12.5 hp electric start 38" mower 5 speed transaxle lawn tractor (56 pages)
Summary of Contents for Craftsman 917.270741
Page 1
Read and follow all Safety about this product, Call: 1-800-659-5917 Rules and Instructions before operating this equipment. Sears Craftsman Help Line 5 am - 5 pm, Mon- Sat Sears, Roebuck and Co., Hoffman Estates, II 60179 Visit our Craftsman website:www.sears.com/craftsman...
Page 2
Parts Ordering .....Back Cover LIMITED TWO YEAR WARRANTY ON CRAFTSMANRIDING EQUIPMENTPARTS For two (2) years from the date of purchase, if this Craftsman Riding Equipment is maintained, lubricated and tuned up according to the instructions in the owner's manual, Sears will repair or replace, free of charge, any parts found to be defective in material or workmanship.
SLOPEOPERATION IMPORTANT; This cutting machine is capable of amputating hands and feet Slopes are a major factor related to loss- and throwing objects. Failure to observe of-control and tipover accidents, which the following safety instructions could can result in severe injury or death. All result in serious injury or death.
Page 4
• Before and when backing, look behind • Keep nuts and bolts, especially blade and down for small children. attachment bolts, tight and keep • Never carry children. They may fall off equipment in good condition. and be seriously injured or interfere •...
_Look for this symbol to point out ,_LCAUTION: Tow only the attachments important safety precautions. It means that are recommended by and comply CAUTION!!! BECOMEAWARE!!! YOUR with specifications of the manufacturer _FETY IS INVOLVED. your tractor. Use common sense when CAUTION: In order to prevent towing.
Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure proper tightness.
Page 8
• Release parking brake by depressing clutch/brake pedal. Label • Place freewheel control in freewheel- ing position to disengage transmission Terminal (See "TO TRANSPORT" in the Battery Operation section of this manual). Door • Roll tractor forward off skid. • Remove banding holding discharge...
Page 9
_,CAUTION: Do not remove deflector CHECKLIST shield from mower. Raise and hold Before you operate and enjoy your new shield when attaching mulcher plate and tractor, we wish to assure that you allow it to rest on plate while in opera- receive the best performance tion.
Page 10
These symbols may appear on your tractor or in literature supplied with the _roduct. Learn and understand their meaning. BATTERY CAUTION OR REVERSE FORWARD FAST SLOW WARNING ENGINE ON ENGINE OFF OIL PRESSURE LIGHTS ON OVER TEMP LIGHT FUEL CHOKE MOWER HEIGHT PARKING BRAKE UNLOCKED...
Page 11
KNOWYOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. Switch Ignition Switch Attachment Clutch Lift Ammeter...
Page 12
The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing adjustments or repairs. We recommend a wide vision safety mask over spectacles or standard safety glasses.
Page 13
• The average lawn should be cut to ACAUTION: Do not operate the mower approximately 2-1/2 inches during the without either the entire grass catcher, cool season and to over 3 inches mowers so equipped, or the deflector during hot months. For healthier shield in place.
NOTE: To protect hood from damage Do not mix oil with gasoline. Purchase when transporting your tractor on a truck fuel in quantities that can be used or a trailer, be sure hood is closed and within 30 days to assure fuel fresh- ness.
Page 15
WARM WEATHER STARTING (50 ° F and IMPORTANT: Should your transmission require removal for service or replace- above) ment, it should be purged after reinstalla- • When engine starts, move the throttle tion before operating the tractor. control to the fast position. •...
MULCHING MOWING TIPS MOWING TIPS • Mower should be properly leveled for IMPORTANT: For best performance, best mowing performance. See "TO keep mower housing free of built-up LEVEL MOWER HOUSING" in the grass and trash. Clean after each use. • The special mulching blade will recut Service and Adjustments...
FILL AS COMPLETE IN DATES _O_l:)_J'_O_'_ REGULAR SERVICE Check Brake Operation Check Tire Pressure Check Operator Presence Interlock Systems Check for Loose Fasteners V ° Lubrication Chad Check Battery Level Sharpen/Replace Mower Blades Clean Battery and Terminals Check Transaxle Cooling Adjust Blade Belt(s)
Page 18
TRACTOR • Install new or resharpened blade with trailing edge up towards deck as Always observe safety rules when shown. performing any maintenance. IMPORTANT: To ensure proper assem- BRAKE OPERATION bly, center hole in blade must align with If tractor requires more than six (6) feet star on mandrel assembly.
Page 19
BATTERY TRANSAXLE PUMP FLUID Your tractor has a battery charging The transaxle was sealed at the factory system which is sufficient for normal use. and fluid maintenance is not required for the life of the transaxle. Should the However, periodic charging of the battery with an automotive charger will extend...
• Use gauge on oil fill cap/dipstick • If very dirty or damaged, replace pre- cleaner. checking level. Be sure dipstick cap is tightened securely for accurate • Reinstall pre-cleaner over cartridge. • Reinstall cover and secure with reading. Keep oil at "FULL" line on knob(s).
