Vulcan-Hart C24EA6 ML-136058 Installation & Operation Manual

C24ea series electric convection steamers
Hide thumbs Also See for C24EA6 ML-136058:

Advertisement

C24EA SERIES
ELECTRIC CONVECTION
STEAMERS
C24EA6
ML-136058
C24EA10
ML-136059
For additional information on Vulcan-Hart or to locate an authorized parts
and service provider in your area, visit our website at www.vulcanhart.com.
VULCAN-HART
DIVISION OF ITW FOOD EQUIPMENT GROUP, LLC
WWW.VULCANHART.COM
INSTALLATION &
OPERATION MANUAL
0
5
10
60
15
55
20
50
25
45
40
30
35
READY
COOK
0
5
10
60
15
55
20
50
25
45
30
40
35
READY
COOK
DELIME
O
3600 NORTH POINT BLVD.
BALTIMORE, MD 21222
F35430 (05-07)

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the C24EA6 ML-136058 and is the answer not in the manual?

Questions and answers

Summary of Contents for Vulcan-Hart C24EA6 ML-136058

  • Page 1 READY COOK C24EA10 ML-136059 DELIME For additional information on Vulcan-Hart or to locate an authorized parts and service provider in your area, visit our website at www.vulcanhart.com. VULCAN-HART 3600 NORTH POINT BLVD. DIVISION OF ITW FOOD EQUIPMENT GROUP, LLC BALTIMORE, MD 21222 WWW.VULCANHART.COM...
  • Page 2: Important For Your Safety

    SERVICE OR MAINTENANCE CAN CAUSE PROPERTY DAMAGE, INJURY OR DEATH. READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING OR SERVICING THIS EQUIPMENT. IN THE EVENT OF A POWER FAILURE, DO NOT ATTEMPT TO OPERATE THIS DEVICE. © VULCAN-HART, 2007 — 2 —...
  • Page 3: Installation Codes And Standards

    INTRODUCTION GENERAL full responsibility for safe delivery upon acceptance of the shipment. Vulcan convection steamers are produced with Immediately after unpacking, check for possible quality workmanship and material. Proper installation, shipping damage. If steamer damage is found, usage and maintenance will result in many years of save the packaging material and contact the satisfactory performance.
  • Page 4: Leveling And Anchoring

    C24EA SERIES ELECTRIC CONVECTION STEAMERS LOCATION Allow space for plumbing and electrical connections. Minimum clearance is 6" (15.2 cm) on the back for proper air circulation. Allow adequate access for operating and servicing the steamer: 36" (91.4 cm) at the front of the steamer, 15"...
  • Page 5: Electrical Connection

    C24EA SERIES ELECTRIC CONVECTION STEAMERS ELECTRICAL CONNECTION WARNING: ELECTRICAL AND GROUNDING WARNING: DISCONNECT THE ELECTRICAL POWER TO THE CONNECTIONS MUST COMPLY WITH MACHINE AND FOLLOW LOCKOUT / APPLICABLE PORTIONS OF THE NATIONAL TAGOUT PROCEDURES. ELECTRICAL CODE AND / OR OTHER LOCAL ELECTRICAL CODES.
  • Page 6: Plumbing Connections

    Vulcan Hart, please use these Water Treatment guidelines. • If you are going to delime the unit with a...
  • Page 7 C24EA SERIES ELECTRIC CONVECTION STEAMERS • If you have purchased a water filtration system from Vulcan Hart, please follow the instructions provided with the water filtration system. At the time of installation you must register your steamer at www.vulcanhart.com/filterreg or use the reply card supplied with your unit.
  • Page 8 C24EA SERIES ELECTRIC CONVECTION STEAMERS STARTUP 4. Close the compartment door. The cooking WARNING: THE STEAMER AND ITS PARTS and ready lights should now be lit, and ARE HOT. USE CARE WHEN OPERATING, steam should be heard entering the CLEANING OR SERVICING THE STEAMER. compartment.
  • Page 9: Operation

    COOK light turns off. To silence the buzzer, turn the timer to the OFF position. READY Light (Green) When lit, indicates steamer is ready for the Refer to Steam Cooking with Vulcan Kettles and cooking cycle. Steamers (packed with your steamer) for — 9 —...
  • Page 10: Daily Shutdown

