1. Manuals
  2. Brands
  3. Heartland Manuals
  4. Wood stove
  5. Artisan
  6. Installation and operating instructions manual

Heartland Artisan Installation And Operating Instructions Manual

Hide thumbs Also See for Artisan:
Table of Contents

Advertisement

Quick Links

Download this manual
Business (519) 650-5775 Fax (519) 650-3773 Toll Free Phone: 1-877-650-5775 Toll Free Fax: 1-800-327-5609
Installation and Operating Instructions
SAVE THESE
INSTRUCTIONS FOR
FUTURE USE.
Note: Please read this entire
manual before you install
and use your new room
heater. Failure to follow
instructions may result in
property damage, bodily
injury or even death.
SAFETY NOTICE: If this stove is not properly installed, a
house fire may result, for your safety, follow the
installation directions, contact local building or fire officials
about restrictions and installation inspection requirements
in your area.
IMPORTANT: Check around oven chamber on a weekly
basis for soot and creosote accumulation. Clean the
chamber thoroughly from the top, side and bottom with
the rake provided. Burn the stove hot daily to reduce
creosote accumulation. Use only dry wood aged for one
year. Failure to do so could result in chimney fire and
void the warranty.
ATTENTION INSTALLER: Leave this manual with the appliance.
PLEASE NOTE: Specifications contained in this manual are subject to change without notice
02156
1050 Fountain St N. Cambridge, Ontario, Canada N3H-4R7
The Artisan
The Artisan is listed to
ULC Standard S-627 &
UL 1482 in Intertek
Testing Services NA
Ltd.
© 2009 HEARTLAND APPLIANCES INC.
WOODSTOVES
The temperature registered by the oven door
thermometer may not necessarily correspond with the
reading taken with a thermometer inside the oven.
OVERFIRING CAUTION
Repeated or extended overfiring
will void warranty on this
appliance. See page 18 for
details.
06/09 EINS 515000

Advertisement

Table of Contents
loading

Related Manuals for Heartland Artisan

Summary of Contents for Heartland Artisan

  • Page 1 1050 Fountain St N. Cambridge, Ontario, Canada N3H-4R7 Business (519) 650-5775 Fax (519) 650-3773 Toll Free Phone: 1-877-650-5775 Toll Free Fax: 1-800-327-5609 The Artisan Installation and Operating Instructions The Artisan is listed to ULC Standard S-627 & UL 1482 in Intertek Testing Services NA Ltd.

  • Page 2: For Your Safety

    FOR YOUR SAFETY DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPOURS OR LIQUIDS IN THE VICINITY OF THIS STOVE. Stove Location - If the stove must be located near a window, avoid using long curtains which could blow over the stove top, causing a fire hazard.
  • Page 3 2. Warranty applies to product only in the country in which it was purchased. 3. Heartland is not liable for any claims or damages resulting from any failure of the Wood Cookstove or from service delays beyond their reasonable control.

  • Page 4: Table Of Contents

    TABLE OF CONTENTS 1) Welcome ........................... Pg 5 2) Installation ......................... Pg 6 3) Installation Requirements ....................Pg 7 4) Clearances Single Wall Connector .................. Pg 8 5) Clearances Listed Double Wall Connector ..............Pg 9 6) Installing the Chimney Connector ..................Pg 10 7) Wall Pass-Through ......................

  • Page 5: Welcome

    The test standards are ULC S-627 for Canada and UL 1482 for U.S. The Artisan is listed for burning wood only. Do not burn other materials or garbage. The Artisan is not listed for installation in mobile homes. Do not install the stove in...

  • Page 6: Installation

    Installation Place the stove in the intended position and lift out the using to the clearance specified. Failure to do so will result hotplate, checking that the joint between the underside of in an unsafe condition. the hob and the top of the stove is intact. Any joints which Unit must be placed on a continuous non-combustible pad have opened shoud be made good with the fire cement (floor tile with grouting or sheet metal pad) extending...

  • Page 7: Installation Requirements

    Model Heartland Artisan Ensure these specifications apply to the model you have purchased. Changes may occur in product specification from time to time. Please contact Heartland for the most up-to-date, as it Help Desk applies to the product being purchased, or download latest Site Preparation Specifications from 877-650-5775 www.heartlandapp.com.

  • Page 8: Clearances Single Wall Connector

    Model Heartland Artisan Ensure these specifications apply to the model you have purchased. Changes may occur in product specification from time to time. Please contact Heartland for the most up-to-date, as it Help Desk applies to the product being purchased, or download latest Site Preparation Specifications from 877-650-5775 www.heartlandapp.com.

  • Page 9: Clearances Listed Double Wall Connector

    Model Heartland Artisan Ensure these specifications apply to the model you have purchased. Changes may occur in product specification from time to time. Please contact Heartland for the most up-to-date, as it Help Desk applies to the product being purchased, or download latest Site Preparation Specifications from 877-650-5775 www.heartlandapp.com.