Page 21
• Keep finished surfaces and wheels free of all gasoline, oil, etc. • Protect painted surfaces with automo- tive type wax. We do not recommend using a garden hose to clean your tractor unless the CLEANING electrical system, muffler, air filter and •...
Page 22
TO LEVEL MOWER HOUSING • If links are not equal in length, adjust one link to same length as other link. Adjust the mower while tractor is parked • To lower front of mower loosen nut "E" on level ground or driveway. Make sure on both front links an equal number of tires are properly...
Page 23
TO REPLACE MOTION DRIVE BELT • Make sure belt is in all pulley grooves and inside all belt guides. Park the tractor on level surface. • Install mower in reverse order of gage parking brake. For assistance, removal instructions. there is a belt installation guide decal on Mandrel bottom side of left footrest.
Page 24
• While holding motion control lever in NOTE: To seal tire punctures place, loosen the adjustment bolt. prevent flat tires due to slow leaks, tire • Move motion control lever to the sealant may be purchased from your neutral (N) (lock gate) position. local parts dealer.
Page 25
Positive Terminal TO REPLACE HEADLIGHT BULB Negative Terminal • Raise hood. • Pull bulb holder out of the hole in the backside of the grill. • Replace bulb in holder and push bulb holder securely back into the hole in the backside of the grill.
Page 26
• With engine not running, move throttle FINAL SETTING - control lever from slow to choke • Start engine and allow to warm for five position. Slowly move lever from minutes. Make final adjustments with choke to fast position. engine running and shift/motion •...
ethanol or methanol) can attract moisture Immediately prepare your tractor for which leads to separation and formation storage at the end of the season or if the tractor will not be used for 30 days or of acids during storage. Acidic gas can more.
TROUBLESHOOTING CHART PROBLEM CAUSE CORRECTION • Outof fuel. Will not start • Fill fuel tank. • Engine not "CHOKED" • See'q-O START ENGINE" properly. in Operation section. • Wait several minutes before • Engine flooded. attempting to start. • Bad spark plug. •...
Page 29
TROUBLESHOOTING CHART PROBLEM CAUSE CORRECTION Loss of power • Cutting too much grass/too • Set in "Higher Cut" position/ fast. reduce speed. • Throttle in "CHOKE" • Adjust throttle control. position. • Clean underside of mower • Build-up of grass, leaves and trash under mower.
Page 30
TROUBLESHOOTING CHART PROBLEM CAUSE CORRECTION Mower blades will • Obstruction in clutch • Remove obstruction. not rotate mechanism. • Worn/damaged mower • Replace mower drive belt. drive belt. • Frozen idler pulley. • Replace idler pulley. • Frozen blade mandrel. •...
TRACTOR - - MODEL NUMBER 917.270741 GROUND DRIVE...
Page 37
TRACTOR - - MODEL NUMBER 917.270741 GROUND DRIVE PART PART DESCRIPTION DESCRIPTION STD551143 Washer Transaxle (See Breakdown) 154778 Keeper Belt Engine Hydro Hydro Gr 314-O510 134683 Keeper Belt Engine 165866 Rod Shift Fender Adjust 169183 Strap Torque Lh Hydro STD561210 Pin Cotter 1/8 x 1 CAD Washer 13/32 x 1-1/4 x 12 Ga.
Page 54
TRACTOR - - MODEL NUMBER 917.270741 BRIGGS & STRATTON ENGINE-MODEL NO. 311707, TYPE NO. 0132-E3 PART PART DESCRIPTION DESCRIPTION 690464 Valve-Choke (Manual Cho 690156 Cylinder Assembly 108A692344 Valve-Choke (Choke A Ma Bushing/Seal 399265 108B695419 Choke Valve -# Seal-Oil 391086 692408 •...
Page 55
TRACTOR - - MODEL NUMBER 917.270741 BRIGGS & STRATTON ENGINE-MODEL NO. 311707, TYPE NO. 0132-E3 PART PART DESCRIPTION DESCRIPTION 693551 Motor-Starter (For Steel Ring 783B693058 Gear-Pinion (For Plastic Ring Gear Only) Gear Only) 497595 Motor-Starter (For Plastic 695050 Harness- Wiring Ring Gear Only) 693167 Nut (Brush Retainer)
Page 59
SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION ONLY RIDE UP AND DOWN HILL, "" NOT ACROSS HILL SIGHTING GUIDE greater than 15°), never across the face. Make turns gradu- Operate your Tractor up and down the face of slopes (not ally to prevent tipping or loss of control.
Page 60
For repair of major brand appliances in your own home... no matter who made it, no matter who sold it! 1-800-4-MY-HOME SM Anytime, day or night (1-800-469-4663) www, sears.com To bring in products such as vacuums, lawn equipment and electronics for repair, call for the location of your nearest Sears Parts &...