Page 1
Owner's Manual NOTE TO INSTALLER: THIS MANUAL MUST BE LEFT WITH THE EQUIPMENT USER. USER: PLEASE READ INSTRUCTIONS IN THE MANUAL RETAIN MANUALS FUTURE REFERENCE. FIRE OR EXPLOSION HAZARD Failure to follow warnings could result in personal injury, death, or property damage.
Page 2
TO TODAY'S GENERATION OF COMFORT Always AsR For Congratulations! In light of rising energy costs, a 90+% AFUE Condensing Gas Furnace from Payne Heating & Cooling Systems is among the soundest investments today's homeowner can make. Your furnace is truly...
Page 3
FURNACE COMPONENTS Furnace shown in upflow position; be used in downflow or horizontal orientation or applications. HOT SURFACE IGNITER MANUAL RESET GAS BURNER ROLLOUT SWITCH FLAME MANUAL RESET ROLLOUT SWITCH GAS VALVE MAIN LIMIT SWITCH BEHIND GAS VALVE) OPERATINGINSTRUCTIONS NOT SHOWN(LOCATED MAIN FURNACE DOOR, OPERATINGINSTRUCTIONS...
Page 4
SAFETY CONSIDERATIONS Installing and servicing of heating equipment can be hazardous to gas and electrical components. Only trained and qualified FIRE OR EXPLOSION HAZARD personnel should install, repair, or service heating equipment. Failure to follow warnings could result in personal injury, Untrained personnel...
Page 5
Some insulation materials may be combustible. • Should the gas supply fail to shut off or if overheating occurs, shut off the gas valve to the furnace before shutting off electrical FIRE OR EXPLOSION HAZARD supply. Failure to follow this warning could result in personal iniury, This furnace contains...
Page 6
i" I '--"1 A92319 Fig. 6 - Do Not Light Burner with Match • Read and follow the operating instructions on inside of A06188 main furnace door, especially the item that reads as fol- Fig. 8 - Close Valve lows: (See Fig.
Page 7
TWO4TAGE GAS CONTROL CONTROL SWITCH SHOWN IN "OFF" POSITION A92359 Al1320 Fig. 14 - Turn on Electrical Supply Fig. 11 - Control Switch to OFF 9. Open the external manual gas valve, See Fig. 15. 6. After waiting five minutes, turn control switch on the gas con- trol to the ON position.
Page 8
TWO4TAGE GAS CONTROL gatherings in your home, etc. Simply change your FAN from 1 to 3 seconds AUTO depending your thermostat), and then return to ON. The blower will switch to the next higher speed. There are at least three speeds to choose from.
Page 9
b. Slide air filter out of furnace. Keep dirty side up (if dirty) to avoid spilling dirt. See Fig. 23 and 24. 3. Inspect the filter. If torn replace CUT HAZARD NOTE: If a washable filter was suppliedwith the furnace and has Failure been replaced...
Page 10
A00226 A00228 Fig. 22 - Removal of Filter Cabinet Door from Bottom Fig. 24 - Removal of Filter from Bottom Blower Cabinet Blower Cabinet A00229 A00227 Fig. 25 - Replacement of Filter Cabinet Door to Side Blower Cabinet Fig. 23 - Removal of Filter from Side...
Page 11
COMBUSTION VENT SYSTEM SURFACE IGNITOR BURNER ASSEMBLY FLAME SENSOR CARBON MONOXIDE POISONING HAZARD MANUAL RESET UMIT SWITCH Olt+P+'_ LIMIT SWITCH (BEHIND VALVE) VALVE Failure to follow this warning could result in personal iniury MAIN UMIT SWITCH or death. If holes are found or if the vent pipe is obstructed or is not connected,...
Page 12
WINTERIZATION 7. Pour 1 quart of anti-freeze solution into the funnel/tube. Antifreeze should run through the inducer housing, overfill condensate trap and flow to an open drain. 8. If condensate pump used, check with pump manufacturer to verify pump is safe for use with antifreeze []NIT AND PROPERTY DAMAGE...
Page 13
A CHECK-UP CHECKLIST BEFORE REQUEST Your furnace represents an important investment in your family's "SERVICE CALL" comfort and your home's value. To keep it performing properly If your furnace is not operating or not performing properly, and to prevent future problems, have a trained service specialist save the expense of a service...
Page 14
INDOOR COIL (Furnace Coil or Fan Coil) Model # Technician Name Serial # NOTE TO INSTALLER: This manual must be left with the equipment owner. ':r 2012 Payne Heating & Cooling Systems • 7310 W. Morris St. • Indianapolis, IN 46231 Edition Date:...