Advertisement
Natural Gas
If your grill is for Natural Gas, it is set for a 7-in. water
column (WC) and is for use with Natural Gas only. Gas
pressure is affected by gas line size and the length of
gas line run from house gas line. Follow the
recommendations in the chart below.
From House to Grill
Distance
Tubing Size
Up to 25 ft.
3/8 in. diameter
26-50 ft.
1/2 in. diameter
2/3 of the run: 3/4 in. diameter
51-100 ft.
1/3 of the run :1/2 in. diameter
Over 101 ft.
3/4 in. diameter
Helpful Care and Maintenance Hints
Before grilling, pre-heat grill for 15 minutes on "HI" with
hood down. To avoid uncontrolledflare-ups or grease
fires, grill meats with hood open. Close hood if meats are
thick or weather is cold, or if you are using a rotisserie or
indirect cooking.
Always protect your hand with a pot holder or cooking
glove when coming into contact with a hot surface.
Hood up when grilling meats, especially chicken. Hood
down when indirect or rotisserie cooking.
NEVER leave your grill unattendedwhile cooking.
After use, close hood, turn burners to HIfor 15 min. for
self-cleaning, grease burn off.
Excess Flow Control and Low Heat
The propane regulator assembly incorporatesan excess
flow device designed to supply the grill with sufficient gas
flow under normal conditions yet control excess gas flow.
Rapid changes in pressure can trigger the excessflow
device providing a low flame and low temperature. If the
tank valve is turned open to allow gas flow while a burner
valve is open, the surge of pressure will cause the device
to activate. The device will remain closed until the
pressure is equalized. This should occur within 5
seconds.
To ensure this does not cause difficulty in lighting the grill,
follow these instructions:
1. Make sure all burner valves are "OFF".
2. Open the tank valve and wait 5 seconds.
3. Light the burners one at a time following the lighting
instructions.
Care and Maintenance Time TableChart
Grill Item
FrequencyBased
on Normal Use
CleaningMethod
Paintedsurface
Twiceyearly
Car wax
Stainlesssurface
Twiceyearly
Stainlesscleaner
All grates
After each use
Burn off and wipe
Wire brush/
Stainlessgrates
15 days
Dishwashersafe
Scrub pad soapy water
Porcelaingrates
15 days
/Dishwashersafe
Burner heat tents
30 days
Wire brush
Burners
90 days
Wire brush
Burner box
Interior grill cleaning
120 days
products(availableat
interior
sears)
12
Advertisement
