Transmission Oil - Yamaha PW80(W) Owner's Manual

Transmission oil

The transmission oil level should be
checked before each ride. In addition,
the transmission oil must be changed
at the intervals specified in the periodic
maintenance and lubrication chart.
To check the transmission oil level
1
2
3
1
4
1. Transmission oil filler cap
2. Dipstick
3. Maximum level mark
4. Minimum level mark
1. Place the vehicle on a level sur-
face and hold it in an upright posi-
tion.
NOTE:
Make sure that the vehicle is positioned
PERIODIC MAINTENANCE AND MINOR REPAIR
straight up when checking the oil level.
EAU19942
A slight tilt to the side can result in a
false reading.
2. Wait a few minutes until the oil set-
tles, remove the oil filler cap, wipe
the dipstick clean, insert it back
into the oil filler hole (without
screwing it in), and then remove it
again to check the oil level.
NOTE:
The transmission oil should be be-
tween the minimum and maximum lev-
el marks.
3. If the oil is below the minimum lev-
el mark, add sufficient oil of the
recommended type to raise it to
the correct level.
4. Insert the dipstick into the oil filler
hole, and then tighten the oil filler
cap.
To change the transmission oil
1. Transmission oil drain bolt
1. Place an oil pan under the trans-
2. Remove the oil filler cap and drain
3. Install the transmission oil drain
4. Add the specified amount of the
6-7
1
mission to collect the used oil.
bolt to drain the oil from the trans-
mission.
bolt, and then tighten it to the spec-
ified torque.
Tightening torque:
Transmission oil drain bolt:
20 Nm (2.0 m·kgf, 14.5 ft·lbf)
recommended transmission oil,
and then install and tighten the oil
filler cap.
2
3
4
5
6
7
8
9