Alwaysstop engine,disconnectsparkplug wire, andground againstengine
before performing anytype of maintenanceon your machine.
GENERAL RECOMMENDATIONS
Always observe safetyruleswhenperforminganymaintenance.
Thewarrantyonthislawnmowerdoesnotcoveritems that havebeen
subjected to operatorabuse or negligence. Toreceive full valuefrom
warranty, o peratormustmaintainthe equipment a s
instructed here.
Changing of engine-governed s peed will voidengine warranty.
All adjustments shouldbe checked a t leastonceeachseason.
Periodically c heck all fasteners andmakesurethesearetight.
ENGINE MAINTENANCE
SparkPlug
Forgoodperformance, the sparkplug mustbe properly gapped andfreeof
deposits. R eplace t he sparkplug annually or every100hours.
1.
Disconnect the capfrom the sparkplug,andremove anydirt from the spark
plugarea.
2.
Use the propersizesparkplug wrench to remove the sparkplug.
NOTE: Replace w ith aChampion QC12YC sparkplug.
3.
Check thegapwitha wiregauge. S eeFigure 15.Spark plug gapshouldbe
0.030in(0.76mm).If necessary, resetthe gap.
4.
Installandtightenthe sparkplugto the recommended t orque(20ft. lb. [27
am]).
5.
Attachthe sparkplug capto the sparkplug.
Air Cleaner
Adirty air cleaner w ill restrictairflow to thecarburetorandcause poorengine
performance. Inspect t he filter eachtime the engineisoperated. Y ouwill needto
cleanthe filter morefrequentlyif youoperate the engineinverydustyareas.
Clean the air cleaner e very25hoursofoperationor oncea season. R eplace t he air
cleaner a nnually or every50hours.
Neverstart or run the engine with the air cleanerassemblyor the air filter
removed.
flOTE: D onot usepressurized a iror solvents to cleanthe filter. Pressurized air can
damage thefilter andsolvents will dissolve the filter.
1.
Loosen knobandremove air cleaner c over. S eeFigure 16.
2.
Remove p recleaner ( If Equipped) andair filter from base.
3.
Replace o r washprecleaner i nwarmwaterwith detergent.Rinse andallow
toairdry.
f
Electrode
Porcelain
1
Figure15
.J
f
6.
7.
Predeaner
Air Filter
J
Figure 16
Toloosendebrisinair filter,gentlytap the filter on ahardsurface. I f thefilter
isexcessively dirty,replace with a newfilter.
Installelement w ith pleatedsideout andseatrubbersealontoedges of
base.
Reinstall predeaner i ntocover, a ligningholeinprecleaner with coverknob.
Reinstall aircleaner c overandsecure with knob.
15