located under the seat and it is light cluster. It reads the elapsed time engine has run. strapped onto the fuel tank.
Tailgate The tailgate can be hinged at the top or the bottom Cargo Box depending on how you release the holding pins. If you pull out on the two top pins, the tailgate will swing down. If you pull out the two bottom pins, you can pivot the tailgate upwards.
Page 11
WARNING: Do not stop or start suddenly • Park the vehicle safely and turn key to the RUN when going uphill or downhill. Be especially position. cautious when changing direction on slopes. • Raise cargo box by pressing and holding top of Apply brakes when going down slopes to electric lift switch.
Loading the Cargo Box Towing Loads WARNING: The utility vehicle may become WARNING: To help prevent personal injury unstable cargo loaded due to loss of control or tipping, always tow a incorrectly. Avoid loose and shifting loads or load slowly enough to maintain control. uneven loading of material.
Page 13
Battery Jumper Cables WARNING: battery produces flammable and explosive gas. Do not smoke near battery. Wear eye protection and gloves when handling the battery. Do not allow direct metal contact across battery posts.The battery is sealed and is maintenance-free. Acid levels cannot be checked and fluid can Booster Battery Disabled Battery not be added.
99 link chain. DO NOT USE a 97 link chain or less. Figure 16 • If chain is still loose after installing a new 98 pitch chain, see your Cub Cadet dealer. • Raise rear of vehicle with a safe lifting device and place support stands under vehicle. Chain Adjusters •...
Add approximately 189 oz (5.5 liters) of Shell TTF- • Raise and secure cargo box, if manual lift. SB Oil (Cub Cadet Part No. 737-3120 or 737-3121). Dirt and debris in oil may cause damage to • Check oil level by screwing dipstick fully into IMPORTANT: transaxle.
Adjusting Brake Adjusting Throttle Pedal The wet brake system is an internal part of the The throttle pedal assembly can be adjusted for comfort transmission and it is adjusted externally without slightly higher or lower by lining up the holes of the opening the transmission.
Storage Prepare fuel system for storage. If planning to store vehicle with fuel tank empty: • Stop the vehicle on a level surface and apply • Add a small quantity of fresh stabilized fuel to tank. parking brake. Run engine until it runs out of fuel. This will circulate •...
Battery will not take a Dead battery. charge Loose or corroded connections. Sulfated or worn-out battery. Fluid level low. NOTE: For repairs beyond minor adjustments or corrections, contact your nearest Cub Cadet service dealer or call 1-877-282-8684.
CUB CADET CORPORATION MANUFACTURER’S ONE YEAR LIMITED WARRANTY (COMMERCIAL USE) The limited warranty set forth below is given by CUB CADET CUB CADET does not extend any warranty for LLC (“CUB CADET”) with respect to new merchandise products sold or exported outside of the United...
MANUFACTURER’S LIMITED WARRANTY FOR: (RESIDENTIAL USE) The limited warranty set forth below is given by Cub Cadet possessions and territories, except those sold through LLC with respect to new merchandise purchased and used in Cub Cadet’s authorized channels of export the United States, its possessions and territories.