    C24EA SERIES ELECTRIC CONVECTION STEAMERS suggested cooking times. Also refer to the COOKING GUILDELINES in this manual. Size, weight, pan loading and product quality will affect cooking times and should be adjusted to your own requirements. DAILY SHUTDOWN 1. Press the power switch to the OFF position. 2.
  • Page 11 C24EA SERIES ELECTRIC CONVECTION STEAMERS CLEANING WARNING: DISCONNECT THE COMPARTMENTS ELECTRICAL POWER TO Wash the inside of the compartment with a THE MACHINE AND FOLLOW LOCKOUT / solution of warm water and non-chloride TAGOUT PROCEDURES BEFORE detergent. Rinse with warm water. CLEANING.
  • Page 12 C24EA SERIES ELECTRIC CONVECTION STEAMERS Avoid rubbing with steel pads, wire brushes or scrapers that can leave iron deposits on stainless steel. Instead, use plastic scouring pads or soft cloths. For stubborn stains, use products such as Cameo , talc or Zud First Impression .
  • Page 13: Maintenance

    C24EA SERIES ELECTRIC CONVECTION STEAMERS MAINTENANCE Items Required (not provided) WARNING: THE STEAMER AND ITS PARTS ARE HOT. USE CARE WHEN OPERATING, • Deliming material (Recommend "Scale CLEANING OR SERVICING THE STEAMER. Release") THE COOKING COMPARTMENT CONTAINS LIVE STEAM. STAY CLEAR WHILE OPENING •...
  • Page 14 C24EA SERIES ELECTRIC CONVECTION STEAMERS Note: Lights will illuminate on the delime switch and on the power switch, indicating that the deliming cycle has begun. The cycle will take about 60 minutes to complete. As the deliming cycle nears completion, the light on the power switch will turn off.
  • Page 15: Cooking Guidelines

    C24EA SERIES ELECTRIC CONVECTION STEAMERS COOKING GUIDELINES The steamer steam cooks vegetables, the best results. Variables which affect cooking frankfurters, eggs in their shells, and certain other time include size, weight, thickness of foods, meats or food items at atmospheric pressure. temperature, density, previous condition of the foods (fresh, pre-blanched or frozen) and degree These cooking guidelines are suggestions only.
  • Page 16: Products To Be Cooked In Perforated Pans

    C24EA SERIES ELECTRIC CONVECTION STEAMERS PRODUCTS TO BE COOKED IN PERFORATED PANS PRODUCT TIME (MINUTES) QUANTITY PER PAN SEAFOOD Clams Frozen 9 - 12 3 Doz. Fresh, Cherrystone 4 - 6 3 Doz. King Crab, Frozen Claws 3 - 4 2 1/2 Lb.
  • Page 17 C24EA SERIES ELECTRIC CONVECTION STEAMERS PRODUCT TIME (MINUTES) QUANTITY PER PAN VEGETABLES (Cont’d.) Broccoli Spears, Frozen 6 - 8 4 Lb. Spears, Fresh 4 - 6 5 Lb. Flowerettes, Frozen 4 - 6 5 Lb. Cabbage, Fresh, 1/6 Cut 6 - 8 5 Lb.
  • Page 18: Troubleshooting

    Water filter is plugged Refer to water filter manual. If symptom persists, contact your Authorized Vulcan-Hart Servicer. Valve inlet screen clogged Contact your Authorized Vulcan- Hart Servicer. Steam is exiting from under Generator pressure is too high Contact your Authorized Vulcan- Hart Servicer.
  • Page 19 C24EA SERIES ELECTRIC CONVECTION STEAMERS NOTES — 19 —...
  • Page 20: Service And Parts Information

    To obtain service and parts information concerning this steamer, contact the Vulcan-Hart Service Agency in your area (refer to listing supplied with the steamer), or contact the Vulcan-Hart Service Department at the address or phone number shown on the front cover of this manual. Parts and service are also available at www.vulcanhart.com.

This manual is also suitable for:

C24ea10C24ea6Ml-136059

Table of Contents