  • Page 10: Installing The Chimney Connector

    6. Do not use single wall chimney connector as an outside chimney. The Heartland Artisan has the ability to connect stove pipe out the top of the flue box vertically or out the back of the 7. Never pass a chimney connector through a flue box horizontally.

  • Page 11: Wall Pass-Through

    Wall Pass-Through Factory Built Chimney Design your installation so that your connector does not Chimneys manufactured in a factory must be tested and pass through a combustible wall. If you must pass listed to ULC S629 (Can.) or Type HT chimneys in the through, check with a local building inspector before you Standard for Chimneys, Factory-Built Residential Type begin.

  • Page 12: Chimney And Draft

    Chimney and draft Chimney Maintenance The chimney is the most important element of a Chimneys serving woodburning appliances must be successful stove operation. The chimney ‘drives’ the checked for creosote build-up. Until you are familiar with system by producing the draft that draws in combustion air the rate of creosote build-up in the system, check it often and exhausts smoke and gases to outdoors.

  • Page 13: Users Instructions

    Users Instructions General Fuelling with Wood WARNING: HOT SURFACES, use the tool supplied to Woodburning operate this appliance. When raising the dome lids, it The firewood used will make an important contribution to is recommended that the heatproof glove supplied successful operation.

  • Page 14: Door Operation

    Door Operation To open the doors. Use the utensil provided to turn the door release screw 1/4 turn counter-clockwise. OVEN DOOR OPERATION - The screw will back off enough to open the door. It is not possible to open the lower door without first opening the To open the doors.

  • Page 15: Refuelling

    Refuelling Cleaning of the Bottom Grate The firebox should be filled to the recommended level at Due to an accumulation of ash and other material, it may the middle of the firebox door opening. not be possible to pass through the grate. Allow the fire to burn out and then open the ashpit door.

  • Page 16: Break-In Fire

    Break-In Fire Flue Chamber Damper SMOKE/SMELL EMITTED DURING INITIAL USAGE. The adjustable flue chamber damper is for chimney draft. Some parts of the stove have been coated with a light The more it is closed, the easier it is to control the heat. covering of protective oil.

  • Page 17: Flueway Cleaning

    Damaged firebricks should be replaced as soon as possible but it may be temporarily repaired with the stove cement. The firebricks fitted to the Heartland Artisan are of first quality manufacture, and providing the stove has been installed and used correctly will have a reasonable life.

  • Page 18: Fresh Air Kit

    Insulation board firebrick front 1 characteristic of a wood fire. If the smoke does not burn, it will condense in the chimney forming creosote or exit the Please contact your Heartland dealer for information. chimney as air pollution. Servicing Charcoal: As the fire progresses and most of the gases have vaporized, charcoal remains.

  • Page 19: Over Firing

    Overfiring - Caution! Overfiring of your woodburning appliance represents a serious fire hazard Overfiring can also warp your stove, break welds, permanently discolour the enamel and cause premature burnout of your stove. Repeated overfirings will void the warranty of the appliance. To prevent overfiring: If the air intake has little effect on dampering the fire, excessive chimney draft is the probable cause (especially on chimneys in excess of 20’).

  • Page 20: Trouble Shooting

    Trouble Shooting Chimneys and Draft Chimney Height Taller chimneys tend to produce stronger draft. We The performance of your woodburning system depends recommend that the top of the chimney should be at least more on the chimney than on any other single component. 36”...

  • Page 21: Cooking Instruction

    Masonry chimneys should be checked for deterioration Safety Practices including damaged bricks, crumbling and missing mortar, cracks in the drip cap at the top of the chimney, and loose What to do if you have a chimney fire flashings at the roof line. The liner should be checked for cracks and mis-alignment.
  • Page 25 1050 Fountain St N. Cambridge, Ontario, Canada N3H-4R7 Business (519) 650-5775 Fax (519) 650-3773 Toll Free Phone: 1-877-650-5775 Toll Free Fax: 1-800-327-5609 The Artisan Cooking Instructions The temperature registered by the oven door thermometer may not necessarily correspond with the...

  • Page 26: Stove Top Cooking

    Be sure to read it entirely, including the terms of reference and function. The Artisan is listed for burning wood only. Do not burn other materials or garbage. Successful stove top and oven cooking will result from using a heated stove and baking the fire to retain the heat required.
  • Page 27 Top Oven Cooking Bottom Oven Cooking It is not possible to control this oven, but during the course The oven door thermometer registers the temperature at of roasting, sufficient heat input allows the simmering of the door only. Oven temperatures vary from top to bottom dishes that have been taken from the roasting oven.
  • Page 28 519-650-5775. Our office hours are from 8:30 am to 5.00 pm. est. For our complete line of kitchen appliances, visit our website at www.heartlandapp.com or phone 1-877-650-5775 and ask to speak to a sales representative For pricing please call your dealer, or call Heartland Appliances (519) 650-5775 or Fax (519) 650-3773...

Table of Contents