Storage; Cleaning; Terminals - Craftsman EZ3 917.258591 Owner's Manual

immediately prepare your tractor' for storage at the end of
the season or if the tractor will not be used for 30 days or
mo re
I X CAUTION: Never store the tractor with !
| • • gasoline in the tank inside a building !
| _ where fumes may reach an open flame |
| U or spark. Allow the engine to cool I
! before storing in any enclosure. !
TRACTOR
Remove mower from tractor for winter storage.. When
mower is to be stored for a period of time, clean it thor-
oughiy, remove all dirt, grease, leaves, etc. Store in a
clean, dry area,
• Clean entire tractor (See"CLEANING" in the Customer
Responsibilities section of this manual).
• Inspect and replace belts, if necessary (See belt re-
placement instructionsin the Service and Adjustments
section of this manual).
Lubricate as shown in the Customer Responsibilities
section of this manual.
I
m
Be sure that all nuts, bolts and screws are securely
fastened. Inspect moving parts for damage, breakage
and wear. Replace if necessary.
Touch up all rusted or chipped paint surfaces; sand
_ightly before painting°
BATTERY
• Fully charge the battery for storage.
. After a period of time in storage, battery may require
recharglng_
° To help prevent corrosion and power leakage during
long periods of storage, battery cables should be
disconnected and battery cleaned thoroughly (see "TO
CLEAN BATTERY AND TERMINALS in the Cus-
tomer Responsibilities section of this manual).
• After' cleaning, leave cables disconnected and place
cables where they cannot come in contact with battery
terminals.
• Be sure battery drain tube is securely attached.
, If battery is removed from tractor for storage, do not
store battery directly on concrete or damp surfaces.
ENGINE
FUEL SYSTEM
IMPORTANT: 1T IS IMPORTANT TO PREVENT GUM
DEPOSITS FROM FORMING IN ESSENTIAL FUEL
SYSTEM PARTS SUCH AS CARBURETOR, FUEL FILTER,
FUEL HOSE, OR TANK DURING STORAGE. ALSO,
EXPERIENCE INDICATES THAT ALCOHOL BLENDED
FUELS (CALLED GASOHOL OR USING ETHANOL OR
METHANOL) CAN ATTRACT MOISTURE WHICH LEADS
TO SEPARATION AND FORMATION OF ACIDS DURING
STORAGE. ACIDIC GAS CAN DAMAGE THE FUEL
SYSTEM OF AN ENG(NE WHILE _N STORAGE.,
° Drainthe fueltank.
• Start the engine and let it run until the fuel lines and
carburetor are empty.
• Never use engine or carburetorcleaner products in the
fuel tank or permanent damage may occur.
° Use fresh fuel next season_
NOTE: Fuel stabilizer is an acceptable alternative in
minimizing the formation of fuel gum deposits during stor-
age. Add stabilizer to gasoline in fuel tank or storage
container. Always follow the mix ratio found on stabilizer
container. Run engine at least 10 minutes after' adding
stabilizer to allow the stabilizer to reach the carburetor. Do
not drain the gas tank and carburetor if using fuel stabilizer.
ENGINE OIL
Drain oil (with engine warm) and replace with clean engine
clio (See "ENGINE" in the Customer Responsibilities
section of this manual).
CYLINDERS
• Remove spark plug(s).
° Pour one ounce of oil through spark plug hole(s) into
cylinder(s)o
° Turn ignitionkey to"START" positionfor a few seconds
to distribute oil
° Replace with new spark plug(s).
OTHER
• Do not store gasoline from one season to another_
• Replace your'gasoline can if your can starts to rust.
Rust and/or dirt in your gasoline will cause problems.
• If possible, store your tractor indoors and cover it to
give protection from dust and dirt.
• Cover your'tractor with a suitable protective covetthat
does not retain moisture. Do not use plastic. Plastic
cannot breathe which allows condensation to form and
will cause your tractor to rust.
IMPORTANT: NEVER COVER TRACTOR WHILE ENGINE
AND EXHAUST AREAS ARE STILL WARM_
28