M A T E R I A L S A F E T Y D A T A S H E E T
Conforms to Workplace Hazardous Materials Information System (WHMIS) Rev. November, 1988
The Lincoln Electric Company of Canada LP
179 Wicksteed Avenue
Toronto, Ontario M4G 2B9 CANADA
Phone: (416) 421-2600
I M P O R T A N T !
This section covers the materials from which this product is manufactured. The fumes and gases produced during welding with the normal use of this
product are covered by Section VII; see it for industrial hygiene information.
CAS Number shown is representative for the ingredients listed.
(1)
The term "hazardous" in "Hazardous Ingredients" should be interpreted as a term required and defined in the Hazardous Products Act and does
not necessarily imply the existence of any hazard.
Ingredients:
Magnesite
Aluminum oxide and/or Bauxite
Fluorides (as F)
Mineral silicates
Silicates and other binders
Manganese and/or manganese alloys and compounds (as Mn)
Nickel (metal)
Silicon and/or silicon alloys and compounds (as Si)
Quartz
Iron
Crystalline-Silica (cristobalite)
Vanadium alloys (as V)
Notes:
(*)
Not listed. Nuisance value maximum is 10 milligrams per cubic
meter. TLV value for iron oxide is 5 milligrams per cubic meter.
(**)
As respirable dust. Value for respirable quartz is 0.1 milligrams
per cubic meter.
(@)
As V
0
fume or dust.
2
5
Physical data such as odor, vapor pressure, density, evaporation rate and freezing or boiling points are not listed as they are not applicable to this product and
its use.
Non Flammable; Welding arc and sparks can ignite combustibles and flammable products. See CSA W117.2 Section 9.7 as referenced in Section VIII.
Product is inert, no special handling or spill procedures required.
Rev 9/07
For Welding Consumables and Related Products
Section I & II - Preparation and Product Information
Section III - Hazardous Ingredients (1)
Section IV - Physical Data
Section V - Hazard Data
Date:
1/5/2009
Trade Name:
MIL 800 HPNi
Sizes:
---
Supersedes:
9/10/2007
Product Type:
Representative Classifications:
Prepared by The Lincoln Electric Company, Cleveland, Ohio, USA
(216) 481-8100, on the date shown above.
TLV
CAS No. Wt. %
mg/m
1309-48-4
30-60
1344-28-1
10-30
7789-75-5
10-30
1332-58-7
10-30
1344-09-8
5-10
7439-96-5
1-5
7440-02-0
1-5
7440-21-3
0.1-1
14808-60-7
0.1-1
#0.05**
7439-89-6
0.1-1
14464-46-1
0.1-1
#0.025**
7440-62-2
0.1-1
.05(@)
(LDLo, LCLo) Lowest published toxic concentration.
(#)
Crystalline silica (quartz) is on the IARC (International
Agency for Research on Cancer) and NTP (National
Toxicology Program) lists as posing a carcinogenic risk to
humans.
MSDS No.:
CAN-F27
Submerged Arc Flux
AWS F8A6-ENi1K-G-H2
F9A4-ENi5-G-H2
LD
50
3
(Route/Species)
10
Not Available
10
Not Available
4250 mg/kg
2.5
(oral/rat)
590 g/kg LDLo
5**
(oral/rat) reproductive
1153 mg/kg
10*
(oral/rat)
9 g/kg
0.2
(oral/rat)
50 mg/kg LDLo
1.5
(intravenous/mouse)
10*
Not Available
200 mg/kg LDLo
(intratracheal/rat)
10*
Not Available
10,000 mg/kg
(oral/rat)
10 mg/kg LDLo
(oral/rat)
(CONTINUED ON SIDE TWO)
3
LC
mg/m
50
(Route/Species)
Not Available
Not Available
Not Available
Not Available
Not Available
2.3 LCLo
(inhalation/human)
Not Available
Not Available
300 LCLo
(inhalation/human)
Not Available
Not Available
346 mg LCLo
(inhalation/human)