To Replace Headlight Bulb; Interlocks And Relays; To Replace Fuse; To Remove Hood And Grill Assembly - Poulan Pro PD185H42STA Owner's Manual

SERVICE AND ADJUSTMENTS
• Lift seat pan to raised position.
• DisconnectBLACKbattery cable first then RED battery
cable and carefully remove battery from tractor.
• Install new battery with terminals in same positionas
old battery.
• FirstconnectRED battery cable to positive(+) terminal
with hex boltand keps nut as shown. Tighten securely.
Slide terminal cover over terminal.
• Connect BLACK grounding cable to negative (-) ter-
minal with remaining hex bolt and keps nut. Tighten
securely.
SEAT PAN
TERMINAL
COVER
FIG. 29
KEPS
HEX
POSITIVE (RED) NEGATIVE
CABLE (BLACK) CABLE
FIG. 30
TO REPLACE HEADLIGHT BULB
• Raise hood.
• Pull bulb holderout of the hole in the backside of the
grill.
• Replace bulb in holder and push bulb holder securely
back into the hole in the backside of the grill.
• Close hood.
INTERLOCKS AND RELAYS
Loose or damaged wiring may cause your tractor to run
poorly, stop running, or prevent it from starting.
• Check wiring. See electrical wiring diagram in the
Repair Parts section.
TO REPLACE FUSE
Replace with 20 amp automotive-type plug-in fuse. The
fuse holder is located behind the dash.
TO REMOVE HOOD AND GRILL ASSEMBLY
(See Fig. 31)
Raise hood.
Unsnap headlight wire connector.
Stand infrontoftractor. Grasp hood at sides, tilttoward
engine and lift off of tractor.
• To replace, reverse above procedure.
HEADLIGHT
WIRE
CONNECTOR
FIG. 31
ENGINE
TO ADJUST THROTTLE CONTROL CABLE
The throttle control has been preset at the factory and
adjustment should not be necessary. If adjustment is nec-
essary, see engine manual.
TO ADJUST CHOKE CONTROL
The choke control has been preset at the factory a nd ad-
justment should not be necessary. If adjustment is neces-
sary, see engne manual.
TO ADJUST CARBURETOR
Your carburetor is not adjustable. If your engine does not
operate properly due to suspected carburetor problems,
take your tractor to an authorized service center for repair
and/or adjustment.
23